Jump to content
SAU Community

Recommended Posts

For those who do have probs just check your soldering job. The tracks are very close in spots and thats necessary to keep the size of the unit down. Its very easy to short out a component if you are not careful. Use a magnifying glass to check the circuit board after its been built and clean the board after you have soldered the components with a small plastic brush to remove any metalic contaminants.

Hope thats of some help

Regards

Bov

  • Replies 91
  • Created
  • Last Reply

Top Posters In This Topic

  • 2 weeks later...

may do another batch later on, but realistically that wouldnt be before feb (the boards themselves may take up to a month to get done)

would also want a bit more feedback on what would be good to improve if i was to. currently i have:

1. fix yellow led

2. make those 2 tight spaced components more room

3. more room so crystal can lay flat (look into low profile crystal)

4. look into 4024 14 pin counter (replace 4060 16 pin)

5. IC sockets rather than soldering into pcb (given pcb sits lower than i originally designed means theyll fit)

6. change pcb a bit where leds go to make it square (originally that cutout bit wasnt supposed to be cutout by pcb manufacturers)

7. dont use that stupid packaging tape as it leaves the boxes sticky!

8. finally, see how difficult it would be to put USB on same board

Edited by NewKleer

I kind of like how the LEDs poke through the screw holes for the Serial ports, but i also think its important to be able to lock the serial cables onto the unit. Since many of these will be mounted permanently there is a chance that they could vibrate loose without the DB9 connector screws...

its pretty difficult to put the nuts onto the connectors (ive not idea how ud do it without glueing them on, unless u just somehow use the existing holes where leds go thru as the nut). its pretty dam tight fit for the connectors to go together, so i dont think they fall off easily?

and the idea is that u disconnect the consult cable from the box when not using it (to cut power etc)

Chalk another one up for working first go.

Finally got a few hours free today to solder it up and test it out. Worked fine with all the software mentioned in the thread. FYI I didn't solder any of the pins in the consult connector. I just crimped them as they were designed to do. I actually found this to be the easiest part of the job.

Thanks for the kit NewKleer.

what did u use to crimp them? i dont have any crimping tools on hand (and i doubt most people would) but might be useful to get one if theres a cheap one that can do it

ive found 2 more kits all ready to go that i didnt think i had (might have 1 or 2 more after this also, but need to check parts).

Edited by NewKleer

ive gone ahead and designed a combined usb/serial version that potentially can be used as either serial, usb, or both (with jumpers changing whether its serial or usb), which improves on all the points i listed above (except not worrying about point 4).

only thing is if u want to have both usb and serial, to switch between them ud have to open the box (unless u drill a hole and maybe get those easy to change jumpers that have the extra plastic on it to make it longer so its easy to grab to remove, if anyone knows what i mean)

the usb chip is a smd one (surface mount) so i might have to solder it to the board for usb versions as i cant imagine it being too easy for most people to do with normal soldering iron.

Edited by NewKleer

will need to test circuit (mainly usb side) before boards are manufactured, and then do the construction guide etc, so realistically not till feb some time (and of course assuming theres nothing major goes wrong with any of it)

good to hear.

heres a few pics on the layout of the pcb for the usb/serial one. the 4 blocks in the middle (and one down bottom left) are the jumpers to switch between usb/serial. top right chip is usb which ill hopefully be able to solder to pcb. waiting on parts (1-2 weeks) before i can test circuit, then go ahead with board manufacture if all is good.

Edited by NewKleer
  • 2 weeks later...

still waiting on some parts to do some testing before i get boards done. however i might put this on hold while im working on the consult display which could, if i go overboard, include a usb/serial consult interface as part of it (if it does i might cancel this one). not sure that ill have the funds up front to do both at same time, so will have to see.

its definitely the priority over this given being something thats useful everyday (whereas the majority of people wont have a laptop permanently in the car)

Edited by NewKleer
  • 2 weeks later...

ive decided at this stage to put any further consult interface kits on hold indefinitely as i wont have time whilst working on the consult lcd display:

http://www.skylinesaustralia.com/forums/in...howtopic=102414

im planning to have it come with integrated serial and usb consult interfaces

Guest
This topic is now closed to further replies.



  • Similar Content

  • Latest Posts

    • Had I known the diff between R32 and R33 suspension I would have R33 suspension. That ship has sailed so I'm doing my best to replicate a drop spindle without spending $4k on a Billet one.
    • OEM suspension starts to bind as soon as the car gets away from stock height. I locked in the caster and camber before cutting off the kingpin. I then let the upright down in a natural (unbound) state before re-attaching it. Now it moves freely in bump and droop relative to the new ride height. My plan is to add GKTech arms before the car is finished so I can dial camber and caster further. It will be fine. This isn't rocket science. Caster looks good, camber is good, upper arm doesn't cause crazy gain and it is now closer to the stock angle and bump steer checks out. Send it.
    • Pay careful attention to the kinematics of that upper arm. The bloody things don't work properly even on a normal stock height R32. Nissan really screwed the pooch on that one. The fixes have included changing the hole locations on the bracket to change the angle of the inner pivot (which was fairly successful but usually makes it impossible to install or remove the arm without unbolting the bracket from the tower, which sucks) and various swivelling upper arm designs. ALL the swivelling upper arm designs that look like a capital I (with serifs) suck. All of them. Some of them are in fact terribly unsafe. Even the best one of them (the old UAS design) shat itself in short order on my car. The only upper arm that works as advertised and is pretty safe is the GKTech one. But it is high maintenance on a street car. I'm guessing that a 600HP car as (stupidly, IMO) low as you are going is not going to be a regular driver. So the maintenance issues on suspension parts are probably not going to be a problem. But you really must make sure that however your fairly drastically modded suspension ends up, that the upper arms swing through an arc that wants to keep the inner and outer bolts parallel. If the outer end travels through an arc that makes that end's bolt want to skew away from parallel with the inner bolt, you will build up enormous binding and compressing forces in the bushes, chew them out and hate life. The suspension compliance can actually be dominated by the bush binding, not the spring rate! It may be the case that even something like the GKTech arm won't work if your suspension kinematics become too weird, courtesy of all the cut and shut going on. Although you at least say there's no binding now, so maybe you're OK. Seeing as you're in the build phase, you could consider using R33/4 type upper arms (either that actual arm, OEM or aftermarket) or any similar wishbone designed to suit your available space, so alleviate the silliness of the R32 design. Then you can locate your inner pivots to provide the correct kinematics (camber gain on compression, etc).
    • The frontend wouldn't go low enough because the coilover was max low and the upper control arm would collapse into itself and potentially bottom out in the strut tower. I made a brace and cut off the kingpin and then moved the upright down 1.25" and welded. i still have to finish but this gives an idea. Now I can have a normal 3.25" of shock travel and things aren't binding. I'm also dropping the lower arm and tie rod 1.25".
    • Motor and body mockup. Wheel fitment and ride height not set. Last pic shows front ride height after modifying the front uprights to make a 1.25" drop spindle.
×
×
  • Create New...