Jump to content
SAU Community

Recommended Posts

Hi everybody,

I am planning to take my R32 to its first run on dyno this coming thusrday, and i am seeking your advices and any tip that helps...like should I raise boost when on dyno or jsut stick to 1 bar?>(tuner's advice)

here are the major mods:

RB25DET Series 2

Garret T04E turbo

3" FMIC

Custom 3" air intake piping

BOV

Turbonetics Evolution wastegate

custom 3" downpipe

Tomie cams (270/8.8 both)

HKS metal head gasket 1.2mm

Walbro 255 in-tank fuel pump

HKS 555cc injectors

SARD standard fuel pressure regulator

Centerforce single plate clutch

HKS N1 muffler with custom 3" exhaust pipes

Greddy Profec-B Spec II

Apexi Power FC

Edited by Light
Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/
Share on other sites

your tuner will tune the car to its potential. so if he thinks it can take more than 1 bar then he'll turn it up.

from the sounds of your setup, it will depend on the maximum allowable flow of your turbo.

also, you havent listed an AFM in your list. is it still standard? if so, you might be restricted with the power you make.

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2739695
Share on other sites

Don't stress mate.

You should expect any were from 230-250rwkw depending on what boost you run

as 250 give or take is maxing out your stock inectors.

As long as it doesn't lean out badly or run too rich you should be safe.

However, this depends on the tuner's experience.

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2739830
Share on other sites

Just pump boost into it until you either get valve float, no gain, or run out of fuel.

I think the limiting factor in your setup is the walbro intank pump. You may find that your injectors are maxing out earlier than expected if it isn't up to the task.

Stock valve springs and lifters will likely stop the fun at about 20psi anyway.

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2740539
Share on other sites

20 will be safe on stock internals.

Just dont expect anything super brilliant in terms of response with a t04e, around 5000rpm before yo'll really see much of a song start :)

It'll make good power, just take a while to do it

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2740980
Share on other sites

around 5000rpm before yo'll really see much of a song start

you are absolutely right R31Nismoid, the song starts :) at around 5000rpm and this is the lag that makes me think of going to a better turbo even before i dyno it. thanks mate

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2741042
Share on other sites

looking at your mods and the condition of your engine

with cams, it should see full boost earlier then it would, with just standard ones.

And i have just a r33 plain bearing hiflow on mine set on 15psi pretty much doin 230rwkw. with pretty much the same mods as you except for cams. My turbo is set on 18psi, but i have been restricted to 15psi because of the standard actuator bleedin off to early.

Having a t04e turbo, ( i haven't had one before, but have seen specs.)

i would be hoping to equal 270rwkw and or higher sittin on 1bar boost.

Just depends how good your tuner is, and what condition all your mods and turbo is in.

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2741063
Share on other sites

on an RB20, there is no way its going to make 270rwkw @ 1bar

I had the old GTS-R turbo on the RB25 which was a t04e front and a hybrid T3 int gated rear... and it came on 13psi @ 4200rpm/220rwkw on the RB25

Check FATGTS-R's results with his version, its taking a bit more than 1 bar to mash out 270rwkw

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2741221
Share on other sites

I recon do yourself a favour and get a better fuelpump, no mention is the walbro direct connection to battery loop or using the standard fuel power source, your setbacks are the pump and turbo choice, let alone its all been said above, ove noticed lowered compression ratio with the head gasket so you should be able to pump in a bit pending on what your turbo allows you to do im guessing? Goodluck on your endevours and keep us posted

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2741259
Share on other sites

well thats fair enough on a rb20, but he has stated its a rb25det series 2

with cams and all the fuel supporting mods.

As i dont have a t04e, i wouldnt know, but looking at my car and he has a bigger turbo, ball bearing??

Maybe not at 1 bar but hopefully it shouldnt be too far off

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2741639
Share on other sites

whops, RB25, didnt read that line :happy:

But yeah, i made 220rwkw @ 13psi with a t04e/hybrid T3 rear... so i doubt its going to be much more different, maybe 20rwkw higher with a different rear. But no more.

If you make 335rwkw, i'll be surprised mate.

The turbo will be working its guts out, and my guess @ somewhere above 24psi will be needed to get there

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2741948
Share on other sites

so mates do you suggest setting the boost on 20psi all the time and that will be safe with no harm to engine at all? Anybody got settings for greddy profec-B spec II for 20psi (gain, set gain, warning...etc) i find it confusing sometimes

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2747202
Share on other sites

Look, its your tuners call.

Some people run into valve float issues when boost gets higher etc.

IMO, ask the tuner to run as much boost as possible.

If the tune is decent and there are no issues. Then really there should be no issue.

If knock doesnt go about 25-30, then it should be fine.

Link to comment
https://www.sau.com.au/forums/topic/146761-dyno-first-run/#findComment-2747564
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Haha I do that.. thats when it chirps..The bit point for me is almost non-existent. Otherwise I stall it. But yes, in terms of performance, the clutch is solid af.
    • Greg speaks wisdom. These dirty old Datsuns are only value when they are cheap. When they are not cheap, there is no value. Sounds contradictory, but it's true. We are now 20 years past the hey day of modifying cheap 90s JDM cars for small amounts of money. This is a different world. If you are rich and can afford not to care about what is effectively wasting money on an old Datto shitter, then I have no reason to argue against it. But if you are wanting to experience what we all experienced back in 2005 (and I bought my car last century!) then there is no way to do it.
    • Short answer: No. Medium answer: No, because you still need to conjure the things out of thin air to bolt them to a NA to make it a NA+T. Long Answer: No - The things you need to conjure - meaning a turbo, intercooling, manifolds, exhaust, intake/manifold/piping, clutch, injectors, fuel pump, AFM (?), ECU + Wiring (woo, N/A loom fun) have to come from somewhere. You could have many scavenged these things from an OEM car that someone had upgraded from and use some of these. This will be cost prohibitive now, especially so in the USA. You'd probably pay the same for newer, upgraded components that are better than old OEM stuff from 25-30 years ago. None of these big ticket items are re-usable for the N/A car. Why not buy new and upgrade while you're there? The only real consideration is turbo and fuel sizing and determining whether you want to stay within the bounds of the OEM engine or get into rebuild territory. These limits ARE lower with a N/A motor and especially N/A gearbox at the starting point. And if you're gonna upgrade those then you may as well consider having them built to begin with. Because everyone here knows you're never far from that next engine rebuild once you start making the power you want... The cars you see on the internet and SAU etc have been built over decades. If you're really clued in... you would sell your US car to somebody for what you paid for it. You would then scour AU JDM pages or SAU and buy a car like Dose's on this forum with your powerful American Dollar. This will save you so much money in the long term. Importing it could be tricky. Or it might not because USA. I have long said the only reason 90's Japanese stuff took off was because a) Japanese people had Japanese cars so that is what they used b) Australians could import these cars to Australia with very minimal changes and use them on the road here c) Neither country had well-priced access to US or EU Sports Cars. I don't believe the JDM scene would have taken off in Australia at all if we had EU priced EU BMW M offerings, or more especially the AUS V8 Scene would never have existed if we had the multitude of US cars like Camaros, Mustangs, Corvettes at the prices you folks do. After all - Do the math. I would say put a V8 in your R34 and that's the smart way forward. It is. I did it. I know this from my own experience. But at that point there's no reason to simply not buy a C5 or C6? It would be simpler and easier and cheaper and bette-
    • Reading all this... hurts lol. I have an ENR34 5MT and I paid an inflated USA price for the car alone, had to do tons of preventative maintenance past that, and so I'm over $30K USD into the car already and haven't even touched power.  I wanted to +t it. Not even trying to make GTR numbers, I'd be happy with 250hp.  Can I get away with paying much less to make that happen?
    • Damn you’ve done well, definitely snapping necks.
×
×
  • Create New...