Jump to content
SAU Community

Recommended Posts

  • Replies 46
  • Created
  • Last Reply

Top Posters In This Topic

  • 2 weeks later...
  • 2 months later...

Ok I finally had my R34 GTT intercooler modified and installed at RE Customs by Ray last week.

Cost $280 to modify and install, with 2 dyno runs. The reason for two runs was that my AFRs were getting a bit lean, so they cleaned my AFM to see if it was the problem. It wasnt, so I'll be installing a r32 gtr fuel pump in the next few weeks to try to fix the problem.

My car:

1992 R32 GTSt Type-M

170000km

old pod filter

3 inch cat back

3 inch split BATMBL dump/front pipe

5 inch metal substrate cat

and now R34 GTT sidemount cooler.

No external boost control (just the stock actuator).

As with Patricks, the duct wasnt installed as it would have needed a lot of modification. If i get the chance i'll have a shot at modifying it to fit.

The first dyno graph is from an SAU dyno day a while ago. I made 128.3 kW, at this stage I just had the cat back and the pod filter. The afrs were crap at first because i was playing around with my Jaycar DFA and had set up the offset wrong... but i unplugged it and all was ok again.

post-1218-1180960289_thumb.jpg

Ok the next two dyno charts are from two seperate occasions, the red line is from another SAU-Vic dyno day earlier this year. As you can see i made 142kW. But my AFRs were way too lean again. This was because i was using United Boost98 petrol (without specific tuning for it). So the moral of the story is dont use it...

post-1218-1180960296_thumb.jpg

post-1218-1180960320_thumb.jpg

The blue/green line is with the R34 cooler installed. I made 155.1kW at the wheels. Boost held constant at about 11psi all the way to red line and there was slightly more power everywhere. But my AFRs are still too lean, even with the AFM cleaned. The fuel filter was only a few thousand kms old too. So hence me looking at getting a new fuel pump.

So to sum it up definately good value for money, at $170 for the cooler and $280 for the mods, install and dyno run. Once the fuel issue is sorted i'll install my Jaycar IEBC (boost controller) at dial in 13psi i think.

Cheers,

Rhett

It'll cost you about $400 just to fit a FMIC alone.

And I'm yet to see a home-installed job that I would be comfortable with driving around with.

My reasons for going this option were:

Dont want to have to get another front bar

Dont want to cut into the front bar i have.

Dont like the look of a FMIC (unless the front bar fits it nicely...)

Dont plan on going for more than about 200 rwkW. (maybe r33 turbo or highflow at some stage)

Didnt want to get defected for FMIC as i already have a pod filter (Vic rules)

I already have a water spray controller i want to try out.

Didnt want to increase throttle response time (what usually happens with FMICs)

Didnt want to cut hole into engine bay near battery.

Cost me $370 all up installed if you dont count the dynos (that i didnt really have to have).

I'd call it great value.

IMHO anyway,

Cheers,

Rhett

But then again I would agree that its a more feasible upgrade for r33s, as no modifications are required.

Bringing it down to just the cost of the cooler ($180) and an hours work or so.

Thanks Rhett for your results!

The r34 smic can handle up to 230kw so i guess that is close enough to your sweet spot Cubes :P

Will be interesting to see the maximum capabilities of the smic further down the track as I will be looking into r33 hi-flow hopefully.

As stated above, if you have a r33 id aim for fmic as the r33 can gain much more power easily and reach max power of the smic. Although you will have to cut holes and possibly engineer reobar/hole if you get caught (which costs $$$)

Quick benefits;

- Less piping than fmic

- r34 SMIC outlet is larger in diameter than r32 smic, which resulted in restriction for stock r32's (possible reason as to gain of power)

- Larger core but small enough to not cause any throttle lag (compared to fmics)

Once i pop in a bosch 040 fuel pump, ill get another dyno run and post up results.

Rhett ill be interested to see your waterspray + airduct shroud if you customize it in :P

One negative thing about the smic is it gets heatsoaked easily.

Unlike fmic's which are freezing cold, after a long hard run the smic is hot on one side and warm on the other side.

They tend to get warm and i think i have felt a couple of times the heatsoak, but cannot confirm as it could be either heat soaked pod or my coil packs.

Would like to hear your results with the new smic on the roads and tracks.

Cheers

Patrick

r34 coolers used to be cheap as chips before all you guys jumped onto the train. My first one costed me $80. my second one was $60. My third was 120. I'd hate to think what the next one will cost.

you think they expensive here, check out the price of them in Japan.

Its a common mod in japan and to import one off yahoo auction will cost over $250 lol

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • After my last update, I went ahead with cleaning and restoring the entire fuel system. This included removing the tank and cleaning it with the Beyond Balistics solution, power washing it multiple times, drying it thoroughly, rinsing with IPA, drying again with heat gun and compressed air. Also, cleaning out the lines, fuel rail, and replacing the fuel pump with an OEM-style one. During the cleaning process, I replaced several hoses - including the breather hose on the fuel tank, which turned out to be the cause of the earlier fuel leak. This is what the old fuel filter looked like: Fuel tank before cleaning: Dirty Fuel Tank.mp4   Fuel tank after cleaning (some staining remains): Clean Fuel Tank.mp4 Both the OEM 270cc and new DeatschWerks 550cc injectors were cleaned professionally by a shop. Before reassembling everything, I tested the fuel flow by running the pump output into a container at the fuel filter location - flow looked good. I then fitted the new fuel filter and reassembled the rest of the system. Fuel Flow Test.mp4 Test 1 - 550cc injectors Ran the new fuel pump with its supplied diagonal strainer (different from OEM’s flat strainer) and my 550cc injectors using the same resized-injector map I had successfully used before. At first, it idled roughly and stalled when I applied throttle. Checked the spark plugs and found that they were fouled with carbon (likely from the earlier overly rich running when the injectors were clogged). After cleaning the plugs, the car started fine. However, it would only idle for 30–60 seconds before stalling, and while driving it would feel like a “fuel cut” after a few seconds - though it wouldn’t fully stall. Test 2 – Strainer swap Suspecting the diagonal strainer might not be reaching the tank bottom, I swapped it for the original flat strainer and filled the tank with ~45L of fuel. The issue persisted exactly the same. Test 3 – OEM injectors To eliminate tuning variables, I reinstalled the OEM 270cc injectors and reverted to the original map. Cleaned the spark plugs again just in-case. The stalling and “fuel cut” still remained.   At this stage, I suspect an intermittent power or connection fault at the fuel pump hanger, caused during the cleaning process. This has led me to look into getting Frenchy’s fuel hanger and replacing the unit entirely. TL;DR: Cleaned and restored the fuel system (tank, lines, rail, pump). Tested 550cc injectors with the same resized-injector map as before, but the car stalls at idle and experiences what feels like “fuel cut” after a few seconds of driving. Swapped back to OEM injectors with original map to rule out tuning, but the issue persists. Now suspecting an intermittent power or connection fault at the fuel pump hanger, possibly cause by the cleaning process.  
    • For race cars, this is one part where I find having the roll cage bar having gone through a hole in the floor better than the build it up on a ledge inside... The Merc I help on, the main hoop ends are marked on the car, and the jack is marked... Jack goes under a few inches and lifts one whole side of the car up... Removes that fight for long slim jacks for race car duties!   My biggest issue for the daily drivers I work on, is my jacks don't go high enough. The jacks start out on a few blocks, jack it up, then start a second jack under it on more blocks, and then I can get an axle stand under it. My axle stands are presently in use, and are nearly fully extended. The car is sitting with barely more than a cm of clearance to get the wheel off the studs! Sarah's Kluger is the same, as it has an ungodly amount of droop available in the suspension and a distinct lack of good jacking points!
    • Happy? Yep, my to do list is getting shorter and shorter. Either this light approaching is the end of the tunnel, or I'm about to be hit by a train... Ha ha ha   Also, Duncan isn't that far out of town that you need to make a multi day drive out of it. 😛
    • Sorry I meant that we are building the EH for a client.
    • LOL, when one "money pit" is never enough Noice, and excellent work mate
×
×
  • Create New...