Jump to content
SAU Community

Recommended Posts

1 hour ago, V28VX37 said:

Came up ok for a $90 setup.

Looks tidy

Surprisingly tight to run the 5/8" hose across the engine, especially with bonnet and fan clearance.
I have no idea how people run 1 or 2 litre catch cans with a stock-ish engine bay arrangement, not much space... 

They don't - they relocate the battery and/or get a custom unit made often incorporating the window washer reservoir

32309483831_ff883276bd_c.jpg

32309574791_c8d38bb4b1.jpg    31618860573_3e066e19f1.jpg

 

  • Like 1

Went for a quick test drive, car runs well but there's something curious going on with the heater hose, there's like this fine white dust on the outer surface. It's kinda like talcum powder, similar to what you often see on the inside of brand new rubber hose. I did flush the inside of the hose with hot water before installing but I'm wondering if the powder used in manufacture to keep the layers separate is coming through the hose skin with (some) pressure and heat?

I'm guessing this won't impact performance but somewhat odd still. I've wiped the hoses clean and will keep an eye on them.

EDIT: Sounds like it's mold release, pretty standard with new rubber hoses, should be ok. 

On 21/01/2017 at 0:13 PM, V28VX37 said:

I have no idea how people run 1 or 2 litre catch cans with a stock-ish engine bay arrangement, not much space...

My charcoal canister just fell out.. and now there's a catch can there lolol

Also, good job on mounting it down there.. nice bracket!

On 19/01/2017 at 8:05 AM, Kinkstaah said:

...

You *could* be massively dodgy and just run a hose from where you currently have it into something temporarily to see if it clears your oil up. But it's a strange place for oil to be accumulating in any case given it's not anywhere else in the system. Oil coming out of the compressor cover isn't usually what leads people to think they have a problem with blowby and want to catch it in a can.

I wiped the comp cover 100% clean last night and went for a longer drive today, there's a drop of oil in there again. It doesn't look like the simple catch can has made any difference so I'm with you now Greg, I'm not convinced it's the breather either.

Anyone got suggestions on what could be causing a leak at the comp cover? I've tightened all oil and coolant lines and the turbo core section seems dry as far as I can tell from above and below without pulling stuff out.

2 minutes ago, Dose Pipe Sutututu said:

My charcoal canister just fell out.. and now there's a catch can there lolol

Also, good job on mounting it down there.. nice bracket!

Cheers mate, aluminium flat bar is pretty friendly to work with :) I was actually eyeing off that charcoal canister spot, would have been sweet. I'm sure that mine is 100% non-functional after some 150k on car.

  • 3 weeks later...

You may have seen that I took the car to Sandown last month and blew the bottom end: https://www.sau.com.au/forums/topic/468826-blown-neo-bottom-end-next-steps/

Now, judging by the symptoms it's been a long time coming and really just a matter of time.

I was checking the catch can between sessions and there was barely anything until the second last session, after which it had perhaps 10mm oil in. However, after the last session (which eventually led to losing compression on 3 cylinders), I had heaps of crankcase pressure building and pushing oil and smoke out of the breather hose ends, the one running across the rocker covers. It also popped of the PCV hose on the intake cam cover. I pulled the catch can at this point and it was just over half fun.

The question is, whilst it most likely wasn't the root cause, do you think the catch can may have contributed to the demise of this engine?

Nah mate the catch can would have had nothing to do with it. You obviously had a fair bit of crank pressure going on, how were the rings when you pulled it apart?

Cheers mate. Yet to be pulled apart, will keep youse posted.
On 19/01/2017 at 8:49 AM, Dose Pipe Sutututu said:

A baffled catch can is the best option however if you're a tight skyline owner like myself a basic catch can with steel wool stuffed into it will also do the trick.

If you want, delete the PCV as well, block it plenum side and put a bung on the side of the cam cover. Then just run the breather hose from cam cover to catch can, then catch can to intake.

I wouldn't just block the pcv like that.

I don't mean to insult anyones intelligence, but there is a fair bit of misconception on the pcv valve. When the car is off boost, the intake manifold is under vacuum, which then sucks crank gasses through the pcv. The system needs fresh air though, which comes from the intake pipe. So off boost the air travel looks like this air->afm->intake tube->cam cover->crankcase->pcv->intake manifold.

When you are on boost, the pcv shuts, and the flow actually reverses. So you will get the crankcase gasses going back out the valve covers into the intake tube, to the turbo and into the manifold that way.

Now if you just block the pcv off, when you are off boost you won't be venting the gasses. You would need to add a vent to the valve cover or to the catchcan to vent the gasses off boost. If you don't, a lot of that fuel vapor will just sit around in the crankcase getting absorbed in your oil. The pcv is not that bad, as like I said it only vents to the intake manifold off boost. Yes you will get some oily vapors, but not that bad. And it's pretty efficient way of evacuating the crank vapors. On boost you will get a lot more crank pressure/vapor, which is where a catch can is much more important.

11 hours ago, Husky33 said:

I wouldn't just block the pcv like that.

I don't mean to insult anyones intelligence, but there is a fair bit of misconception on the pcv valve. When the car is off boost, the intake manifold is under vacuum, which then sucks crank gasses through the pcv. The system needs fresh air though, which comes from the intake pipe. So off boost the air travel looks like this air->afm->intake tube->cam cover->crankcase->pcv->intake manifold.

When you are on boost, the pcv shuts, and the flow actually reverses. So you will get the crankcase gasses going back out the valve covers into the intake tube, to the turbo and into the manifold that way.

Now if you just block the pcv off, when you are off boost you won't be venting the gasses. You would need to add a vent to the valve cover or to the catchcan to vent the gasses off boost. If you don't, a lot of that fuel vapor will just sit around in the crankcase getting absorbed in your oil. The pcv is not that bad, as like I said it only vents to the intake manifold off boost. Yes you will get some oily vapors, but not that bad. And it's pretty efficient way of evacuating the crank vapors. On boost you will get a lot more crank pressure/vapor, which is where a catch can is much more important.

You are insulting people's intelligence. Johnny was suggesting blocking off the PCV IFF you have a catch can installed.

1 hour ago, KiwiRS4T said:

You are insulting people's intelligence. Johnny was suggesting blocking off the PCV IFF you have a catch can installed.

My apologies.

However, just fitting a catch can doesn't mean you will vent crank case vapors off boost. Fitting a catch can between the right valve cover and the intake pipe has nothing to do with venting off boost. Will it vent a little bit, yes, but most of the vapor will stay in the crank case.

What I'm getting at is that it makes no sense to delete the pcv and still keep the vent from the cam cover to the intake pipe. Both are for emissions purposes, so why delete one and not the other? If you don't care about emissions, then put breathers on the valve covers and change your oil more regularly. Or even better, fit an evac or vacuum pump if it's a race car.

If you do care about emissions than the way to do it properly is to either fit two catch cans, once between the pcv and intake, and one between the valve cover and intake. Or one catch can that has lines that go to both location, with a couple check valves installed.

1 hour ago, Husky33 said:

My apologies.

However, just fitting a catch can doesn't mean you will vent crank case vapors off boost. Fitting a catch can between the right valve cover and the intake pipe has nothing to do with venting off boost. Will it vent a little bit, yes, but most of the vapor will stay in the crank case.

What I'm getting at is that it makes no sense to delete the pcv and still keep the vent from the cam cover to the intake pipe. Both are for emissions purposes, so why delete one and not the other? If you don't care about emissions, then put breathers on the valve covers and change your oil more regularly. Or even better, fit an evac or vacuum pump if it's a race car.

I

The full monty approach taken by some people who regularly track their car involves two breathers from the sump (above oil level of course)  and one combined or two seperate hoses from the cam cover breathers going into a large baffled catch can - with an outlet going to the turbo intake.

It is true that there are a few not so well thought out set ups around...

  • 11 months later...
On 21/01/2017 at 12:13 PM, V28VX37 said:

Came up ok for a $90 setup.

Surprisingly tight to run the 5/8" hose across the engine, especially with bonnet and fan clearance.
I have no idea how people run 1 or 2 litre catch cans with a stock-ish engine bay arrangement, not much space... 

32309483831_ff883276bd_c.jpg


Question: Is it possible to install a large 1 to 2L catch can without shifting everything around in the engine bay? I've seen some GT-R bays with a custom box where the battery is but that's obviously a battery relocation job.

One possibility could be the front left guard, at the OEM side mount IC location, but I have no idea how you would run the hoses there?

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...