Jump to content
SAU Community

Recommended Posts

  • Replies 69
  • Created
  • Last Reply

Top Posters In This Topic

Just spoke to my engine builder about another matter and mentioned your situation. Whether or not detonation/lean mixtures caused the problem, for your engine builder to claim that they did there needs to be clear and irrefutable evidence of same.

If there isn't any evidence of this then it's a cop-out and they're full of shit. If there is evidence of it then you haven't got a leg to stand on.

Just spoke to my engine builder about another matter and mentioned your situation. Whether or not detonation/lean mixtures caused the problem, for your engine builder to claim that they did there needs to be clear and irrefutable evidence of same.

If there isn't any evidence of this then it's a cop-out and they're full of shit. If there is evidence of it then you haven't got a leg to stand on.

Isn't he your dentist?

Harris do a lot of RB30's and they're close to you Joe. Worth a call. Although keep in mind they dont like to stay on the phone for long cause they're always busy

Thanks Steve, if the engineer returns with results in my favour then i'll give them a call.

Just spoke to my engine builder about another matter and mentioned your situation. Whether or not detonation/lean mixtures caused the problem, for your engine builder to claim that they did there needs to be clear and irrefutable evidence of same.

If there isn't any evidence of this then it's a cop-out and they're full of shit. If there is evidence of it then you haven't got a leg to stand on.

As far as he has told me, he doesnt have an actual report. He says that he's had 2 guys look at it, an engineer (i think) and someone from the NRMA and both said it was caused by detonation whereas the engineer that will provide me with a report said that detonation would not cause the main bearings to go, it would cause the big end bearings to go if anything.

whereas the engineer that will provide me with a report said that detonation would not cause the main bearings to go, it would cause the big end bearings to go if anything.

Yep. That's what I would've thought. But here's the thing, dude. It doesn't matter what's caused it, if it has detonated its ring out then there's sweet f**k all you can do.

Yep. That's what I would've thought. But here's the thing, dude. It doesn't matter what's caused it, if it has detonated its ring out then there's sweet f**k all you can do.

he said the pistons and rings are fine as well as the bores so i highly doubt it was detonation. the only part in the entire motor that failed were 2 of the main bearings.

Engineer will have a report ready for me by wednesday i hope. i'll ring him today and see if he'll go earlier. no point in speculating if we dont know 100% what happened.

Edited by SECURITY
  • 3 weeks later...

I'm sure Joe will give an update sooner or later, but I understand the engineer confirmed there was nothing wrong with the build, the issue was un-related.

It would be good to see the details posted since the reason I heard was unusual and an interesting warning about how small things can build up to a dead motor

Engineer report in:

results are:

bearing failure caused by overfueling/incomplete combustion + a restriction in the oil pickup which caused low oil flow at high RPM. the over fueling + the oil pickup restriction caused the motor to fail.

I'll post up the engineer report once ive edited out my details etc.

who tuned the new engine? As from what im reading there it has had problems since it was installed as the 8000klms travelled on an overfueled engine. This is critical on initial run-in as an excessively fueled engine will not allow rings to bed-in and the overfueled combustion chamber to release fuel mixture into sump area on compression stroke.

Edited by DiRTgarage

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Wife wanted basket things in the wardrobe in our temporary house. Thought about ripping our the wardrobe and fitting the entire IKEA set, but it's a temporary house and we want to move in a few years. So IKEA advertises this as a 50cm unit, however the actually basket and rails measure 46cm wide. Only issue was depth, IKEA stuff is quite deep, where as the builder special junk is super shallow at less than 40cm. Send it, chopped the rails, then offset the mounting holes, job done, happy wife, less shit scattered all over the bedroom. Did the same to the other side too. Also drove the Skyline shit box today, dropped off oil at Supercheap Auto. I didn't realise they only now take max 2x bottles per visit. I visited 2x Supercheap Autos.  
    • I've seen similar actually in my situation. You never know what tables are attempted to be used when the car thinks it's -99C or +200C. The fail state is not usually that extreme but you know what I mean - it was in my case though! This is where being able to read all the sensors is useful cause you see this stuff really quickly.
    • The above is very important. However as long as you keep timing relatively low, it's plausible to make your own knock ears and plausible to learn to tune with a modern ECU that can do wideband O2 correction like a boost controller. I mean if you only have one viable road to even drive the car on, learning to tinker to this level may be worth doing given you can't do much else with the car...?
    • I find the fact that the rear plate has to be bent inwards at the rear not so bad: but the front is just awful: It's like come on. (these are my very old, now retired/turned in plates) TBH it is a lot of money to fix a minor issue, the fact I said "I'll never really spend the money on doing this" is why people ended up buying them as a gift for a 'car guy' who can be hard to shop for.. for car guy things.
    • I just bent the ends of my premo plates. It even went through Regency like that after the engine conversion and the inspector (a great bloke!) just squinted his eyes and said "I didn't see that". Plates, and how they look, are just something that have zero importance to me.
×
×
  • Create New...