Jump to content
SAU Community

Recommended Posts

Sorry Guys but I fail to see the point of doing this modification. The factory rb25 intake manifold is good for at least 500rwhp worth of flow as I have seen. It will also give best cylinder distribution and will also create the highest port velocity due to the long runner length - which will result in a better midrange, earlier boost potential and not to mention better fuel economy.

I have dyno sheets of an aspirated XR6 with a TO4Z turbo conversion which I tuned a couple of months ago - as some of you are aware the aspirated XR6's have a dual length intake manifold to promote bottom end torque. The dyno sheet shows the difference between the long runner and short runner in a turbo situation and I can telll you the difference through the midrage is huge not to mention the rpm at which the desired boost level was acheived. If you interested I could find dig it up and post it.

I was lucky enough to be in japan at BLITZ when abe-san built the kits for nomuken's r34 gtt, i have the bosch dyno graph somewhere (this is the same graph used in the option magazine as they were also there to cover the kit) it lost no bottom end and gained 35 rwhp throughout the WHOLE mid to top end on a 400ps car.

i also bought a shload of these kits in 4 odd years back, few guys of here bought some like adzmax for "big red" and all have found killer results... pity they were dear and have since been discontinued.

I was lucky enough to be in japan at BLITZ when abe-san built the kits for nomuken's r34 gtt, i have the bosch dyno graph somewhere (this is the same graph used in the option magazine as they were also there to cover the kit) it lost no bottom end and gained 35 rwhp throughout the WHOLE mid to top end on a 400ps car.

i also bought a shload of these kits in 4 odd years back, few guys of here bought some like adzmax for "big red" and all have found killer results... pity they were dear and have since been discontinued.

Strange how the Nomuken's American 34 still has the stocko manifold. I did notice that the other day.

Blitz's kit would of been a whole lot easier, but much more expensive. And not quite as unique and as technically advanced.

Strange how the Nomuken's American 34 still has the stocko manifold. I did notice that the other day.

Blitz's kit would of been a whole lot easier, but much more expensive. And not quite as unique and as technically advanced.

the american car is one of the "old" spare cars.

I got the buckets out so now it's time remove the springs and whatnot, gonna leave the guides in for now and have everything done then have them replaced. Gonna have the head submerged in water and have the intake side be above water for welding to hopefully eliminate any heat problems. Any updates on your side, I am doing R32 Nismo twin turbos and 550 Nismo injectors on the RB26 fuel rail. I am also not filling the intake ports but reshaping the individual throttle adapter to match the bigger RB25 Neo intakes, there should be more than enough that I can machine off comfortably. Quick question for later on down the road, has anyone run a blow through setup on the RB25 as I am thinking of running this with twin setup using a Q45 MAF, your thoughts?

Why don't you make some copies? I can't see myself spitting out $2400 for it but it is a nice piece though. I am gonna try what I can on my spare head and see what can happen. Does anyone know how to go about removing two stuck valves, they are stuck shut, I am thinking maybe heating the head and removign the entire guide and vlave together, anyone has an idea what can be done, I don't want to be pounding on it hoping it pops free and damage something. All valves seals, springs, retainers, buckets etc have been removed along with valves except for these two valves, once removed I will get eerything welded and machined and tapped and then have the remaining guides removed and replaced and then have the entire head rebuilt. Also is it safe to drill and tap the exhaust side for the RB26 mani or should I just use the stock RB26 manis and have the appropriate flanges cut and flipped and rewelded, I have a good cast iron welder?

Edited by TriniGT

i knew that i should of orderd the $78 blitz gtr manifold adapter plate when i was at autobarn.. doh..

funny what you find in the system when your bored. i just typed in the search "rb26" and bang...

I got the buckets out so now it's time remove the springs and whatnot, gonna leave the guides in for now and have everything done then have them replaced. Gonna have the head submerged in water and have the intake side be above water for welding to hopefully eliminate any heat problems. Any updates on your side, I am doing R32 Nismo twin turbos and 550 Nismo injectors on the RB26 fuel rail. I am also not filling the intake ports but reshaping the individual throttle adapter to match the bigger RB25 Neo intakes, there should be more than enough that I can machine off comfortably. Quick question for later on down the road, has anyone run a blow through setup on the RB25 as I am thinking of running this with twin setup using a Q45 MAF, your thoughts?

you must have one big ass 300+ amp tig there!!!

Well I spoke to some people and got some more options but my friend that does the welding does a pretty decent job, this is the reason why I bought a scrapped head to do the job on in the even that it does fail then I still have my car running. Can anyone guide me as to how to remove the two stuck valves, should I just heat the area and tap the entire valve and guide out, I will need to replace all guides so I need some pointers on the difficulty of replacing the guides myself as finding good machinists locally is few and far between.

you must have one big ass 300+ amp tig there!!!

Oh just confirmed yeah 300+ amp tig FTW. I just spoke with him and he said he has done a number of heads and has some tricks up his sleeve, hopefully things go according to plan, he also has his machine shop that will be flattening the intake side and then tapping them as well. We'll see how it goes, this week I will be doing some valve guide work. GTS4WD thanks for the tips and I will keep in touch with my findings and results :P.

  • 1 month later...

Just keeping the thread alive.

Have run into a few problems;

Injectors - 25 are too small etc.

Problems with the coolent outlet fouling the clutch fan

But we are alsmost here with answers!

Just keeping the thread alive.

Have run into a few problems;

Injectors - 25 are too small etc.

Problems with the coolent outlet fouling the clutch fan

But we are alsmost here with answers!

yeah i was thinking that when i saw the photo!!

I don't see both problems being a big thing and can be easily solved. The coolant outlet is a quick fix and also I was thinking you should have gone with RB26 injectors and the resistor pack. That is what my plan is, should be getting back my head soon from the shop, as soon as weekend hopefully.

Hoookay.. so.. update!

Photos of the finished head, all filing, grinding etc completed. Did also some minor porting & polishing, mainly removing casting imperfections.

The face was also machined.

Please note that the "kink" at the top of the RB25DET head port needed to be enlaged too.

f_IMGP1074m_ae4402e.jpg

Note the stud which replaces the original bolt on LHS of the water port hole.

f_IMGP1080m_00a5f62.jpg

The coolant outlet was chopped and re-welded, having now the correct position and clearance against timing belt cover, plenum, VCT solenoid and fuel rail and clutch fan clearance issues.

Note the outlet is at a greater angle than before

f_DSC00562m_c9ea259.jpg

f_DSC00563m_01dc597.jpg

The 'air balancer' above the manifold had interference as shown. Same for the bottom of the water gallery under the manifold, which required bit of filing as well as grinding the head of the LHS bolt.

f_DSC00566m_d7b5b70.jpg

f_DSC00568m_24233a9.jpg

f_DSC00574m_d929ca8.jpg

More grinding on the block, the thermostat housing and the top bolt to ensure clearance with the water gallery below the manifold. The yellow water tube on LHS was also rotated few degrees down due to interference.

As you Can see there is very little grinding required.

f_DSC00575m_3eddfa1.jpg

Decided to use at this stage the NEO injectors and rail, to be able to start and run the engine on the stock ECU and iron out any other 'bugs'. The injectors have been modded as shown, with nozzle sitting now in same position as the GTR injectors. The rail brackets are also being modded with more photos to come shortly.

Long term will push for more kW with GTR rail, adjustable fuel regulator and aftermarket ECU (ye ol' faithful PFC sitting at home)

f_DSC00573m_8447ebd.jpg

The NEO oil cooler interferes with the air box below the plenum. Most likely we'll replace this with a GTR oil cooler, although down the track an external oil cooler will be fitted.

Will most likely have to go with the GTR AAC valve, as the NEO one is very different.

Yes it was possible to thermo fans, GTR rail, injectors and play around with the ijector impendance but that would be adding a considerable amount of cash the project as well as adding extra injector problems.

you will have to use the gt-t AAC valve, as the gt-t uses 2 plugs on it but the gtr only uses one.

GTR injectors and rail is easy, you just wire in the std gtr resister pack, and gtr injectors are cheaper than gt-t injectors.

i am running a hks oil cooler but i still found that the vacuum box that is bolted onto the under side of the gtr plenum would not fit, so i fab up my own mine and hook up all the vacuum hoses that were needed into it

Also looks like you use the GTR water outlet on the plenum the other option you could have gone was to cut off the gt-t water outlet and weld that onto the gtr plenum. then the angle would not have been so bad but looks like it will still work.

Edited by [Michael]

my before and after results were

Before:

Full boost @ 16psi 3300rpm

After:

More power

More torque

More responds

Full Boost @ 18psi 3200rpm

different dynos where used; second dyno reads lower than the 1st dyno but still made more power.

The car changed characteristics greatly; the car gain alot of responds; no matter what gear or were you were i the rev range. The car was tune very soft, still has alot more in it but i choice not to push it; plus @ the time of the tune still had an exhaust leak

Edited by [Michael]
  • Like 1

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • For once a good news  It needed to be adjusted by that one nut and it is ok  At least something was easy But thank you very much for help. But a small issue is now(gearbox) that when the car is stationary you can hear "clinking" from gearbox so some of the bearing is 100% not that happy... It goes away once you push clutch so it is 100% gearbox. Just if you know...what that bearing could be? It sounding like "spun bearing" but it is louder.
    • Yeah, that's fine**. But the numbers you came up with are just wrong. Try it for yourself. Put in any voltage from the possible range and see what result you get. You get nonsense. ** When I say "fine", I mean, it's still shit. The very simple linear formula (slope & intercept) is shit for a sensor with a non-linear response. This is the curve, from your data above. Look at the CURVE! It's only really linear between about 30 and 90 °C. And if you used only that range to define a curve, it would be great. But you would go more and more wrong as you went to higher temps. And that is why the slope & intercept found when you use 50 and 150 as the end points is so bad halfway between those points. The real curve is a long way below the linear curve which just zips straight between the end points, like this one. You could probably use the same slope and a lower intercept, to move that straight line down, and spread the error out. But you would 5-10°C off in a lot of places. You'd need to say what temperature range you really wanted to be most right - say, 100 to 130, and plop the line closest to teh real curve in that region, which would make it quite wrong down at the lower temperatures. Let me just say that HPTuners are not being realistic in only allowing for a simple linear curve. 
    • I feel I should re-iterate. The above picture is the only option available in the software and the blurb from HP Tuners I quoted earlier is the only way to add data to it and that's the description they offer as to how to figure it out. The only fields available is the blank box after (Input/ ) and the box right before = Output. Those are the only numbers that can be entered.
    • No, your formula is arse backwards. Mine is totally different to yours, and is the one I said was bang on at 50 and 150. I'll put your data into Excel (actually it already is, chart it and fit a linear fit to it, aiming to make it evenly wrong across the whole span. But not now. Other things to do first.
    • God damnit. The only option I actually have in the software is the one that is screenshotted. I am glad that I at least got it right... for those two points. Would it actually change anything if I chose/used 80C and 120C as the two points instead? My brain wants to imagine the formula put into HPtuners would be the same equation, otherwise none of this makes sense to me, unless: 1) The formula you put into VCM Scanner/HPTuners is always linear 2) The two points/input pairs are only arbitrary to choose (as the documentation implies) IF the actual scaling of the sensor is linear. then 3) If the scaling is not linear, the two points you choose matter a great deal, because the formula will draw a line between those two points only.
×
×
  • Create New...