Jump to content
SAU Community

Recommended Posts

Figured I'd do an update on my setup.

old-return-flow-intercooler-kit-RB25.jpg

I made 235kw on 18psi, RB25 TD06 20G 10cm.

All you cool cats worked out my intercooler was shit house, you were all right!

I've stuck to return flow as I want it the engine bay as factory looking as possible, but a much better setup.

HKS-type-S-intercooler-kit-installed.jpg

Ended up taking it for a drive on Monday, left the boost controller on low just to be safe. Low boost was set at 14psi previously, and with the new intercooler it's pumping out 20psi! Crazy how much restriction the old cooler setup made. Pulls like a freight train now too which is great. Also feels less laggy too, win win win!

So thank you for all your input lads :D

hey man, whats the rev range it starts to paty at?, and is it laggy or is it just right , share the info :))))))

LOL...really? Something very different between our setups then. I was hitting 18psi at 3,200rpm or something stupid and show was over with the thing losing its pull over 6,500rpm. It was mega grunty with the 8cm housing. And that was with cams at 0 and only a 2/3 tune.

I like the way the 12cm drives but on a very rough tune with no ignition the 12cm housing has generally added 800-1,000rpm to response. Would be far easier and nicer to drive with the way it delivers its power.

Will see if we get any of theloss in response back with the changes we made today....the car got pulled off the dyno due to another car needing some urgent work.

Will keep looking for a 10cm housing but think the T67 will go on before a find the right sized housing for the 20G. That will be the real test as I am pretty sure we have maxed out the compressor on the 20G so the question is will the billet wheel flow more with the TD06-12cm vs the T67-25G 10cm . That will be the real interesting test. Smaller, lower flowing turbine with a 78mm cast compressor wheel VS a larger higher flowing turbine with a lighter, smaller billet 73mm compressor with the larger 12cm housing.

I would go straight for the proven 10cm if I had one so ...no other choice then to waste tuners dyno time with my games :)

was using standard manifold with external gate and plazmaman plenum! internals were slightly modified on the turbo when it was rebuilt so dont know the exact specs but couldnt get any top end out of it....

ill check my dyno sheet as i have it laying around somewhere

Thats the trick...std manifold. They do mess with performance rather badly. I know people rate them and say they work...but from a performance standpoint jn my view they dont work :) But understand the many other reasons why you may run a std manifold

So I suspect a car with an aftermarket exhaust manifold on E85 could live with an 8cm housing longer then a car running the std manifold. I think the other catch is I dont think the backl pressure and heat woudl allow a 98 setup to work well either.

mine was run on 98 and 20psi didnt have any issues with heat which was good but if it was swapped to e85 and a custom manny id say 310wkw would be easily achieved at the same boost level on the 8cm housing and would prob help with the lousy bottom end of the rev range

I was hitting 18psi at 3,200rpm or something stupid and show was over with the thing losing its pull over 6,500rpm. It was mega grunty with the 8cm housing. And that was with cams at 0 and only a 2/3 tune.

I like the way the 12cm drives but on a very rough tune with no ignition the 12cm housing has generally added 800-1,000rpm to response. Would be far easier and nicer to drive with the way it delivers its power.

Will keep looking for a 10cm housing but think the T67 will go on before a find the right sized housing for the 20G. That will be the real test as I am pretty sure we have maxed out the compressor on the 20G so the question is will the billet wheel flow more with the TD06-12cm vs the T67-25G 10cm . That will be the real interesting test. Smaller, lower flowing turbine with a 78mm cast compressor wheel VS a larger higher flowing turbine with a lighter, smaller billet 73mm compressor with the larger 12cm housing.

Troy did you use the H4 turbine rotor with this RB25 + TD06-20G 12cm combo? From those comments it appears you have? Comments are a bit too cryptic to decipher, and remember this is a Kando/Kinugawa thread if you are using a custom build.

Sounds like impressions are that it currently delivers in a progressive manner, and winding some ignition advance into the thing will help that particular setup with regards to spool and bottom end torque.

If I'm correctly interpreting your specs to be tested, I reckon the T67-25G will come on easier.earlier but then perform roughly the same across 4000-6000ish. Bigger turbine flow in the TDO6-20G will help scavenging up towards the 7000 mark but then your comp flow seems to be the limiting factor and not much expectation that it can exceed 310rwkW. The T67 runners seem to be able to push things up towards the mid 340 mark via more boost.

Is the target driveability? If your R32 is seeing mostly/only track use then "best" turbine flow will certainly help the engine. Maybe stick a set of Albins 1-2-3 gears into that RB20 box and keep things spinning in the happy rpm range.

Feed us some more information please.

Not meaning to be cryptic other than the fact that I now swim in muddy waters with a farking RB25 :(

The 20G (Will refer to it as that) is the same old turbo I have run since 2003. It is a 55/65mm 12 blade turbine. It is running the 12cm housing

The 73HTA (Will refer to it as that) is a little bit custom. It runs a FP 73 HTA compressor and a newer 11 blade version 55/65mm turbone. I am going to swap the 20G 12 cm housing onto this turbo so this is going to be a good bacl to back test

The T67-25G runs a 10cm and is all as Trust shipped it. Ditto my TD06H-25G (Will refer to it as the 25G) with 10cm. That means the T67 has a 54/61mm 11 blade turbine and the 25G has the largest turbine at 58.8/67.2 12 blade turbine

I am hoping the 73HTA turbo gives me better than T67 response and the same, if not more power. Ultimately thats what I am hoping. It is being back to backed with the 20G just to understand the differences between all the turbos and its a relatively easy bolt off-on proposition.

I expect the T67 is the fall back option if the 73HTA doesnt work out, even if lack of performance can be put down to the 12cm housing.

Posting in this thread as Kando do so many Mistu based turbos seemed the best place to compare the results of Mitsu based turbo combinations

I am hoping the 73HTA turbo gives me better than T67 response and the same, if not more power.

I expect the T67 is the fall back option if the 73HTA doesnt work out, even if lack of performance can be put down to the 12cm housing.

Posting in this thread as Kando do so many Mistu based turbos seemed the best place to compare the results of Mitsu based turbo combinations

I understand better now, thanks. It's good to see things posted in here, definitely provides broad comparison for Mitsu and Mitsu-based turbos.

I can recall some pics you posted up some time ago of the TDO6 turbine - quite a "flat" blade form that looked pretty restrictive to passing gases? Presumably by going from 12 down to 11 blade its flow capacity will have been increased, though it might take a few more rpm to get moving. Reduced wheel mass will give lower inertia and hopefully even up most of the difference

The SL2 and H4 turbine blade shape/forms appear broadly similar, much more "open" than "flat" at the discharge zone. They both look like they should pass gases pretty easily and offer good flow efficiency. How efficient they are in drive and spooling the compressor is going to be interesting for sure.

Good luck , hopefully the 73HTA spec will do what you want of it.

I tend to agree that the turbine housing will be the crucial factor in getting the best match to your big-bore RB25...

Thats the trick...std manifold. They do mess with performance rather badly. I know people rate them and say they work...but from a performance standpoint jn my view they dont work :) But understand the many other reasons why you may run a std manifold

So I suspect a car with an aftermarket exhaust manifold on E85 could live with an 8cm housing longer then a car running the std manifold. I think the other catch is I dont think the backl pressure and heat woudl allow a 98 setup to work well either.

to be honest i dont think and 8cm on an aftermarket manifold is really going to work much better than a 10cm on a standard manifold...personlly if i wanted any more response from my setup I reckon a better bet would be a GTR intake ;)

I doubt a 6 throttle setup would make any different to spool and response. Throttle response would be sharpened but i doubt its going to make any significant difference to where the turbo spools. If you run the std RB25 inlet then I can see it adding lay even it if does sharpen throttle response. I have a Blitz adaptor kit which I plan on using but no way I am putting that on and testing differences. That will be going on my other motor and its going to be very different so will never truly know. But my engine builder has put 26 internals into a few RB25s as he sees that as a better street setup than going to RB26 mostly due to the NVCS and the long runners of the std RB25 plenum.

That all said, squeezing that air into an 8cm housing makes a difference...how big I dont know. Will throw up the graph of the 1/2-2/3 tune to see how it looked. It was way more responsive than a GT-RS on an RB25etc

*edit* stupid RB25s

No matter what we do with the gate, boost falls over from 19psi to 14psi as soon as the gate opens.

If anyone has any ideas then I am all ears. As is it is only making 280rwkws with 14psi from about 4,500rpm to red line. Ramps up to 19psi nicely at about 350rpm earlier than the RB20 (even with the much larger rear housing) but then just boost immediately trails off :(

So the 20G would be a rather good setup and may come back and keep it if I can get my head around how to stop the boost drop off. If I could get it to hold 18psi I am pretty confident the compressor would be maxed out and it would have 300-310rwkws and a good spread of power and torque with the ability to ram ignition down its throat in the top end to keep the torque flat. But suspect I am maxing out the flow of the turbo so the 45mm gate may be too big for the setup and probably need a 38mm gate or something...thats a change I am not willing to make so.

The 73HTA is on and ready to be rolled onto the dyno once I get a M11x1.5 to 3AN connector for oil feed. Hopefully the boost issue isnt repeated as I hope there isn't something wrong with the gate.

How should I plumb it other than how i plumbed the Greddy manifold and gate with the 20G with AVC-R and off the spring. The 6boost on the 20 with Turbosmart gate and Blitz ID and off the spring? Always plumbed my gates the way I have and never had a problem. Even with my lil RB20 I ony had an 8psi in my original Greddy gate and was able to run a pretty solid 20psi dropping to only 19psi at the top end.

I only know the one way and it has worked in the past. Like I said, I am all ears, how would you suggest?

There are many ways, if the boost is holding the gate open when it cracks you either need heavier springs or boost pressure helping to hold the gate closed. There is probably different pressure in the manifold, or the gate flows better due to it's placement.

Here are the Turbosmart instructions, there are multiple ways to set up the solenoid in there. I use a different method using a 5 port solenoid as I was explaining in the BW thread. Which way is yours set up now?

http://www.turbosmart.com.au/wp-content/uploads/2012/06/TS-0506-1001_Hypergate45_MAY_12_rev-2.pdf

Yeh, they dont spell out anything different to what has been tried and doing. Like I said have had numerous different manifold and gate and EBC and manual boost controllers on my car the 9-10 years I ran the 20G. I bought more springs and have tried combinations of 7psi inner, 3psi inner, 11psi middle and 7psi outer with the associated manual boost controllers/bleeds etc.

Anyway, got a good feel for when it hits and how it ramps and we know the compressor will max out around 310rwks on this dyno. So time to compare the power and ramp with the 73HTA

Quite strange issue, seems you have had a few mysterious power limitation issues over time with this project. Fingers crossed the HTA plays ball more enthusiastically - when is it due to be tuned?

Today or tomoz. The boost control looked ok on the 8cm. Boost was falling over but didnt lose too much sleep as just wanted to get some baseline runs and get a feel for the characteristics. But it wasnt that far away and if we spent more time on the boost feel we could have got it closer than we have been able to with the 12cm.

With the 12cm a bit more energy was put into trying to get it to hold boost. Didn't exhaust ourselves as I dont want to spend too much $ fiddling around when the setups are going to get swapped. Main thing is we get to see the character and idea of response and numbers. But curious that it wasn't anywhere as simple as getting the other combos to hold boost.

I dont know about power limitations. 306rwkws out of an RB20 is a decent enough haul. :) But having had the car for 14 years with what has essentially been a number of 20G combinations over the years...everything generally experimented with has been at best a move sideways not forward. Goes to show how capable (basically the best setup) a std RB20 with std inlet plenum and std cams just with a genuine Greddy manifold-20G kit performs!

The only change I have made to my original setup that was an improvement was the change from 10cm housing to 8cm back in 2004. Other than that I didnt know I had the optimum setup at the time and have tried various things that were .... umm cash consuming :) Curiousity is a cruel mistress :)

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • From there, it is really just test and assemble. Plug the adapter cables from the unit into the back of the screen, then the other side to the car harness. Don't forget all the other plugs too! Run the cables behind the unit and screw it back into place (4 screws) and you should now have 3 cables to run from the top screen to the android unit. I ran them along the DS of the other AV units in the gap between their backets and the console, and used some corrugated tubing on the sharp edges of the bracket so the wires were safe. Plug the centre console and lower screen in temporarily and turn the car to ACC, the AV should fire up as normal. Hold the back button for 3 sec and Android should appear on the top screen. You need to set the input to Aux for audio (more on that later). I put the unit under the AC duct in the centre console, with the wifi antenna on top of the AC duct near the shifter, the bluetooth antenna on the AC duct under the centre console The GPS unit on top of the DS to AC duct; they all seem to work OK there are are out of the way. Neat cable routing is a pain. For the drive recorder I mounted it near the rear view mirror and run the cable in the headlining, across the a pillar and then down the inside of the a pillar seal to the DS lower dash. From there it goes across and to one USB input for the unit. The second USB input is attached to the ECUtec OBD dongle and the 3rd goes to the USB bulkhead connected I added in the centre console. This is how the centre console looks "tidied" up Note I didn't install the provided speaker, didn't use the 2.5mm IPod in line or the piggyback loom for the Ipod or change any DIP switches; they seem to only be required if you need to use the Ipod input rather than the AUX input. That's it, install done, I'll follow up with a separate post on how the unit works, but in summary it retains all factory functions and inputs (so I still use my phone to the car for calls), reverse still works like factory etc.
    • Place the new daughterboard in the case and mount it using the 3 small black rivets provided, and reconnect the 3 factory ribbon cables to the new board Then, use the 3 piggyback cables from the daughterboard into the factory board on top (there are stand offs in the case to keep them apart. and remember to reconnect the antenna and rear cover fan wires. 1 screw to hold the motherboard in place. Before closing the case, make a hole in the sticker covering a hole in the case and run the cable for the android unit into the plug there. The video forgot this step, so did I, so will you probably. Then redo the 4 screws on back, 2 each top and bottom, 3 each side and put the 2 brackets back on.....all ready to go and not that tricky really.      
    • Onto the android unit. You need to remove the top screen because there is a daughterboard to put inside the case. Each side vent pops out from clips; start at the bottom and carefully remove upwards (use a trim remover tool to avoid breaking anything). Then the lower screen and controls come out, 4 screws, a couple of clips (including 3 flimsy ones at the top) and 3 plugs on the rear. Then the upper screen, 4 screws and a bunch of plugs and she is out. From there, remove the mounting brackets (2 screws each), 4 screws on the rear, 2 screws top and bottom and 3 screws holding in the small plates on each side. When you remove the back cover (tight fit), watch out for the power cable for the fan, I removed it so I could put the back aside. The mainboard is held in by 1 screw in the middle, 1 aerial at the top and 3 ribbon cables. If you've ever done any laptop stuff the ribbon cables are OK to work with, just pop up the retainer and they slide out. If you are not familiar just grab a 12 year old from an iphone factory, they will know how it works The case should now look like this:
    • Switching the console was tricky. First there were 6 screws to remove, and also the little adapter loom and its screws had to come out. Also don't forget to remove the 2 screws holding the central locking receiver. Then there are 4 clips on either side....these were very tight in this case and needed careful persuading with a long flat screw driver....some force required but not enough to break them...this was probably the fiddliest part of the whole job. In my case I needed both the wiring loom and the central locking receiver module to swap across to the new one. That was it for the console, so "assembly is the reverse of disassembly"
    • But first....while I was there, I also swapped across the centre console box for the other style where the AV inputs don't intrude into the (very limited !) space.  Part# was 96926-4GA0A, 284H3-4GA0B, 284H3-4GA0A. (I've already swapped the top 12v socket for a USB bulkhead in this pic, it fit the hole without modification:) Comparison of the 2: Basically to do the console you need to remove the DS and PS side console trim (they slide up and back, held in by clips only) Then remove the back half of the console top trim with the cupholders, pops up, all clips again but be careful at the front as it is pretty flimsy. Then slide the shifter boot down, remove the spring clip, loose it forever somewhere in the car the pull the shift knob off. Remove the tiny plastic piece on DS near "P" and use something thin and long (most screwdrivers won't fit) to push down the interlock and put the shifter down in D for space. There is one screw at the front, then the shifter surround and ashtray lift up. There are 3 or 4 plugs underneath and it is off. Next is the rear cover of the centre console; you need to open the console lid, pop off the trim covering the lid hinge and undo the 2rd screw from the driver's side (the rest all need to come out later so you can do them all now and remove the lid) Then the rear cover unclips (6 clips), start at the top with a trim tool pulling backwards. Once it is off there are 2 screws facing rearwards to remove (need a short phillips for these) and you are done with the rear of the console. There are 4 plugs at the A/V box to unclip Then there are 2 screws at the front of the console, and 2 clips (pull up and back) and the console will come out.
×
×
  • Create New...