Jump to content
SAU Community

Recommended Posts

Hi Guys

I have recentyl upgraded the RB25DET with 550cc injectors and a HKS GT-RS turbo plus supporting mods. My tuner originally said 245rwkw @ 18psi

At the track for the first time on the weekend and I was getting knock; it started out in 5th gear only, even on small throttle openings and seemed to get worse as the day went on... occuring at lower boost and in lower gears. My tuner came down did some data logging (without a wide band) and reckons my fuel pump isn't keeping up... It is a recently (less then 2 years and 15000kms) installed Walbro 255lph with the direct battery feed (14v) and new earth etc. I went to a lot of trouble to confirm it was a genuine Walbro and was purchased from reputable Aussies dealer (NOT Ebay!)

My tuner also said that they have recently found out that their dyno under-reads by about 30kw at the 250kw mark so my beast is actually putting out more like 275rwkw (nice to have some good news!). I think at this power level the Walbro may be struggling (especially at the end of the straights) and I'm looking at the Deatschwerks DW301 in-tank replacement pump.

Has anyone else experienced similar issues? What was the cause/fix?

My tuner is also recommending a surge tank...

So my main question is how neccessary is a surge tank in an often tracked R33?

It seems like a complicated, expensive set up with more things to go wrong (relying on 2 pumps) and is also very obvious and illegal (car is still street legal and stealthy).

How good are the R33 fuel tanks (baffles) etc for track work? At what point do you seriously need to consider a surge tank on an R33?

Cheers :cheers:

Edited by Checkbuzz
Link to comment
https://www.sau.com.au/forums/topic/385690-r33-fuelingknock-issues/
Share on other sites

I had the exact same problem with my GT3037 and Walboro. You do not need a surge tank. That piece of shit Walboro 342 "255lph" pump, are crap. Once they go beyond 60psi, their flow goes to shit.

Do some maths - 18psi of boost (FPR is 1:1) + 42psi rail pressure + a few psi in pressure drop = 65psi+ of pump pressure needed. If your boost goes a bit higher, or other reasons, the pump needs to make even more pressure.

Once your flow drops off, the car is starving of fuel and leaning out. If you don't do anything about this soon, your engine will blow.

My advice, and I did this - Buy a Nismo 275lph pump, install, and all problems will go away. They are a complete drop in unit, come with the bracket, sock, cables, etc, and it takes about 5 minutes to put them in. Don't buy the bosch 040, their pickup is absolute shit.

If you do want to go cheap, buy a bosch 044 and do a direct replacement of your walboro.

You will most likely need a re-tune too, because if your existing tune was opened right up to accomodate for a failing \ inadequate pump, a new pump will make it as rich as hell. Your tuner should have seen this, instead it looks as if they have gotten lazy, or left it like this so you'll come back to be charged more.

Attached is a picture of the Walboro dying in the ass.

post-7271-0-98335700-1323825799_thumb.gif

Edited by The Mafia

From what my tuner told me is the Walbro 255lph are known to make 500hp atw. Considering it is original, and alot of people on this forum are making over 300rwkw with the same fuel pump. Maybe just bad fuel...

Iv got the same fuel pump myself and also getting installed 555cc injectors and looking at making the same power...il let you know how it goes

From what my tuner told me is the Walbro 255lph are known to make 500hp atw. Considering it is original, and alot of people on this forum are making over 300rwkw with the same fuel pump. Maybe just bad fuel...

Iv got the same fuel pump myself and also getting installed 555cc injectors and looking at making the same power...il let you know how it goes

I tuned my own car, and had it connected to the dyno flow tester. If you don't want to listen to me - That's OK, your money not mine. You'll need to change the pump and get a retune, and the retune the tuner will happily charge you $500+ for.

The Graph I have attached states exactly what I said in plain English.

500hp my ass. Anybody that says that the Walboro GSS342 can make that much power is dreaming.

I had the exact same problem with my GT3037 and Walboro. You do not need a surge tank. That piece of shit Walboro 342 "255lph" pump, are crap. Once they go beyond 60psi, their flow goes to shit.

Do some maths - 18psi of boost (FPR is 1:1) + 42psi rail pressure + a few psi in pressure drop = 65psi+ of pump pressure needed. If your boost goes a bit higher, or other reasons, the pump needs to make even more pressure.

Once your flow drops off, the car is starving of fuel and leaning out. If you don't do anything about this soon, your engine will blow.

My advice, and I did this - Buy a Nismo 275lph pump, install, and all problems will go away. They are a complete drop in unit, come with the bracket, sock, cables, etc, and it takes about 5 minutes to put them in. Don't buy the bosch 040, their pickup is absolute shit.

If you do want to go cheap, buy a bosch 044 and do a direct replacement of your walboro.

You will most likely need a re-tune too, because if your existing tune was opened right up to accomodate for a failing \ inadequate pump, a new pump will make it as rich as hell. Your tuner should have seen this, instead it looks as if they have gotten lazy, or left it like this so you'll come back to be charged more.

Attached is a picture of the Walboro dying in the ass.

From what the manufactures say it can easily handle 80psi or more. then again I guess its all theory :down:

I tuned my own car, and had it connected to the dyno flow tester. If you don't want to listen to me - That's OK, your money not mine. You'll need to change the pump and get a retune, and the retune the tuner will happily charge you $500+ for.

The Graph I have attached states exactly what I said in plain English.

500hp my ass. Anybody that says that the Walboro GSS342 can make that much power is dreaming.

500hp does sound like bulshit to me aswell, though im not considering that much power but im sure it can handle 350hp

Tuners round here all want a better fuel pump once you're getting up to 300kw + and I have relegated my Walbro to a lift pump and have a 044 pumping from my surge tank but to be fair I just had a look through the RB25 upgrade thread and there are quite a few people making 300kw with a Walbro.

For the OP I would make sure fuel pressure and afrs are ok on the dyno but would seriously consider a more grunty in-tank pump - the Deatschwerks looks like it will flow enough or a Nismo., Denso etc.

If you are going to the track a lot I would get a surge tank. When you are getting stuck in on the track it is amazing how quickly you can empty your tank, Either that or keep an eagle eye on your fuel levels and keep topping it up. Are surge tanks definitely illegal where youe are? There is no reason for the cops to be looking in your boot anyway.

Tuners round here all want a better fuel pump once you're getting up to 300kw + and I have relegated my Walbro to a lift pump and have a 044 pumping from my surge tank but to be fair I just had a look through the RB25 upgrade thread and there are quite a few people making 300kw with a Walbro.

For the OP I would make sure fuel pressure and afrs are ok on the dyno but would seriously consider a more grunty in-tank pump - the Deatschwerks looks like it will flow enough or a Nismo., Denso etc.

If you are going to the track a lot I would get a surge tank. When you are getting stuck in on the track it is amazing how quickly you can empty your tank, Either that or keep an eagle eye on your fuel levels and keep topping it up. Are surge tanks definitely illegal where youe are? There is no reason for the cops to be looking in your boot anyway.

You drive a Skyline, they have EVERY reason to look in your boot. A uncommon but common thing they look for in the R33 is the battery in the boot. Even though it came like that, they can defect you because it can't vent. If you have a sound system, they can ask to check its not blocking your spare tire. They can even just want to check your spare tire. I don't think surge tanks are legal anywhere. You've made some pretty big mods to the fueling system which if there is a fault could leak fuel and the result could be catastrophic.

Your fuel pump is probably getting too hot and running inefficiently. Get a 040 in tank or if you track often, surge tank might be a good option.

Bingo!

@65psi the Walbro is only flowing 170lph which is only just enough for 450HP from my (very rough) calculations.

Keep in mind these flow figures for fuel pumps are averages taken from limited samples so you may get a bad one (or a good one)

Anybody trying to run 500HP on one of these is fooling themselves the pump will be right on the edge of it's limits (Walbro only rate them to 500HP and that is only at 3bar)

The NISMO pump seems a little pricey and still only flows 276lph @ 3bar...

The DW301 is half the price and is still flowing close to 275lph @ 5 bar and is also a drop in replacement!

I'll definately be going back in for a tune and will also be recieving a wide-band for Xmas. I am not keen to do any more "testing" (read detonating my engine to hell!) without taking some remedial action first (i.e. new pump) and fitting the wide band so I can see what's going on with my AFRs. For a couple of hundred dollars ia new pump is cheap insurance!

I have seen that engine management warning light flash a little too often for my liking lately... god knows how much damage has already been done :domokun:

P.S. The PFC is going great thanx Mafia

for that much power you don't need a surge tank, many guys have run just drop in Nismo or Tomei pumps and crank out heaps more power than that and have sexy time with their cars and experience no lean outs like what you're experiencing.

I ran a Tomei drop in fuel pump and made close to 250rwkW on my old R33 and never experience any lean outs, also self tuned.

Were you actually experiencing fuel surge on the track? If not then yeah you dont need one. In my case when ever I had anything less then 1/2tank on hairpin turns my car would surge so chucked a surge tank in and no problem now can run til empty if I want. But by the sounds of things your not actually describing experincing fuel surge but just high knock levels.

I know I don't need a surge tank for the amount of power I'm running - it's the track work that is the concern with surge

for that much power you don't need a surge tank, many guys have run just drop in Nismo or Tomei pumps and crank out heaps more power than that and have sexy time with their cars and experience no lean outs like what you're experiencing.

I ran a Tomei drop in fuel pump and made close to 250rwkW on my old R33 and never experience any lean outs, also self tuned.

The pump is wired to the battery via a relay and I gave it a new earth etc

Knock was getting up to 120

No (550cc Tomei's should handle this power easy)

No (ditto for the Z32)

My tuner was there at the track (FYI - Sabbadin automotive have fantastic customer service!) pulling timing from cells (5 degrees out of a conservative tune) etc but it just didn't make any difference...

I'm sure they would have double checked injector duty cycle and AFM levels etc the only thing that couldn't be checked was AFRs due to lack of wide-band hence the suspicion about the lack of fuel. The issue was also mostly occuring only in high gears at the end of the straight i.e. after I'd been on WOT for some time again raising suspicions about fuel.

Have u got the fuel pump wired up via a relay and battery voltage?

U say the engine light was flashing. What knock did it reach?

Did it max the injector duty?

Did it max the air flow meter?

What data sheet are you looking at Sarge?

There seems to be some wild claims made about the 040 but I tend to go straight to the source: http://apps.bosch.com.au/motorsport/downloads/fuelpumps.pdf

That would be only 102LPH @ 6.5 bar for the 040!!! :ermm:

A definate downgrade from the Walbro... it's the 044 or nothing from Bosch for me however I have reservations about putting one in the tank (not what they were designed for) which is why I've been looking at the DW301 & Aeromotive 340 (DW301 seems to be more tested and comes from Deatschwerk who are known for quality injectors etc).

FYI - the DW301 has similar flow rate/characteristics as the 040

http://forums.evolutionm.net/automotosports-illinois/566110-bosch-044-aeromotive-stealth-340-deatschwerks-dw300-walbro-255lph-fuel-pump-test.html

Is the datasheet for the 040 correct? It say it can flow 300LPH at 94psi and in the same paragraph says its the direct comparable unit to the Wallbro 255.

There were no issues on the dyno or during road testing at the time.

I have full confidence in the tuner (Sabbadin automotive) these guys have been doing it longer than most and have an impressive track record.

The problems started happening towards the end of a couple of long spirited runs through the hills and then again on the track deteriorating as the day went on.

It really does sound like the Walbro is getting hot and slowly breaking down under long periods of high load.

Anyone got any experience with the DW301?

I will almost guarantee that the fuel pump is running out of flow.

The tuner should not have tuned it like this.

I still don't understand why you'd tune a car right on the edge of the fuel pumps capacity.

Anyone in the industry knows the walboro is shit beyond 60psi, or much beyond stock power.

It's basic maths.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Well, I can recommend the partial AV system translation CD I ordered from Car Audio Workshop in NZ. Whilst it didn't address the date issue, it has conveniently translated on-screen menu items into English, and now allows the GPS-received time to be offset in hours rather than minutes, so I can display Eastern Australian time accurately ( and bump it by another hour when daylight savings starts ).
    • Yuh, if it's 45°C outside, my car is driving in it.
    • I'd be curious to hear more. Otherwise, have you driven a modern x-trail? I wonder how it compares. Here in Australia they are/were popular for rentals and fleet vehicles. I have been in some and my impression was they are bad. But, this may have been very different in the 2000s at a good trim level. Twenty years is plenty of time to make the model worse. I do very much agree with the 2 silver cars in the garage approach. But, not driving because it's too hot would not leave a lot of time in the year for many Australians. I don't think you need to worry too much unless the car has actual issues with overheating. 
    • Back again. I returned to Japan in Jul/Aug to spend time with the car on my birthday and remind myself what all the sacrifice and compromise is for. It happened to line up with the monthly morning meet in Okutama, which I have been wanting to go to for a long time. It's a unique event at a unique spot with really rare, interesting, and quirky cars. It's where all the oldheads and OGs gather. The nighttime scene at DKF certainly has its place and should be experienced if you're into cars, but there's too much bad attention and negativity around it now. IMO the better time is Sunday morning at DKF or Okutama; it's more chill and relaxed. I'm glad I was finally able to go, but not sure it's worth the drive from all the way from Nagoya immediately the day before, unless I was already staying in Tokyo for the days right before the meet, because you have to wake up quite early to make it in time. Funnily enough though I didn't drive the car all that much this trip because it was just too damn hot. While there were zero issues and running temps were nominal and the A/C was strong, RBs already run crazy hot as it is. Sure, it took it all like a champ but something about driving these cars in the ridiculous heat/humidity bothers me and makes me feel like I'm asking too much of it. I'm just me being weird and treating the car like a living thing with feelings; I'm mechanically sympathetic to a fault. Instead I was mainly driving something else around - a KX4(silver) 2001 X-Trail GT, that I acquired in May. There's a few different flavors to choose from with Xs, but visually it's the Nissan version of the Honda CR-V. Mechanically it's a whole different story as this, being the top-trim GT, has an SR20VET mated to a four-speed auto and full-time AWD! It was a very affordable buy in exceptional condition inside and out, with very low mileage...only 48k kms. Most likely it was owned by an older person who kept it garaged and well-maintained, so I'm really happy with how it all worked out. It literally needs zero attention at the moment, albeit except for some minor visual touch-ups. I wanted something quirky, interesting, and practical and for sure it handily delivers on all three of those aspects. I was immediately able to utilize the cargo and passenger capacity to its full extent. It's a lot of fun to drive and is quite punchy through 1st and 2nd. It's very unassuming -in the twisty bits it's a lot more composed than one would think at a glance- and it'll be even better once I get better tires on it(yes, it's an SUV but still a little boat-y for my liking). So...now I have two golden-era Nissans in silver. One sports car and one that does everything else; the perfect two-car solution I think👍 The rest of the trip...I was able to turn my stressed brain off and enjoy it, although I didn't quite get to do as much as I thought. I did some interesting things, met some interesting people, and happened into some interesting situations however, that's all for another post though only if people really want to know. Project-wise, I went back to Mine's again to discuss more plans and am hoping to wrap that up real soon; keep watching this space if that interests you. Additionally, while working in the tormenting sweatbox that is the warehouse, I was able to organize most of the myriad of parts that my friend is storing for me along with the cars, and the 34 has a nice little spot carved out for it: And since it can get so stupid hot in there, that made it all the more easy -after I was standing there looking at the car and said 'f**k it'- to finally remove all the damn gauges that have mostly been an eyesore all this time. Huzzah. The heat basically makes the adhesive backing on the gauge mounts more pliable to work with, so it was far less stressful getting this done. I didn't fully clean it up or chase the wiring though; that will happen once I have the car in closer possession. Another major reason to remove all that stuff is to give people less reasons to get in my car and steal s**t while it's being exported/imported when/if the time comes, which leads us to my next point... ...and that is even though it's time in Japan is technically almost up since it's a November car and the X would be coming in March, I'm still not entirely sure where my life and career is headed; I don't really know what the future looks like and where I'm going to end up. I feel there's a great deal of uncertainty with me and as a result of that, it feels like I'm at a crossroads moreso now than any point in my life thus far and there are some choices I need to make. Yes, I've had some years to consider things and prepare myself, however too much has happened in that time to maintain confidence and everything feels so up in the air; tenuous one might say. Simply put, there's just too much nonsense going on right now from multiple vectors. Admittedly, I'm struggling to stay in the game and keep my eyes on the prize. So much so in fact, that very recently I came the closest I ever have before to calling it quits outright; selling everything and moving on and not looking back. The astute among you will pick up on key subtext within this paragraph. In the meantime I've still managed to slowly acquire some final bits for the car, but it feels nice knowing there's not much left to get and I'm almost across that finish line; I have almost everything I'll ever want for my interpretation and expression on what it is I think an R34 should be. 'til later.
    • Thanks for that, hadn’t used my brain enough to think about that. 
×
×
  • Create New...