Jump to content
SAU Community

Recommended Posts

I have a 2001 ARX fitted with BC coilovers. On Saturday I hit a pot hole in a roadworks zone - only doing about 40kmph. There was a loud crashing noise and something was clearly loose in the rear. We had a look today and found that the passenger side coilover top mount had torn out. Wondering if it has happened to anyone else, and what is the best way to repair it, and who best to do it - I'm in Canberra. Grateful for any advice.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/
Share on other sites

please excuse my ignorance - it's our first Stagea - which is the separate piece? At least one of the two bolts at the top of the shock absorber unit has sheared off and the plate that it is attached to has separated from the chassis.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7223618
Share on other sites

Wow. That looks like the bolt has pulled through the mount.

If that is the case I would be putting a decent washer and or reinforcing plate under the bolt, but that shouldn't have been able to happen in the first place.

I wonder if they were installed wrong?

Edited by superben
Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7224102
Share on other sites

Never seen that before :O must have been a bit of play on the bottom for it to pull out the top on one side? As Ben said, it will need to be welded and then strengthen it by welding 2 washers on top and bottom side. Do the other side to keep it simetrical.

  • Like 1
Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7224130
Share on other sites

Looks like metal fatigue around the stud has allowed it to break a section clean out of the body; there's no rust there.

I reckon the car has copped a hit in the wheel, and the shock has borne the brunt of the impact. You can see the stress cracks that have propagated around the stud. You can also see where the metal is stretched around the other stud.

I'd be looking for evidence of subframe removal, or rear arm removal; those components would have been badly damaged if it has been hit (or slid into a gutter etc).

You are going to need to get in from above; weld in a reinforcing plate with a pair of captive studs, I wouldn't just tack up the sheetmetal & put a washer in there.

That is going to be a pain, and you are going to want to find someone who is experienced with welding & engineering (like a hot rod or custom car body workshop), and you will be paying for that. I doubt a normal panel shop will even touch that repair.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7225360
Share on other sites

Thanks for all the info - car was on the hoist today - it is not rusted and there is no sign of damage to the sub frame, or indications that it has been removed - no marks on the wheels and it hasn't had a hit in my ownership - except the pot hole the other day - getting at it from above will be a real challenge - the panel that needs to be removed to access it is bolted and welded. Looks like it will have to be done from underneath.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7225793
Share on other sites

  • 2 weeks later...

Car is back on the road - shock mounts plated and welded by M&A Engineering in Mitchell ACT - ended up doing both sides because the other side was also cracked - they didn't think it happened because the shock units weren't installed correctly.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7236510
Share on other sites

Car is back on the road - shock mounts plated and welded by M&A Engineering in Mitchell ACT - ended up doing both sides because the other side was also cracked - they didn't think it happened because the shock units weren't installed correctly.

Great to hear mate!

If you don't mind my asking; what did they charge you to do the repair?

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7236575
Share on other sites

Good you found a decent fabricator to repair it, but I have seen many Stagea's and none have ever had that issue. The shocks were installed too short, it's the only way it could pull the stud through, as the spring tension is working against it. Hopefully it doesn't happen again...

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7236694
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • My dream is also to have a proper hoist, but I don't think it will ever happen. My quickjack is probably as close as I'll ever get, it really is very good though. 
    • Yeah we keep on in the dailies, it is pretty poor how many animals get hit and the driver leaves without checking....have saved a couple of little ones over the years. Bit of a gruesome job though, pouches generally need to be cut open because they are so tight and often the joey doesn't realise mum is gone so they are still locked onto the teat. I checked the modules in front of the DS wheel where an oil cooler should go.... There is the radar unit - that can go for race use) One of the 2 HX water pumps, the silver cylinder. That needs to be kept but might be able to be relocated But the bad news, the big computer mounted vertically in front of the wheel (blocking any potential air exit) is the electric steering computer. That is required until/unless i do a hydraulic steering conversion, and in CAD based modern car design it is not like I can just pop a big unit like that somewhere else (plus the loom would be too short anywhere else too). So, the passenger side is OK to clear out (just use a smaller washer reservoir, potentially elsewhere), but the DS no beuno
    • Well, all the best with the new camry It was interesting to hear about the UK process, it is generally a lot more streamlined here with a shipping agent looking after all the import side (noting the exact final price can still be a surprise.....) and I've used a few different brokers on the japan (or US) side, and never had any trouble with any of them....luck of the draw I guess. You mentioned you didn't get the auction sheet (understandable since you bought it from a dealer, not auction), but I always try and get hold of that because they are pretty thorough. I've imported 2x R grade vehicles over the years and both were fine, repairs in Japan are pretty thorough compared to here in Oz.
    • BTW I measured the jack I have, it is 70mm at the saddle but you only have about 700 until it returns to 150mm high at the cylinder so it is good but no magic bullet.
    • My experience with Rising Sun Exports Before agreeing to the sale I tried to do as much research as I could (obviously), his Facebook reviews are 98% and he goes Live at least once or twice a week. I contacted 2 people in the UK who had used him for their imports, both had positive feedback. His explanation and talk through of the import process was thorough, answering any query no matter how stupid it was. It felt as soon as the money was sent, communication dropped off. I asked for shipping updates every 2 weeks or so, not wanting to pester him, he never had any updates. I wasn't informed the car had been dropped off at the port, I only found out by his Facebook story. I asked for the photos taken at the port, knowing he would need some for insurance purposes. I received a few 5 second clips and that's it. When asked again, he said his staff had them. Weeks later I asked again, he tells me he doesn't have any, but does have 50 photos from the original advert. I never received them. I eventually got the documents sent via WhatsApp after I mentioned the port was requesting them. I purchased a CarVX report, to find out the vehicle is a Grade R with recorded accident damage, first recorded in 2017 when it was first auctioned. He never told me the grade, then again I didn't ask. His response was "Grade R means nothing, it wasn't chassis damage". Still, I would have liked to have been informed about it. Jon prides himself on being open and honest when it comes to inspecting cars, it's his main job doing so at the auctions for customers. When the vehicle arrived in the UK I noticed a few little cosmetic issues. It's a 21 year old car so it wasn't going to be mint condition. The side skirts are cracked on each corner and the sealant is failing. The front grill on the bonnet/hood isn't secured very well, mounting studs are missing. Both minor things, but again, it would have been nice to be told. During a Facebook Live walk around video of the vehicle, he mentioned it has a front Whiteline anti roll bar/sway bar. While on the inspection ramp, I noticed the stock item has been installed. When first questioned, his response was "the ARB? Switched? Since when, it never had them". Since sending video and photo evidence I've not received a response. I'm probably being over critical of the overall condition of an old car, but all I wanted was honesty (which he claims to have). I'm aware I wasn't his only customer, he's busy doing XYZ but other reviews praise him for great communication with regular updates and photos, I felt I didn't receive the same treatment. 
×
×
  • Create New...