Jump to content
SAU Community

Recommended Posts

  • Replies 98
  • Created
  • Last Reply

Top Posters In This Topic

Yes I'd be a bit concerned about a copper tube radiator at the front as well , if it were to rupture without warning hot manifolds and high voltage ignition systems could do the blevey thing .

Guys I have to wonder about running two pressure pumps , ie a small one (adequate) for normal running and a Gorilla one for super duty . I guess the problem then becomes dont forget to switch over at the right time ... The problem I think is a reliable system that somehow fails safe rather than unsafe from a fuel capacity point of view .

With coolers I'd be happier with something made of steel and although its a pain maybe some kind of fan forced one if its not located "out in the breeze" .

Actually just had another thought , is it possiple to have a T piece in front of the pump that can somehow bypass a controlled amount of fuel back to the tank so less volume is doing the roundies from the pump to the rail and back ? More complication and how can you reliably block this bypass when you need it all - another manifold pressure referenced FPR ?

Food for thought , cheers A .

I have already made money available to buy a fuel cooler as part of my fuel upgrade. I had been watching my mates rotory. It was in a super sudan speedway car. after about 16 laps, the car would go off tune, spit and cough and loose heaps of power. Much time was spent tring to find the problem. Due to the layout of the track, it had a fair amount of light throttle cornering. One day (after being pushed off the track) he was checking for a fuel block and noticed his alloy tank was quite warm~hot. hmmm

Added a davies craig auto cooler! no more problems. The cooler had to be steel to keep the officials happy. They also stated that the cooler was not permitted on the pressure side!!

The car had the same outcome as said above! it was fixed! then it blew a apex seal.. i guess all that lean mixture got to it..

Big pumps and low fuel useage..

afr's started to play up a little again this morning but only after 2.5 hours of driving in very heavy traffic because of a few break downs and traffic... the pump was a little louder but no way near as loud as it would have been previously...

So its much better then it was.. Was also thinking that if there was a front on accident the cooler would get bashed inbetween the intercooler and the air con cooler and once the engine stopped there would not be alot of fuel leakage... im going to speak to the engineer today about it.

I phoned my engineer who is doing my car and he said he has never seen this done before but he cannot see why it would be a problem...

The system is hooked up after the fuel regulator so in a accident fuel is not going to squirt everywhere because its not under high pressure and as soon as the engine stops the fuel flow stops as well.

He said he will think about it a bit more...

another engineer said he would have no issues if its on the return line but would prefer that some decent fittings were used to prevent it from accidently leaking..

Sounds like it might be okay to leave it where it is for now.

If you have a programmable ecu, you should be able to setup an output, so that when cruising/idling, the 044 pump is shutdown, and another smaller (maybe stock pump) is running. but the moment you go above say 3000RPM the output turns off, and the 044 pump comes on.

So set it up, the output is ON for the small pump, off for large one.

Put the 044 through a NC relay, and the small pump on the NO relay, set it up with a timeout delay (So that the NC relay stays open for say 1/2 a second whilst the small pump turns on.)

This way, if you loose power, the larger pump will become the active pump.

With this setup you WILL need a retune.

When running an inline external pump - we always run a bypass around the big pump along with a check vavlve and switch it on when required - either a hobbs or an output of the ECU can be used. This helps by not flowing lots of fuel to front of the car where it is heated.

ive got a hobs pressure switch 9psi i could use...

When running an inline external pump - we always run a bypass around the big pump along with a check vavlve and switch it on when required - either a hobbs or an output of the ECU can be used. This helps by not flowing lots of fuel to front of the car where it is heated.
Running a phenolic gasket between the head and the inlet manifold helps keep the rail cool, provided you do the associated coolant mods too.

www.gizzmoelectronics.com

Surely it would have sealing issues under higher boost. Also whats the good of a phenolic spacer to stop heat from the head when the intake manifold runs coolant through it anyway?

Edited by rob82

Yep i knew that would be mentioned but its just the angle of the pic. It about 300mm part but i think you are correct with the idea about ducting more air to it. It seems to work although can give any figures on whe temp difference there was.

Yea the cooler on the speed way car was on the return after the fuel reg.

The powers at be said pritty much the same as the engineer you spoke to... low pressure, its the hottest point in the system and will not pose any restriction to the fuel flow.

Although they did want it in steel. They were concerned about its ability to be ruptured in an accident.

The car never had an issue after the cooler was added. He mounted the cooler in the boot just before the fuel tank. His thoughts were that the cooler will be in less danger in there! He used a pair of 100mm computer fans for air flow.

I will be following his lead when i put my bigger pump in, and adding the cooler.

the twin pump idea is interesting..

I am going to be running a swirl pot, and using the stanard pump as a lift pump.

I've an 070 which could be used for a primary pump.

thanks for the idea. man my boot is gonna have some plumbing in it!

  • 1 year later...

Ive just dug this up from the dead as im now having the same problems with my 044. When i drove the car for short periods of time the pump was fine, however now it seems to heat up and cause me problems.

The bosch dealer in my case said the relay i used may be causing the problem. "The intermittent noises can be related to low voltage = high current = excessive heat and swelling of the pump armature which will not cause the pump to fail all together but limit its output, (causes shorts in the armature and lowers the pumps terminal rpm)

and/or

starving of fuel pump under surge conditions = wear in the gear set = terminal pump damage and will eventually stop altogether."

I fail to see how everyone running a bosch pump in their boot is going to require some sort of fuel cooler system as the pump is having issues? Anymore opinions or developments from anyone whos posted in here?

Hes pics of my setup anyway. I do think the wire is a bit thin and may be causing a voltage drop. Im also going to change the relay to something a bit meatier. Will post back when i sort out the problem.

post-21312-1229684152_thumb.jpg

post-21312-1229684171_thumb.jpg

post-21312-1229684188_thumb.jpg

Edited by SirRacer

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • For once a good news  It needed to be adjusted by that one nut and it is ok  At least something was easy But thank you very much for help. But a small issue is now(gearbox) that when the car is stationary you can hear "clinking" from gearbox so some of the bearing is 100% not that happy... It goes away once you push clutch so it is 100% gearbox. Just if you know...what that bearing could be? It sounding like "spun bearing" but it is louder.
    • Yeah, that's fine**. But the numbers you came up with are just wrong. Try it for yourself. Put in any voltage from the possible range and see what result you get. You get nonsense. ** When I say "fine", I mean, it's still shit. The very simple linear formula (slope & intercept) is shit for a sensor with a non-linear response. This is the curve, from your data above. Look at the CURVE! It's only really linear between about 30 and 90 °C. And if you used only that range to define a curve, it would be great. But you would go more and more wrong as you went to higher temps. And that is why the slope & intercept found when you use 50 and 150 as the end points is so bad halfway between those points. The real curve is a long way below the linear curve which just zips straight between the end points, like this one. You could probably use the same slope and a lower intercept, to move that straight line down, and spread the error out. But you would 5-10°C off in a lot of places. You'd need to say what temperature range you really wanted to be most right - say, 100 to 130, and plop the line closest to teh real curve in that region, which would make it quite wrong down at the lower temperatures. Let me just say that HPTuners are not being realistic in only allowing for a simple linear curve. 
    • I feel I should re-iterate. The above picture is the only option available in the software and the blurb from HP Tuners I quoted earlier is the only way to add data to it and that's the description they offer as to how to figure it out. The only fields available is the blank box after (Input/ ) and the box right before = Output. Those are the only numbers that can be entered.
    • No, your formula is arse backwards. Mine is totally different to yours, and is the one I said was bang on at 50 and 150. I'll put your data into Excel (actually it already is, chart it and fit a linear fit to it, aiming to make it evenly wrong across the whole span. But not now. Other things to do first.
    • God damnit. The only option I actually have in the software is the one that is screenshotted. I am glad that I at least got it right... for those two points. Would it actually change anything if I chose/used 80C and 120C as the two points instead? My brain wants to imagine the formula put into HPtuners would be the same equation, otherwise none of this makes sense to me, unless: 1) The formula you put into VCM Scanner/HPTuners is always linear 2) The two points/input pairs are only arbitrary to choose (as the documentation implies) IF the actual scaling of the sensor is linear. then 3) If the scaling is not linear, the two points you choose matter a great deal, because the formula will draw a line between those two points only.
×
×
  • Create New...