Jump to content
SAU Community

Recommended Posts

Hey guys,

Pulled my rb30/26 down over the last 2 weeks and today finally got to taking the pistons out. Basically I have 87mm rb30et pistons in there now, and I have new higher CR pistons to go back in which will yield 9.5:1

I had the bottom end built by an engine builder back in the day. I pulled them out to find this, marks were on every cyliner and on both inlet/exhaust side of the bore:

post-13028-1267327105_thumb.jpg

post-13028-1267327123_thumb.jpg

post-13028-1267327149_thumb.jpg

Now I have two questions:

1. Is this caused by incorrect piston to bore clearance? If not what is likely to have caused it?

2. Can I give the bores a lite hone and re-fit my new 87mm pistons and be OK? The bores are 87mm at the moment, and the new pistons are too, hence the issue.

Some people have told me a lite bottle brush hone to get the marks out won't hurt, others have told me to ditch the block all together and hone out another 30 block to suite my new 87mm pistons.

Issue with that is I spent many a hours modifying this block for the 4wd adapter plate :blush:

Anyways what be SAU's opinion.

Link to comment
https://www.sau.com.au/forums/topic/310036-what-has-caused-this-marks-on-bore/
Share on other sites

I wouldn't imagine piston to bore would play as a factor here given it is on all cylinders in the same spot.

Potentially, could it have been a problem with lubrication, as in the squirters were not getting to those points in the bore?

Or a more unlikely cause could be too many revs while the engine is cold and the pistons have not expanded fully causing the bore wear?

Just some ideas...

I would speak to the bloke that built it though - how long had the motor been going before the pull down?

First off you can still see the cross hatching in those dark areas, so the finish is still fine. It doesnt look like any abnormal wear, if it was you would see straight up and done scratch marks in those dark spots, it looks like something has stained your bores. But always hard to tell just looking at photos.

Is it carbon build? will it scratch off? does it still feel smooth, try and describe it to us a bit more.

Also a second interesting clue is that the dark strip goes down below the line where the top of the piston would be at the bottom of its stroke.

There is also a very clear line at the top where it stops, it looks like the line could line up with one of the rings. Figure out where the top of that line lines up with the piston when its at TDC that might give you another clue to what is causing it.

Also do the same at the bottom of the stoke.

But it almost looks like the oil squirters are squirtering at that spot at the bottom (hence the rounded stain at the bottom) and the piston is dragging it up to the top. Over time it could of just stained the bore.

Then again like I said its still very hard to diagnoise properly without having a proper look.

Edited by ascenion24
when the engine was rebuilt last time, was the block torque plate bored and honed? have you taken messurements in all different areas of the bore to see how round it is...

valid point

Cartman has it spot on, you have blow by because the bore is out of round. It should be nice and shiny like the rest of the bore because your rings are scraping, they are not scraping on your black bit. You probably didn't even notice this when driving, may have used just a tad more oil, but not much, and would have vented a bit more that usual into your catch can

are the marks on the pistons where the skirts are???

this is the largest part of the piston, i reckon the piston to bore clearance was too tight,

another possibility is the pistons have swelled during an extreme heat session, big burnout, too many hard laps on circuit etc.

Thanks for all the help guys.

Yeah it did burn oil ever so slightly, according to a mate following me once under load it was evident. It ran a 100% atmo catch can too so this probably explains the burning oil. Has a brand new head so I knew it was not stem seals that was causing the issue.

I think your right in that the bores are out. I don't know how it was done last time unfortunately, I just took it to a local mob with the pistons and they bored it out to 87mm and assembled it with the pistons I supplied.

I ran a bottle brush through no6 this afternoon very quickly and it took the marks right off and it looked brand new again. Obviously I still have a major problem but.

Waiting on a mate to bring some equipment around so we can measure the bores properly.

So where too from here? Another block?

take off your old comp rings and keep in order of cylinder, carefully put them in there matching cylinder and check the ring gaps, you will also be able to see if the bore marks are out of round, this is not accurate you still need to measure with a bore gauge

a new block depends on the meat you have to remove to get it round again, it may still be within spec and OK you need to mike up the bore both ways and then check that against clearance spec's

Thanks for all the help guys.

Yeah it did burn oil ever so slightly, according to a mate following me once under load it was evident. It ran a 100% atmo catch can too so this probably explains the burning oil. Has a brand new head so I knew it was not stem seals that was causing the issue.

I think your right in that the bores are out. I don't know how it was done last time unfortunately, I just took it to a local mob with the pistons and they bored it out to 87mm and assembled it with the pistons I supplied.

I ran a bottle brush through no6 this afternoon very quickly and it took the marks right off and it looked brand new again. Obviously I still have a major problem but.

Waiting on a mate to bring some equipment around so we can measure the bores properly.

So where too from here? Another block?

James, were the pistons installed the correct way around? Did the piston skirts appear to have excessive wear. The pin offset the wrong way around could have the rod angle incorrect at TDC.

since the marks go well past where the rings sit, to me looks like to much piston to bore clearance. since the skirt has rubbed it up aswell. they were installed the right way round? little dot or arrow facing forward?

its fairly normal to get those marks up top with forgies, but not the whole way down past the rings. what pistons were they? and what ones are you putting in?

I've had marks like these in an engine before and it was due to excessive piston to bore clearance. Do the pistons have polished areas above the top ring on the thrust faces? You get this when the piston "tips" in the bore. Must've been noisy on cold starts..

Hey guys,

I think your right, piston to bore clearance. Pistons were all around the right way, according to the mark.

Pistons that it had were CP.

Measured it all up tonight, I think they have added the piston to bore clearance to the actual hone itself.

Bores were showing a fairly consistant 87.07 across the board. Plus whatever CP recommend on top of that again which is like 3-3.5 thou I read.

I think that is what has happend anyway. Skirts are all showing signs of wear yes.

Sound plausible?

Edited by James_03

Unless I worked that out incorrectly, thats only 2.8 thou of clearance. I assume the piston size is 87mm at the skirt? .07 is only .0028" Unless your measuring devices are not accurate enough???

What if the piston to bore was too tight, not too excessive? Would the rubbing show up much the same? or would it be in four corners instead of just two?

If it was too tight then it should have scored the bore and the piston should have score marks on the top skirt above the top ring lands due to 'unaccommodated' heat expansion.....well thats my take.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...