Jump to content
SAU Community

Recommended Posts

Ok, im pretty sick of this shit, i've been dealing with this loss of power for a while, the cars a track car, drift specifically.

Engine:

RB20DET

RB25 Turbo

Pnumatic Boost Controller

Pod Filter

Front-Mounted Intercooler

3" Split dump pipe with screamer

Bosch 040

Nistune Remapped ECU

Power when it was first remapped (probably 3 years ago) was 180rwkw, hasn't been dyno'd since, but there is a noticeable loss of power, bogs down a lot easier, it's laggier, and generally slower on the straights. it cuts out around corners when i go in hard some times, i think this is fuel surge from the fuel slushing around, and probably completely unrelated.

Symptoms:

- White smoke, smells like burning oil but not overly blue, could be burning water as well. Has been smoking for a while on start up, but went after some driving, now smokes all the time, although seems to reduce after it's been on the track for a bit

- Low power, no missing or anything, runs smooth, just lacks power

- Laggy

Extra details:

- Still seems to hold boost ok, possibly spools a bit late

- The screamer which is pretty good (split dump on internal wastegate), known for how good they seal, and definitely sealed back when i had it on the street, now has exhaust coming out on idle and under light load, well before the wastegate should be opening. unsure whether the screamer just isnt sealing properly anymore, or whether the wastegate is opening early

- I just replaced the exhaust manifold gasket + faced the manifold + replaced studs (they were f**ked, 2 were missing), also the turbo/manifold gasket was replaced.

- Actuator has been adjusted to make sure the gate arm is as far back as it goes at rest

- Runs smooth, no missing, sounds great

- Quite loud tappets, been loud for a while, haven't bothered with them

- Looks like it's gone through a little bit of coolant (radiator was low when i just checked it), but can't be 100%

- Small amount of bubbles in radiator

Compression test:

120 - 135 - 120 - 130 - 120 - 120 (Cold Dry)

170 - 150 - 150 - 150 - 150 - 170 (Cold Wet)

140 - 140 - 145 - 145 - 140 - 140 (Hot Dry)

170 - 165 - 170 - 170 - 170 - 180 (Hot Wet)

at this stage, im thinking the turbo is going, but i'd just expect to see it struggling to hold the 12psi it's set to.

that's it off the top of my head, but as i remember more i'll add details.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/
Share on other sites

do a leak down test... that will tell you more then anything.

to be honest it sounds like from what you are saying that the motor is just tired..

+1

Sounds alot like my old RB20.

Was tired, just turfed it out.

I had a slight oil slick in the radiator and reserve bottle aswell.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5668539
Share on other sites

do a leak down test... that will tell you more then anything.

to be honest it sounds like from what you are saying that the motor is just tired..

pretty much my thinking after last night, but the compression test was slightly promising as after a quick search it didnt look like that was a too bad result, maybe im wrong?

and the bubbles in the rad are pretty slight, headgasket could be buggered.

just not sure what to check to confirm it, to give you an idea simon, this is the difference between me making winton or not, so if i just write off the engine as old and f**ked, then im out, but if i can find an issue and fix it, then im there.

leak down is next on the list, unfortunately dont have one myself, only comp tester.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5668703
Share on other sites

ive seen engines with major internal damage comp test ok... i remember trent saying on here he comp tested a car that had a chunk missing from the crown of the piston comp test ok.. the point is its not the most accurate indication of posblems. leak down test is however.

if its HG. i'd say rip the head off... ddo a quick head shave. check the manifold gaskets while your at it. check the turbo and wastegate. and put another OEM gasket on and put it back together

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5668750
Share on other sites

Try re torqueing the head down to help the head gasket. Put in some chemi weld or similar,

Make sure u run enough fuel so it doesnt surge around corners.

Go to winton with a little bit more boost and enjoy the day and get a new motor after u finish.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5668980
Share on other sites

ok, thanks to simon, was leak tested yesterday, got between 5-20% across all 6cyls.

pulled off the dump, still burning oil, but i noticed it did take a few minutes before it really started to smoke, which really made me think it was a leak that was burning from touching a hot surface in the exhaust at some stage once it heated up from running for a few minutes.

anyway looked at the exhaust housing, not much shaft play, blades look alright, wastegate seems to be sealing.

took the turbo off the manifold and ran it straight out the manifold for a bit, couldnt see any white smoke anymore.

so i can only conclude the oil is coming from the turbo.

the question is, if it's spooling up and building full boost still, can it still be affecting power? i didnt think so. even if it is leaking oil, does that mean that it's definitely the source of the low power?

im thinking of grabbing another turbo, putting it on, then taking it for a power run on monday, check the tune etc etc.

one thing i did do at the same time was disconnect the rocker cover breathers so that they didnt go back to the intake and just vented to the atmosphere, there was quite a decent amount of pressure built up after blocking the breathers off with my thumb for about 15 seconds. not sure if that's an issue though.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5676071
Share on other sites

lol i know it's blow by, i just wasnt sure how much is considered normal. there is a lot of oil pooling in the in take and i want to get an idea if it's just bad blowby or whether it's oil getting into the compressor housing via f**ked seals.

stock Rb20 turbo going back on, currently running rb25 turbo.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5676465
Share on other sites

I always assumed that fuel surge would probably damage a motor - with lean outs and power cutting in and out... a quick search turned up these threads below that seem to support that idea. Might be worth doing something about it before the next motor goes in. At the very least it will mean you always have power in corners.

http://www.skylinesaustralia.com/forums/topic/188138-fuel-surge/page__p__3394937

http://www.skylinesaustralia.com/forums/topic/316605-help-please-no-1-cylinder-low-compression-and-turbo-failure/page__view__findpost__p__5181420

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5677486
Share on other sites

yeh it's definitely not a good thing, but it's an RB20 so it's not top priority atm, but it's the kind of thing i should be able to fix by running a full tank of fuel. it's the constant power loss while the engines running smooth that's getting me.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5677675
Share on other sites

lol i know it's blow by, i just wasnt sure how much is considered normal. there is a lot of oil pooling in the in take and i want to get an idea if it's just bad blowby or whether it's oil getting into the compressor housing via f**ked seals.

stock Rb20 turbo going back on, currently running rb25 turbo.

Keep in mind: Excessive blow-by can cause a positive pressure in the crankcase which can, in turn, lead to seals leaking due to the excessive pressure felt at the seal. This doesn't necessarily mean perished seals.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5678656
Share on other sites

Keep in mind: Excessive blow-by can cause a positive pressure in the crankcase which can, in turn, lead to seals leaking due to the excessive pressure felt at the seal. This doesn't necessarily mean perished seals.

yeh that was my main concern with the amount of blow by i was feeling, i have had the dipstick blow out once or twice, but certainly not a regular occurrence.

as mentioned the leak down test has shown pretty positive results. so at this point im really not sure.

going to chuck a oil cooler on, thinking the oil overheating could be causing some of the results ive been getting, as a minimum it's needed anyway.

Link to comment
https://www.sau.com.au/forums/topic/353799-diagnosis-help/#findComment-5680703
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • It would be well worth deciding where you want to go and what you care about. Reliability of everything in a 34 drops MASSIVELY above the 300kw mark. Keeping everything going great at beyond that value will cost ten times the $. Clutches become shit, gearboxes (and engines/bottom ends) become consumable, traction becomes crap. The good news is looking legalish/actually being legal is slighly under the 300kw mark. I would make the assumption you want to ditch the stock plenum too and want to go a front facing unit of some description due to the cross flow. Do the bends on a return flow hurt? Not really. A couple of bends do make a difference but not nearly as much in a forced induction situation. Add 1psi of boost to overcome it. Nobody has ever gone and done a track session monitoring IAT then done a different session on a different intercooler and monitored IAT to see the difference here. All of the benefits here are likely in the "My engine is a forged consumable that I drive once a year because it needs a rebuild every year which takes 9 months of the year to complete" territory. It would be well worth deciding where you want to go and what you care about with this car.
    • By "reverse flow", do you mean "return flow"? Being the IC having a return pipe back behind the bumper reo, or similar? If so... I am currently making ~250 rwkW on a Neo at ~17-18 psi. With a return flow. There's nothing to indicate that it is costing me a lot of power at this level, and I would be surprised if I could not push it harder. True, I have not measured pressure drop across it or IAT changes, but the car does not seem upset about it in any way. I won't be bothering to look into it unless it starts giving trouble or doesn't respond to boost increases when I next put it on the dyno. FWIW, it was tuned with the boost controller off, so achieving ~15-16 psi on the wastegate spring alone, and it is noticeably quicker with the boost controller on and yielding a couple of extra pounds. Hence why I think it is doing OK. So, no, I would not arbitrarily say that return flows are restrictive. Yes, they are certainly restrictive if you're aiming for higher power levels. But I also think that the happy place for a street car is <300 rwkW anyway, so I'm not going to be aiming for power levels that would require me to change the inlet pipework. My car looks very stock, even though everything is different. The turbo and inlet pipes all look stock and run in the stock locations, The airbox looks stock (apart from the inlet being opened up). The turbo looks stock, because it's in the stock location, is the stock housings and can't really be seen anyway. It makes enough power to be good to drive, but won't raise eyebrows if I ever f**k up enough for the cops to lift the bonnet.
    • There is a guy who said he can weld me piping without having to cut chassis, maybe I do that ? Or do I just go reverse flow but isn’t reverse flow very limited once again? 
    • I haven’t yet cut the chassis, maybe I switch to a reverse flow. I’ve got the Intercooler mounted as I already had it but not cut yet. Might have to speak to an engineer 
    • Yes that’s another issue, I always have a front mount, plus will be turbo plus intake will big hasstle. I’ve been told if it looks stock they’re fine with it by a couple others who have done it ahahaha.    I know @Kinkstaah said the stock gtt airbox is limiting but I might just have to do that to avoid a defect so it atleast looks legit. Or an enclosed pod so it’s hidden away and feed air from the snorkel and below Intercooler holes like kinstaah mentioned. Hmm what to do 
×
×
  • Create New...