Jump to content
SAU Community

Recommended Posts

So last weekend I decided to heighten the front coilovers a bit as it turned out the tyres would rub the underside of the guards on certain occasions. So I took them out, raised them up 5mm and bam; problem solved. After doing a test drive I noticed a variety of clunks and occasional noises and now I'm unsure if they have been there all along and I didn't notice as I always run the stereo, or is it to do with the work I just did. I don't believe it to be related to the past weekend work as it was a simple enough process and I put it all back together tightly.

Even more confusing is that most of the suspension related parts are in good condition or relatively new. A quick run down...

coilovers - around 15,000kms

front sway bar - aftermarket, new polyurethane bushes 700kms ago

swaybar links- 1300kms old

tension rods - solid, 8,000kms

steering ends - solid, 8,000kms

LCA - standard

tower brace

I know that a set up like this is conducive to NVH but this is something else.

The clunks seem to happen at lower speeds and usually when I'm just minding my business going in a straight line. Its not set off by any specific road conditions or driver inputs. The vibration of the clunk I can even sense through my feet, but I think its coming from both sides. Also there is one from the right rear of the car sometimes too.

I did jack each corner of the car up and did a basic check to see if there was any play in the ball joints, but they seem ok. I did notice about an inch of sideways play in the front wheels, equally on both sides, and put this down to normal play in the L/R motion of the steering system (would that be right?)

So yeah, I'm kinda concerned as I feel like I have the obvious stuff covered, but that said I don't have much confidence in tracking down these clunks. Has this happened to you? What was it? or what have I overlooked?

Thanks!

It could be anything really. I have a clunk that only appears in the wet and its from the Diff bushes. I noticed it after I did all 4 diff bushes and we got a bit of rain, it disappears when it dries out

I know its not much help but just shows it could be anything, even if you have replaced it with something new. Because you think its not a new problem since the coilovers it makes it a bit harder. The Coilover bolts/nuts are all done up nice and tight? coilover bottom mounts on the right way? (They do only go one way, but usually they wont fit the other anyway)

Sorry its not much help

yeah, other threads seem to suggest a variety of things. I guess if it moves, it can make noise. Im wondering if it could be the swaybar touching the control arm, but that's a long shot too. Im hoping for a magic bullet solution, but don't think I'll find one.

have you checked your ashtray for earings??

I have a clunk in my ute...drove me nuts for a few days I thought something was seriously broken in my suspension or something...

well as it turns out

the cable has come off my guard side indicator and it the plug knocks against firewall as i drive...i can feel it through my footwell and it sounds horrible ,clunk clunk, clunk, but now I know its nothing...I ignore it ;)

I chased a noise for ages, had a weird noise from the front of the car. Checked everything and couldnt find a thing

Then one day with the car over a pit, I noticed that for some reason there is a bracket on each front hub that holds the brake line and both had no bolt in them. These had been hitting against the hub. Funny how I never noticed it the first time I looked

Do you have access to a pit? Put it over there and carefully try and take off with the handbrake/brake on to try and put some load on everything while someone stands under the car and looks/listens for noises

Be careful obviously

UPDATE

So I got the front end on stands and got in there to see what I could find. I was half way through fitting standard front suspension as a test when I noticed some movement in the swaybar. it turns out that the swaybar links I bought were a combination of a little loose and a little ill-fitting. I taped the thread (for where it goes through the hole in the swaybar so as to eliminate any play), and also added a washer to all connecting points with a nut, then tightened them all up solid.

I also noticed a little more play than I would like with the tie rod ends where they link up with the knuckle, so I tightened this up a bit more too.

Then went for a test drive and, yey, clunking noises are gone!!

Just an occasional clunk at the rear to follow up. Some other day.

Good to hear you found something.

Sway bar links are a common culprit, usually noticed going in & out of driveways.

Was going to say an inch of sideways play in steering is no good, there should be zero play. That much play will chew out tyres big time!

Yeah, im going to keep an eye on it all though. Tyres are fine, and I put it down to also being off the ground when I checked.

In other news, I was looking at the many underbody pics I took yesterday while there and noticed a turbo dump pipe bolt hanging on right at the end of the thread. Great I saw it and can act on it before it falls right off, but sucks as it means I gotta get out and under the damn car again today...

Unsurprisingly, got under the back of the car and the driver side rear swaybar link has a bit of a creak in it when you move it about (same location as the noise when I drive) so that might well be the cause of that noise too.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Hi,  Just joined the forum so I could share my "fix" of this problem. Might be of use to someone. Had the same hunting at idle issue on my V36 with VQ35HR engine after swapping the engine because the original one got overheated.  While changing the engine I made the mistake of cleaning the throttle bodies and tried all the tricks i could find to do a throttle relearn with no luck. Gave in and took it to a shop and they couldn't sort it. Then took it to my local Nissan dealership and they couldn't get it to idle properly. They said I'd need to replace the throttle bodies and the ecu probably costing more than the car is worth. So I had the idea of replacing the carbon I cleaned out with a thin layer of super glue and it's back to normal idle now. Bit rough but saved the car from the wreckers 🤣
    • After my last update, I went ahead with cleaning and restoring the entire fuel system. This included removing the tank and cleaning it with the Beyond Balistics solution, power washing it multiple times, drying it thoroughly, rinsing with IPA, drying again with heat gun and compressed air. Also, cleaning out the lines, fuel rail, and replacing the fuel pump with an OEM-style one. During the cleaning process, I replaced several hoses - including the breather hose on the fuel tank, which turned out to be the cause of the earlier fuel leak. This is what the old fuel filter looked like: Fuel tank before cleaning: Dirty Fuel Tank.mp4   Fuel tank after cleaning (some staining remains): Clean Fuel Tank.mp4 Both the OEM 270cc and new DeatschWerks 550cc injectors were cleaned professionally by a shop. Before reassembling everything, I tested the fuel flow by running the pump output into a container at the fuel filter location - flow looked good. I then fitted the new fuel filter and reassembled the rest of the system. Fuel Flow Test.mp4 Test 1 - 550cc injectors Ran the new fuel pump with its supplied diagonal strainer (different from OEM’s flat strainer) and my 550cc injectors using the same resized-injector map I had successfully used before. At first, it idled roughly and stalled when I applied throttle. Checked the spark plugs and found that they were fouled with carbon (likely from the earlier overly rich running when the injectors were clogged). After cleaning the plugs, the car started fine. However, it would only idle for 30–60 seconds before stalling, and while driving it would feel like a “fuel cut” after a few seconds - though it wouldn’t fully stall. Test 2 – Strainer swap Suspecting the diagonal strainer might not be reaching the tank bottom, I swapped it for the original flat strainer and filled the tank with ~45L of fuel. The issue persisted exactly the same. Test 3 – OEM injectors To eliminate tuning variables, I reinstalled the OEM 270cc injectors and reverted to the original map. Cleaned the spark plugs again just in-case. The stalling and “fuel cut” still remained.   At this stage, I suspect an intermittent power or connection fault at the fuel pump hanger, caused during the cleaning process. This has led me to look into getting Frenchy’s fuel hanger and replacing the unit entirely. TL;DR: Cleaned and restored the fuel system (tank, lines, rail, pump). Tested 550cc injectors with the same resized-injector map as before, but the car stalls at idle and experiences what feels like “fuel cut” after a few seconds of driving. Swapped back to OEM injectors with original map to rule out tuning, but the issue persists. Now suspecting an intermittent power or connection fault at the fuel pump hanger, possibly cause by the cleaning process.  
    • For race cars, this is one part where I find having the roll cage bar having gone through a hole in the floor better than the build it up on a ledge inside... The Merc I help on, the main hoop ends are marked on the car, and the jack is marked... Jack goes under a few inches and lifts one whole side of the car up... Removes that fight for long slim jacks for race car duties!   My biggest issue for the daily drivers I work on, is my jacks don't go high enough. The jacks start out on a few blocks, jack it up, then start a second jack under it on more blocks, and then I can get an axle stand under it. My axle stands are presently in use, and are nearly fully extended. The car is sitting with barely more than a cm of clearance to get the wheel off the studs! Sarah's Kluger is the same, as it has an ungodly amount of droop available in the suspension and a distinct lack of good jacking points!
    • Happy? Yep, my to do list is getting shorter and shorter. Either this light approaching is the end of the tunnel, or I'm about to be hit by a train... Ha ha ha   Also, Duncan isn't that far out of town that you need to make a multi day drive out of it. 😛
×
×
  • Create New...