Jump to content
SAU Community

Recommended Posts

I have a 2001 ARX fitted with BC coilovers. On Saturday I hit a pot hole in a roadworks zone - only doing about 40kmph. There was a loud crashing noise and something was clearly loose in the rear. We had a look today and found that the passenger side coilover top mount had torn out. Wondering if it has happened to anyone else, and what is the best way to repair it, and who best to do it - I'm in Canberra. Grateful for any advice.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/
Share on other sites

please excuse my ignorance - it's our first Stagea - which is the separate piece? At least one of the two bolts at the top of the shock absorber unit has sheared off and the plate that it is attached to has separated from the chassis.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7223618
Share on other sites

Wow. That looks like the bolt has pulled through the mount.

If that is the case I would be putting a decent washer and or reinforcing plate under the bolt, but that shouldn't have been able to happen in the first place.

I wonder if they were installed wrong?

Edited by superben
Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7224102
Share on other sites

Never seen that before :O must have been a bit of play on the bottom for it to pull out the top on one side? As Ben said, it will need to be welded and then strengthen it by welding 2 washers on top and bottom side. Do the other side to keep it simetrical.

  • Like 1
Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7224130
Share on other sites

Looks like metal fatigue around the stud has allowed it to break a section clean out of the body; there's no rust there.

I reckon the car has copped a hit in the wheel, and the shock has borne the brunt of the impact. You can see the stress cracks that have propagated around the stud. You can also see where the metal is stretched around the other stud.

I'd be looking for evidence of subframe removal, or rear arm removal; those components would have been badly damaged if it has been hit (or slid into a gutter etc).

You are going to need to get in from above; weld in a reinforcing plate with a pair of captive studs, I wouldn't just tack up the sheetmetal & put a washer in there.

That is going to be a pain, and you are going to want to find someone who is experienced with welding & engineering (like a hot rod or custom car body workshop), and you will be paying for that. I doubt a normal panel shop will even touch that repair.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7225360
Share on other sites

Thanks for all the info - car was on the hoist today - it is not rusted and there is no sign of damage to the sub frame, or indications that it has been removed - no marks on the wheels and it hasn't had a hit in my ownership - except the pot hole the other day - getting at it from above will be a real challenge - the panel that needs to be removed to access it is bolted and welded. Looks like it will have to be done from underneath.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7225793
Share on other sites

  • 2 weeks later...

Car is back on the road - shock mounts plated and welded by M&A Engineering in Mitchell ACT - ended up doing both sides because the other side was also cracked - they didn't think it happened because the shock units weren't installed correctly.

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7236510
Share on other sites

Car is back on the road - shock mounts plated and welded by M&A Engineering in Mitchell ACT - ended up doing both sides because the other side was also cracked - they didn't think it happened because the shock units weren't installed correctly.

Great to hear mate!

If you don't mind my asking; what did they charge you to do the repair?

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7236575
Share on other sites

Good you found a decent fabricator to repair it, but I have seen many Stagea's and none have ever had that issue. The shocks were installed too short, it's the only way it could pull the stud through, as the spring tension is working against it. Hopefully it doesn't happen again...

Link to comment
https://www.sau.com.au/forums/topic/440310-coilover-issue/#findComment-7236694
Share on other sites

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I have no hard data to report, but I have to say, having driven it to work and back all week, mostly on wet roads (and therefore mostly not able to contemplate anything too outrageous anywhere)..... it is real good. I turned the boost controller on, with duty cycle set to 10% (which may not be enough to actually increase the boost), and the start boost set to 15 psi. That should keep the gate unpressurised until at least 15 psi. And rolling at 80 in 5th, which is <2k rpm, going to WOT sees the MAP go +ve even before it crosses 2k and it has >5 psi by the time it hits 90 km/h. That's still <<2.5k rpm, so I think it's actually doing really well. Because of all the not-quite-ideal things that have been in place since the turbo first went on, it felt laggy. It's actually not. The response appears to be as good as you could hope for with a highflow.
    • Or just put in a 1JZ, and sell me the NEO head 😎
    • Oh, it's been done. You just run a wire out there and back. But they have been known to do coolant temp sensors, MAP sensors, etc. They're not silly (at Regency Park) and know what's what with all the different cars.
    • Please ignore I found the right way of installing it thanks
    • There are advantages, and disadvantages to remapping the factory.   The factory runs billions of different maps, to account for sooooo many variables, especially when you bring in things like constantly variable cams etc. By remapping all those maps appropriately, you can get the car to drive so damn nicely, and very much so like it does from the factory. This means it can utilise a LOT of weird things in the maps, to alter how it drives in situations like cruise on a freeway, and how that will get your fuel economy right down.   I haven't seen an aftermarket ECU that truly has THAT MANY adjustable parameters. EG, the VAG ECUs are somewhere around 2,000 different tables for it to work out what to do at any one point in time. So for a vehicle being daily driven etc, I see this as a great advantage, but it does mean spending a bit more time, and with a tuner who really knows that ECU.   On the flip side, an aftermarket ECU, in something like a weekender, or a proper race car, torque based tuning IMO doesn't make that much sense. In those scenarios you're not out there hunting down stuff like "the best way to minimise fuel usage at minor power so that we can go from 8L/100km to 7.3L/100km. You're more worried about it being ready to make as much freaking power as possible when you step back on the loud pedal as you come out of turn 2, not waiting the extra 100ms for all the cams to adjust etc. So in this scenario, realistically you tune the motor to make power, based on the load. People will then play with things like throttle response, and drive by wire mapping to get it more "driveable".   Funnily enough, I was watching something Finnegans Garage, and he has a huge blown Hemi in a 9 second 1955 Chev that is road registered. To make it more driveable on the road recently, they started testing blocking up the intake with kids footballs, to effectively reduce air flow when they're on the road, and make the throttle less touchy and more driveable. Plus some other weird shit the yankee aftermarket ECUs do. Made me think of Kinks R34...
×
×
  • Create New...