Jump to content
SAU Community

Recommended Posts

It worries me a little that you have honed bores and reused old pistons that's in essence increasing the piston to bore clearance which would also increase your ring gap. Problem is unless you measured the Bore with telescopic gauge and micrometer you couldn't be sure how much taper the bore has, I've made a few assumptions here but it's just from experience also where did u set your ring gaps at what point in the cylinder ? How far from top?

Scott

Time to take it for a blat as per the earlier advice given to create pressure to push the rings on to the bore and bed them in

good luck

Post back results

Agree, run it in hard.

My fresh engine did 30x >300kw power runs after I drove it from first start to the dyno ~15min away.

Give the rings a chance to bed in and see where you're at after some (loaded) driving.

Mark :)

It worries me a little that you have honed bores and reused old pistons that's in essence increasing the piston to bore clearance which would also increase your ring gap. Problem is unless you measured the Bore with telescopic gauge and micrometer you couldn't be sure how much taper the bore has, I've made a few assumptions here but it's just from experience also where did u set your ring gaps at what point in the cylinder ? How far from top?

Scott

Was about 20-30mm from the top of the cylinder

It worries me a little that you have honed bores and reused old pistons that's in essence increasing the piston to bore clearance which would also increase your ring gap. Problem is unless you measured the Bore with telescopic gauge and micrometer you couldn't be sure how much taper the bore has, I've made a few assumptions here but it's just from experience also where did u set your ring gaps at what point in the cylinder ? How far from top?

Scott

Not to completely disagree, but just chuck some more Info in the mix.

The larger bore will reduce the amount of force a ring will exert on the bore (by a tiny bit)

Which will make the ring gap bigger, but in the scheme of things a larger ring gap gap by itself really has a negligible impact on the engine

http://www.diagnosticengineers.org/journal_%20articles/Ring%20Gaps%20vs%20Knowledge%20Gaps.php

If he has fitted new rings then they really should have been gapped to the bore after honing it, and those honing tools take 2/5ths of F all anyway, this is how I did my 32 last time and it has held together for a few good hard years of abuse and ran some really good numbers given its set up

To give a consistent 100psi then I would say something is a miss machanically, most likely cam timing

Thanks for all the info guys been giving it some stick over the weekend boosting from second gear upto 7000rpm 3rd about 700rpm and then just a little in 4th upto about 200km/h then down to about 80km from 2nd again and again

now I havnt checked the compression as yet I will try get a diffrent gauge aswell and lets see what the outcome is will keep you posted

It's actually funny how the old and sensible instruction to avoid idling a newly built engine coupled with the old and sensible advice to run the engine through a variety of loads and speeds (but not high load or high speed) has translated through the last 20 years into thrash the living f**k out of it from cold startup.

You don't need to arse rape an engine to get the rings to bed in. You just need to drive it sensibly.

  • Like 1

True if numbers are even that should be an indicator of another issue , I would personally never just hone. A 26 as it's such a big job to get to that point but each to their own I guess really in worst case could be a bit more blow by or just a more noisy engine but as was states earlier honing doesn't take much off but my point was more that an engine that has run for some time may have a taper in the bore, on some of the lesser engines I've built eg Honda lol if just being honed only I would check

The ring gaps at 3 different spots in the bore to make sure I wasn't going to have any dramas . Hopefully it's just a gauge issue in this case as sometimes it's the simple things that cause the most drama . Best of luck to the op ,

Scott

  • 2 weeks later...

Ok so tested compression again

And all seem to be the same 100psi when i put s9me oil in the chamber the increased to about 116psi

This was done with all 6 plugs out and the apexi read about 180 rpm should it not be 300rpm?

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • To follow up a question from earlier too since I had the front bar off again (fking!) This is what is between the bumper and the drivers side wheel And this is the navigator side, only one thing but its a biggy! So basically....no putting coolers in the wheel arches without a lot of moving other stuff. Assuming I move to properly race prepping this car I'll take that job on and see how the computers respond to removing a whole bunch of ADAS modules
    • So I prepped the car for another track day on Wednesday (will be interesting to see coolant temps post flushing out and the larger reservoir, with a forecast of 3-14 being 20o cooler than last time I took it out). Couple of things to mention; since I am just driving the car and not taking a support vehicle, I took the rear seats out and just loaded the back up Team Trackday style. Look at all that space! To cover off removing the rear seat....it is weird (note the hybrid is probably different because it wouldn't have folding rear seats) Basically, you remove the lower seat base, very similar to a r series but it is a clip that pulls forward to release the base rather than it being bolted down. Easy Then, you need to remove the side section of the rear seat on each side. There is a 14mm head nut at the bottom of the side piece, the it slides upwards off a hook at the top to release; you also need to unhook the seatbelt from the loop at the top. Then the centre piece is weird. You need to release/fold the seats forward with the tab in the boot on each side From there, there are 2,x12mm headed bolts holding the rear of each seat to the folding bracket, under the trim between the rear seat and the boot (4x christmas tree clips there, they suck). The seat is out but you can see where the bolts attach to the bracket
    • As discussed in the previous post, the bushes in the 110 needed replacing. I took this opportunity to replace the castor bushes, the front lower control arm, lower the car and get the alignment dialled in with new tyres. I took it down to Alignment Motorsports on the GC to get this work done and also get more out of the Shockworks as I felt like I wasn't getting the full use out of them.  To cut a very long story short, it ended up being the case the passenger side castor arm wouldn't accept the brand new bush as the sleeve had worn badly enough to the point you could push the new bush in by hand and completely through. Trying a pair of TRD bushes didn't fix the issue either (I had originally gone with Hardrace bushes). We needed to urgently source another castor arm, and thankfully this was sourced and the guys at the shop worked on my car until 7pm on a Saturday to get everything done. The car rides a lot nicer now with the suspension dialled in properly. Lowered the car a little as well to suit the lower profile front tyres, and just bring the car down generally. Eternally thankful for the guys down at the shop to get the car sorted, we both pulled big favours from our contacts to get it done on the Saturday.  Also plugged in the new Stedi foglights into the S15, and even from a quick test in the garage I'm keen to see how they look out on the road. I had some concerns about the length of the LED body and whether it'd fit in the foglight housing but it's fine.  I've got a small window coming up next month where I'll likely get a little paint work done on the 110 to remove the rear wing, add a boot wing and roof wing, get the side skirt fixed up and colour match the little panel on the tail lights so that I can install some badges that I've kept in storage. I'm also tempted to put in a new pair of headlights on the 110.  Until then, here's some more pictures from Easter this year. 
    • I would put a fuel pressure gauge between the filter and the fuel rail, see if it's maintaining good fuel pressure at idle going up to the point when it stalls. Do you see any strange behavior in commanded fuel leading up to the point when it stalls? You might have to start going through the service manual and doing a long list of sensor tests if it's not the fuel system for whatever reason.
×
×
  • Create New...