Jump to content
SAU Community

Recommended Posts

Hi everyone, ive got a series 1 R33. I got it last November, its only got about 75,000 on the clock at the moment. The other day i turned my boost up to 13 PSI. Ive got a cooler, pod and aluminium radiator so i was under the impression it should be able to handle the boost, but about 10 mins after winding it up, i was flying down a straight near where i live, and my oil light flashed on for a brief second and the car began to sound sick. I drove the car to where i had good light, popped the bonnet and my dipstick had been shot out, and oil had sprayed everywhere. My Temperature did not increase at all on the gadge. I put more oil in the car, turned boost right down and took the car home. I went through my coil packs, disconnecting them one at a time with the car running, and my 2nd cylinder isnt working, when i pulled the spark plug out, there was alot of oil in there. I know ive f**ked a bit up, but what i wanted to know about is, im thinking about putting in forged pistons cause they're stronger or something, i dont really know much but what else would i need to do besides the forged pistons to get it running so the car wont shit itself under higher boost. Also when i was lookin at forged pistons on the net, they had something about oversize n there were 2 sizes, +.020 and +.040. What is the difference and what would be better for me. also what are total seal gapless rings? What else will i need to do to the car to get it running sweet again bearing in mind i want the car to eventually have around 300 RWHP but thats not in the immediate future.

My email is [email protected] if anyone wanted to talk to my personally, thanks.

Link to comment
https://www.sau.com.au/forums/topic/116285-need-help-with-my-rb25-its-screwed/
Share on other sites

The +0.20 and +0.40 thou refer to the diameter of the piston. They are an option as sometimes when boreing/honing a chamber you may need to get slightly bigger piston sizes as factory sizes may be 20thou too small for example. To determine which you need you will have to accurately measure the diameter of the cylinder chamber...forgot the name of the tool you use.

I think the crank is good for 300HP but not sure on that info...maybe someone can confirm. But you will be needing new conrods, bearings, rings.... Not sure on how good the heads are and what they can take but you may need to upgrade valves, valve springs, etc....

I'd be looking for the culprit at this stage, while you wait for all your bits.

R33 on 13psi should be well into the rich and retarded section of the map, to have killed a ringland (most likely through detonation) really does point to a fuel issue.

Stock engine will do 300rwhp. Just get a wrecker engine in it.

R33 on 13psi should be well into the rich and retarded section of the map, to have killed a ringland (most likely through detonation) really does point to a fuel issue.

Stock engine will do 300rwhp. Just get a wrecker engine in it.

About the fuel issue, what would be making it screw up? What would of been responsible for the oil dipstick shooting out and spraying half my engine bay with oil? I thought they could handle up to 14 PSI but it wasnt healthy to drive around with it all the time as long as u had a decent cooler and exhaust to back it up. I sort of thought maby may have been a small problem there that would of came out eventually but by cranking the boost it bought it out alot sooner, and probably to a greater extent. Do you think it would be better to rebuild this engine, or get another 25, and use mine for spare parts whats still good on it? Which would be the cheaper option? Thx for your help guys im gunna try and get a mechanic apprenticeship somewhere, cause i dont really know much at the moment but where i live its a hole, not really any imports around here, which is what i want to be working on. So you guys are a great help at the moment, i appreciate it.

Oh also 1 last thing, is there anyway to check if the kms have been wound back and if so, what can you do about it if they have?

Edited by WebR33
Stock fuel pump?

yeh its a stock fuel pump but the car hasnt had a great deal of work done to it so i cant see how that should be a problem. Ive got a cooler, pod, exhaust, aluminium radiator and thats bout it engine wise.

yeh its a stock fuel pump but the car hasnt had a great deal of work done to it so i cant see how that should be a problem.
It's getting old and less able to keep pumping fuel at full pressure.
Ive got a cooler, pod, exhaust, aluminium radiator and thats bout it engine wise.
Is the pod shielded? Without shielding, you are simply sucking on hot air from the engine bay, then heating it some more through the 13psi boost you are applying. Regardless of the size of the IC, you are never going to cool the air down to "reasonable" temperature.

The dipstick popped out because you (at a minimum) smashed a ring land on the piston. This allows the pressurised air/fuel mixture to get past the rings and pressurise the sump; the easiest place for the pressure to go is out the dipstick hole, along with all the oil.

Is the pod shielded? Without shielding, you are simply sucking on hot air from the engine bay, then heating it some more through the 13psi boost you are applying. Regardless of the size of the IC, you are never going to cool the air down to "reasonable" temperature.

What do you use to shield pods, ive never seen or heard of them being shielded. Do you have to make them up yourself or can you buy them? If you buy them roughly how much are they?

The +0.20 and +0.40 thou refer to the diameter of the piston. They are an option as sometimes when boreing/honing a chamber you may need to get slightly bigger piston sizes as factory sizes may be 20thou too small for example. To determine which you need you will have to accurately measure the diameter of the cylinder chamber...forgot the name of the tool you use.

I think the crank is good for 300HP but not sure on that info...maybe someone can confirm. But you will be needing new conrods, bearings, rings.... Not sure on how good the heads are and what they can take but you may need to upgrade valves, valve springs, etc....

In regard to your post stealth, boring out cylinders, gives the car a touch more torque right? Are forged pistons already bored out or can they be bored? Just for general idea wat would the conrods, bearings etc that you listed before cost roughly, just a general quote to give me some idea of the cash im going to need for this thing, also would i be better buying a new engine as opposed to rebuilding my one?

In regard to your post stealth, boring out cylinders, gives the car a touch more torque right? Are forged pistons already bored out or can they be bored? Just for general idea wat would the conrods, bearings etc that you listed before cost roughly, just a general quote to give me some idea of the cash im going to need for this thing, also would i be better buying a new engine as opposed to rebuilding my one?

The pistons fit in the bores (cylinders) - so they aren't actually "bored out". It depends on how much damage you might have done to the cylinder after you did whatever you did at the time as to whether or not you need to bore the cylinders. That then determines what size pistons you need to fit - but they always bore the cylinders by a fixed amount (they can leave them standard, or they can bore them 0.020" / 0.5 mm bigger or they can bore them 0.040" / 1 mm bigger).

You should be able to re-use your conrods; bearings, from memory, are a bit over $100 (per set). If you are interested, I happen to have a set of ACL forged 0.040" / 1mm oversize pistons for sale - PM me for details.

WebR33,

You mentioned this:

Do you think it would be better to rebuild this engine, or get another 25, and use mine for spare parts whats still good on it? Which would be the cheaper option?

I would say your best bet would be to get another engine cheap and drop it in. Im not 100% but im sure i've seen full engine with all bolt ons except turbo for about $1600 floating around...

These engines are pretty robust and unless you're gonna go for mega mega power then i'd say just do the swap over.

Also,

Just goin on some of your replyies you dont seem too educated on the internal parts and so i strongly recommend you give rebuilding a miss. Sorry dude, im not bagging ya or anything -dont take it the wrong way..... Im just trying to be honest and save ya from stuffing up even more which is not hard especially if you miss something as small as clearances of 0.010 of a mm!!! Rebuilding an engine is not as easy as it seems. (Although it sometimes is to some dammit! :O)

If you get someone else to do the rebuild then buy all means go for it...but it will be costly as it is time consuming and 'upgrading' one part usually means you have to do another.

If you get someone else to drop the secondhand motor in, provided you supply the motor, the labor shouldnt cost you more than $500 absolute tops!

Edited by R33_STEALTH
Originally posted by blind elk

You should be able to re-use your conrods;

Maybe not...If he's smashed a piston there could be a good chance that the conrod may have bent...

Originally posted by Web33

In regard to your post stealth, boring out cylinders, gives the car a touch more torque right?

That would be the stroke cheif....

Edited by R33_STEALTH

here this might be of some use to u because u dont have any imports cars around and u need to lern i thaught this might help u on ur way to becomming a mechanic and help u fix ur car

there is a workshop manual for all ur car needs on the engin i have same engin as u and it is great for it

http://shop.importdriver.com.au/store/prod...ry198.inetstore

Edited by R33sedanturbo
WebR33,

Just goin on some of your replyies you dont seem too educated on the internal parts and so i strongly recommend you give rebuilding a miss. Sorry dude, im not bagging ya or anything -dont take it the wrong way..... Im just trying to be honest and save ya from stuffing up even more which is not hard especially if you miss something as small as clearances of 0.010 of a mm!!! Rebuilding an engine is not as easy as it seems. (Although it sometimes is to some dammit! :/)

If you get someone else to do the rebuild then buy all means go for it...but it will be costly as it is time consuming and 'upgrading' one part usually means you have to do another.

Hi guys. Umm yeh i agree stealth, i got no intention of doing this kind of stuff myself cause i dont know squat about mechanics, just try to get a rough understanding of things thats y i wanna get an apprenticeship as mechanic, not to get a trade more for personal interest cause they get paid f**k all. I just wanna work out roughly what parts im going to need to buy and how much cash im going to have to need to get em. I dont wanna just fix my engine then have to go through and change shit later on when i get stuff done to it, thats y i mentioned i wanted to get round 300hp further down the track which isnt too hard out of a 25. I appreciate the help you guys have offered me, i never thought forums would be so useful. Thanks for puttin up with my lack of understanding and explaining stuff in detail for me. About getting the rebuild stealth, i was thinking if i get a rebuild, its done i know its all sweet wont have to change stuff, whereas i buy another engine, i dont know wat problems it may have. I basically just want to do this right the first time, so i dont need to worry bout it again.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • perhaps i should have mentioned, I plugged the unit in before i handed over to the electronics repair shop to see what damaged had been caused and the unit worked (ac controls, rear demister etc) bar the lights behind the lcd. i would assume that the diode was only to control lighting and didnt harm anything else i got the unit back from the electronics repair shop and all is well (to a point). The lights are back on and ac controls are working. im still paranoid as i beleive the repairer just put in any zener diode he could find and admitted asking chatgpt if its compatible   i do however have another issue... sometimes when i turn the ignition on, the climate control unit now goes through a diagnostics procedure which normally occurs when you disconnect and reconnect but this may be due to the below   to top everything off, and feel free to shoot me as im just about to do it myself anyway, while i was checking the newly repaired board by plugging in the climate control unit bare without the housing, i believe i may have shorted it on the headunit surround. Climate control unit still works but now the keyless entry doesnt work along with the dome light not turning on when you open the door. to add to this tricky situation, when you start the car and remove the key ( i have a turbo timer so car remains on) the keyless entry works. the dome light also works when you switch to the on position. fuses were checked and all ok ive deduced that the short somehow has messed with the smart entry control module as that is what controls the keyless entry and dome light on door opening   you guys wouldnt happen to have any experience with that topic lmao... im only laughing as its all i can do right now my self diagnosed adhd always gets me in a situation as i have no patience and want to get everything done in shortest amount of time as possible often ignoring crucial steps such as disconnecting battery when stuffing around with electronics or even placing a simple rag over the metallic headunit surround when placing a live pcb board on top of it   FML
    • Bit of a pity we don't have good images of the back/front of the PCB ~ that said, I found a YT vid of a teardown to replace dicky clock switches, and got enough of a glimpse to realize this PCB is the front-end to a connected to what I'll call PCBA, and as such this is all digital on this PCB..ergo, battery voltage probably doesn't make an appearance here ; that is, I'd expect them to do something on PCBA wrt power conditioning for the adjustment/display/switch PCB.... ....given what's transpired..ie; some permutation of 12vdc on a 5vdc with or without correct polarity...would explain why the zener said "no" and exploded. The transistor Q5 (M33) is likely to be a digital switching transistor...that is, package has builtin bias resistors to ensure it saturates as soon as base threshold voltage is reached (minimal rise/fall time)....and wrt the question 'what else could've fried?' ....well, I know there's an MCU on this board (display, I/O at a guess), and you hope they isolated it from this scenario...I got my crayons out, it looks a bit like this...   ...not a lot to see, or rather, everything you'd like to see disappears down a via to the other side...base drive for the transistor comes from somewhere else, what this transistor is switching is somewhere else...but the zener circuit is exclusive to all this ~ it's providing a set voltage (current limited by the 1K3 resistor R19)...and disappears somewhere else down the via I marked V out ; if the errant voltage 'jumped' the diode in the millisecond before it exploded, whatever that V out via feeds may have seen a spike... ....I'll just imagine that Q5 was switched off at the time, thus no damage should've been done....but whatever that zener feeds has to be checked... HTH
×
×
  • Create New...