Jump to content
SAU Community

Recommended Posts

they have a pressure switch to tell the pump when to start pumping pressure again, because there is always a certain amount of pressure kept in an accumulator. the switch maybe faulty

have you tried just leaving the ignition on/engine off and see if the relay keeps clicking??

Interesting thread... I have a S2 with a similar problem... only when engine running, and only at idle, about every 5-10 seconds, coming from somewhere behind the steering wheel/under the bonnet maybe I hear a dull 'clunk' like a mechanical switch sound. It's really weird. I thought maybe low fluid level in ATTESA reservoir?

I have seen my 4WD light come on once. I pulled over & turned ignition off, then started it again and it went out & haven't seen it since...

Edited by DaveB
i also had this problem on my s1 coming from behind the glove box. my car had waranty so it was repaired for free. im going back to the auto sparky so will ask what the problem was

Hey Jerome did you find out what the problem was/how they fixed it?

the clicking is gone after changing the rear tyres and changing ride heights slightly.

wheel/tyre diameter change the cause of the clicking idle??

Interesting. Though I have stock wheels and brand new tyres in stock profile (205/55/R16) fitted at compliance ("Antyre").

Although it seems to only start after car has warmed up...

I ran the diagnostic as mentioned here by chook:

Have you all tried the attessa diagnostic ? http://www.skylinesaustralia.com/forums/4w...=4wd+diagnostic

and got fault code 77 - attesa pressure switch. Even after successfully resetting the fault codes, and starting the car and letting it idle for a couple of minutes, the fault code reappeared.

Anybody know where this infernal pressure switch is located???

I have no idea where the pressure switch is but I would recommend bleeding the system. I got the info on how to do it from some other threads but the jist is to jack the car up, get the ignition on to get the atessa pump running, bleed the air through the nipples above the rear diff, and and the rear of the transfer case from memory. Viola no more 4WD light coming on. I did this because on a hot day I could give the car bootful coming out of an uphill hairpin which guaranteed the Atessa system would kick in. (Under controlled conditions on a closed course of course). By the time I got to the top of the hill the light would be on. Bleeding the system stopped this from happening. The fluid to use to keep the reservoir topped up as you bleed is the same synthetic ATF as the auto.

My relay ticks every 15seconds when idling on my S1.

I have no idea where the pressure switch is but I would recommend bleeding the system. I got the info on how to do it from some other threads but the jist is to jack the car up, get the ignition on to get the atessa pump running, bleed the air through the nipples above the rear diff, and and the rear of the transfer case from memory. Viola no more 4WD light coming on. I did this because on a hot day I could give the car bootful coming out of an uphill hairpin which guaranteed the Atessa system would kick in. (Under controlled conditions on a closed course of course). By the time I got to the top of the hill the light would be on. Bleeding the system stopped this from happening. The fluid to use to keep the reservoir topped up as you bleed is the same synthetic ATF as the auto.

My relay ticks every 15seconds when idling on my S1.

Thanks yeah might have to try bleeding it. Castrol Transmax Z in gearbox/attesa/power steering right?

Thanks yeah might have to try bleeding it. Castrol Transmax Z in gearbox/attesa/power steering right?

Transmax Z sounds familiar. There are a number of threads on this and again it seems to come down to personal preference. I used Penrite ATF synthetic.

The summary.pdf specifies Nissanmatic fluid D and I believe this is available and reasonably priced from Nissan dealers ie $60 for 4 litres.

The files are for an R32 GTR but it should lead you in the right direction.

summary.pdf

bleed.pdf

troubleshooting.pdf

wiring.pdf

Transmax Z sounds familiar. There are a number of threads on this and again it seems to come down to personal preference. I used Penrite ATF synthetic.

The summary.pdf specifies Nissanmatic fluid D and I believe this is available and reasonably priced from Nissan dealers ie $60 for 4 litres.

The files are for an R32 GTR but it should lead you in the right direction.

Cool, thanks for that - good info :) $60 for 4 litres... Transmax Z was ~$70 for 4 litres from my local store; pretty close in price I guess. Reasonable price for a dealer though lol

drove back from bathurst and the click is back again and so are a massive pack of poor drivers with a sense of entitlement to the right lane and probably the same group of drivers that drive 10-15km/h below the speed limit until there are two lanes and then you all know what they do next....

drove back from bathurst and the click is back again and so are a massive pack of poor drivers with a sense of entitlement to the right lane and probably the same group of drivers that drive 10-15km/h below the speed limit until there are two lanes and then you all know what they do next....

:laughing-smiley-014:

Same here in a little road trip back from Pt Pirie only difference is my clicking is not back again - it just never went away :thumbsup:

Check your battery and the +ve cable and connectors coming off it. I found I had a similar issue on my GTR where the connectors on the positive terminal were corroding. Once I cleaned them up clicking went away.

Check your battery and the +ve cable and connectors coming off it. I found I had a similar issue on my GTR where the connectors on the positive terminal were corroding. Once I cleaned them up clicking went away.

Thanks ceedub - i'm gonna check that out, I have cleaned up the main terminals already but I'll check the things plugged into them.

Hmm thought to check the attesa reservoir after a drive, with engine still running, and it was just a little bit below the min.

Sooo I got some ATF (which the guy assured me was a direct substitute for Transmax Z, which I couldn't find in 1-litre containers, and I didn't want to pay $75) and topped it up. Top layer is a different colour now lol

Seems to have had a positive effect; clicking is down to every 30 seconds or thereabouts usually, sometimes a little more frequent, but never more often than 15-20. Is this normal?

I plan to bleed it in the nearish future (perhaps for 100,000K service) and check battery terminal connections (the auxiliary connections to the terminals, not the terminals themselves - thanks ceedub).

and check the earths as well. there are a couple around the car including one between the chasis and the rear subframe (attessa pump sits on the diff). you need good earth as well as power

and check the earths as well. there are a couple around the car including one between the chasis and the rear subframe (attessa pump sits on the diff). you need good earth as well as power

Thanks, will do :) So there is an earth connection from attesa pump -> chassis; can you remember off-hand where any other earth connections are that I should check for the attesa circuit?

they have a pressure switch to tell the pump when to start pumping pressure again, because there is always a certain amount of pressure kept in an accumulator. the switch maybe faulty

have you tried just leaving the ignition on/engine off and see if the relay keeps clicking??

the relay only clicks with the engine running.

Just thought guys, if the above is the case, does this suggest that it's more likely, or less likely that it's the pressure switch? ie. what is the significance of the relay only clicking with the engine running?

the earth goes from the chassis to subframe, opposite side to the exahust from memory. But now I think about ti the attessa pump has rubber mounts so it can't be earthed to the subframe - it must be earthed via it's plug loom

Thanks Duncan, I'll check it out. btw reading the info here - http://tyndago.googlepages.com/gt-rbleedingattesasystem - I discovered that there should be a connector under the driver's side dash somewhere to assist with bleeding the attesa system. All you need is ignition (engine not running), you disconnect the jumper and it starts the pump in a constant pressure mode... I think I have found this connector, it's sort-of on the firewall, behind the driver's kick panel. I might have a go at bleeding the system as soon as I have finished the wheel swap, seat removal/carpet scrub and interior change from woodgrain to silver etc... so in a few days

edit: it's called the 'air bleed connector', and appears in the second picture at that link

Edited by DaveB

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • There is a way, but it's not with the same cars. You need to find the same vintage of car, that we had. Realistically, that was an affordable car with aftermarket parts around. So what people need to find is a car that had a decent base in its day, and can be modified. They're looking for a car year make of 2010 to 2015 really... Aus could have done it if Holden didn't fold as V8 commodores were cheap, and if Ford didn't get expensive thanks to COVID, then you could cheaply play with FG Barras. Realistically, those are just a bit heavier, four door skylines. I'm sure the US and UK have similar cars they could find.
    • Haha I do that.. thats when it chirps..The bit point for me is almost non-existent. Otherwise I stall it. But yes, in terms of performance, the clutch is solid af.
    • Greg speaks wisdom. These dirty old Datsuns are only value when they are cheap. When they are not cheap, there is no value. Sounds contradictory, but it's true. We are now 20 years past the hey day of modifying cheap 90s JDM cars for small amounts of money. This is a different world. If you are rich and can afford not to care about what is effectively wasting money on an old Datto shitter, then I have no reason to argue against it. But if you are wanting to experience what we all experienced back in 2005 (and I bought my car last century!) then there is no way to do it.
    • Short answer: No. Medium answer: No, because you still need to conjure the things out of thin air to bolt them to a NA to make it a NA+T. Long Answer: No - The things you need to conjure - meaning a turbo, intercooling, manifolds, exhaust, intake/manifold/piping, clutch, injectors, fuel pump, AFM (?), ECU + Wiring (woo, N/A loom fun) have to come from somewhere. You could have many scavenged these things from an OEM car that someone had upgraded from and use some of these. This will be cost prohibitive now, especially so in the USA. You'd probably pay the same for newer, upgraded components that are better than old OEM stuff from 25-30 years ago. None of these big ticket items are re-usable for the N/A car. Why not buy new and upgrade while you're there? The only real consideration is turbo and fuel sizing and determining whether you want to stay within the bounds of the OEM engine or get into rebuild territory. These limits ARE lower with a N/A motor and especially N/A gearbox at the starting point. And if you're gonna upgrade those then you may as well consider having them built to begin with. Because everyone here knows you're never far from that next engine rebuild once you start making the power you want... The cars you see on the internet and SAU etc have been built over decades. If you're really clued in... you would sell your US car to somebody for what you paid for it. You would then scour AU JDM pages or SAU and buy a car like Dose's on this forum with your powerful American Dollar. This will save you so much money in the long term. Importing it could be tricky. Or it might not because USA. I have long said the only reason 90's Japanese stuff took off was because a) Japanese people had Japanese cars so that is what they used b) Australians could import these cars to Australia with very minimal changes and use them on the road here c) Neither country had well-priced access to US or EU Sports Cars. I don't believe the JDM scene would have taken off in Australia at all if we had EU priced EU BMW M offerings, or more especially the AUS V8 Scene would never have existed if we had the multitude of US cars like Camaros, Mustangs, Corvettes at the prices you folks do. After all - Do the math. I would say put a V8 in your R34 and that's the smart way forward. It is. I did it. I know this from my own experience. But at that point there's no reason to simply not buy a C5 or C6? It would be simpler and easier and cheaper and bette-
    • Reading all this... hurts lol. I have an ENR34 5MT and I paid an inflated USA price for the car alone, had to do tons of preventative maintenance past that, and so I'm over $30K USD into the car already and haven't even touched power.  I wanted to +t it. Not even trying to make GTR numbers, I'd be happy with 250hp.  Can I get away with paying much less to make that happen?
×
×
  • Create New...