Jump to content
SAU Community

Recommended Posts

ok here we go. Today it was nice so I decided to work on my car.

1st I wanted to diagnose why my horn wasnt working. Ends up being that the relay is bad.

2nd I wanted to bondo my fenders. Thought that I didnt have any hardner so I skipped that task(later found the hardner)

3rd Heat shrink the power wire that enters the engine bay and joins together with the upper and lower engine harness.

4th relocated my s-afc with the extended ash tray thing that I found at the junk yard.

So after all was done I decided to crank her up. Noticed that the throttle and afm wasnt reading anything. Both read 0. So I started to jiggle a few wired and nothing.

went over to the throttle body and unpluged it and the car dies. Normally the revs increase a lil bit but not cut off. Then I went over to the maf and unpluged it. Nothing happened. Now during this whole thing I noticed a lil smoke coming out the tail pipe(just a little bit) So I placed a rag over the maf sensor and nothing changed. I know there is something wrong here but then again why is the maf and throttle not reading on the safc???

When I peg the throttle the engine does like a delayed 2 step and the turbo builds boost. I guess somehow the timing is retarding causing this effect.

Does anyone have any ideas?? I drove the car for the past 3-4 months with no problems. I mean everything I did this afternoon was minor stuff. Any advice would be greatly appreciated.

Mods:

-1989 240sx

-rb25det

-safc

-boost controller 12psi

-3 inch exhaust with cat delete

-freddy intake manifold

-q45 throttle body

-fmic with RFL bov

-aftermarket radiator with slim fans (2 fans)

Link to comment
https://www.sau.com.au/forums/topic/255344-worked-on-my-car-today/
Share on other sites

ok here we go. Today it was nice so I decided to work on my car.

1st I wanted to diagnose why my horn wasnt working. Ends up being that the relay is bad.

2nd I wanted to bondo my fenders. Thought that I didnt have any hardner so I skipped that task(later found the hardner)

3rd Heat shrink the power wire that enters the engine bay and joins together with the upper and lower engine harness.

4th relocated my s-afc with the extended ash tray thing that I found at the junk yard.

So after all was done I decided to crank her up. Noticed that the throttle and afm wasnt reading anything. Both read 0. So I started to jiggle a few wired and nothing.

went over to the throttle body and unpluged it and the car dies. Normally the revs increase a lil bit but not cut off. Then I went over to the maf and unpluged it. Nothing happened. Now during this whole thing I noticed a lil smoke coming out the tail pipe(just a little bit) So I placed a rag over the maf sensor and nothing changed. I know there is something wrong here but then again why is the maf and throttle not reading on the safc???

When I peg the throttle the engine does like a delayed 2 step and the turbo builds boost. I guess somehow the timing is retarding causing this effect.

Does anyone have any ideas?? I drove the car for the past 3-4 months with no problems. I mean everything I did this afternoon was minor stuff. Any advice would be greatly appreciated.

Mods:

-1989 240sx

-rb25det

-safc

-boost controller 12psi

-3 inch exhaust with cat delete

-freddy intake manifold

-q45 throttle body

-fmic with RFL bov

-aftermarket radiator with slim fans (2 fans)

What about limp mode?? I noticed anouther cat on NICOclub had the same issue. Never told what it was or if he fixed it but it is the doing the exact thing. Would this happen if im throwing a code?? Im sure that I wired the check engine light into the cluster but not really sure how to check codes.

It will have something to do with the AFM wire that you have to use for the SAFC. Probably a dry solder join or it's come loose.

EDIT: Or you changed the settings on the SAFC accidentally where you have to program what type of AFM you are using.

Edited by PM-R33
What about limp mode?? I noticed anouther cat on NICOclub had the same issue. Never told what it was or if he fixed it but it is the doing the exact thing. Would this happen if im throwing a code?? Im sure that I wired the check engine light into the cluster but not really sure how to check codes.

Nah. All my settings on the safc where the same after reconnecting the battry. The power wire,blk and brn wires broke off but I soldered those back. Everything is still the same.

I pulled code 12(MAf) once. Could not get it to pop up again.

I als code code 55. I read here

http://www.northwestnissans.com/board/showthread.php?t=26965

that this means all ok. When I get home today I guess ill check over all wiring with the maf,tb, and safc

found the problem....

comes to find out that when I went to relocate my safc that I pulled just a lil to hard. At the end of the wires is a plug. Well the plug goes inside the safc and plugs into some computer board inside the afc. I had to seperate it in order to plug it back in. Plus my plugs where fouled out from the none maf voltage. cleaned plugs and reinstalled. All good.

Oh yeah. I noticed that everyone says that the rb25's run rich. Well I have huge throttle body and freddy intake so I subtracted 2% from 5500 rpms to 7 grand. She pulled like a champ

found the problem....

comes to find out that when I went to relocate my safc that I pulled just a lil to hard. At the end of the wires is a plug. Well the plug goes inside the safc and plugs into some computer board inside the afc. I had to seperate it in order to plug it back in. Plus my plugs where fouled out from the none maf voltage. cleaned plugs and reinstalled. All good.

Oh yeah. I noticed that everyone says that the rb25's run rich. Well I have huge throttle body and freddy intake so I subtracted 2% from 5500 rpms to 7 grand. She pulled like a champ

And you pulled the 2% without putting a wide band on it? f**king smart...

Get it on a dyno NOW and check the AFRs.

Not "every" RB25 runs rich. Some have minor issues and make them run lean, although they seem to run perfect. Just guess working is bad

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • You just need to remove the compressor housing, not the entire turbo. I would not be drilling and tapping anything with the housing still on anyways. 
    • So, I put my boat on a boat. First of all, I'm going to come out and say it. Why is Tasmania not considered a holy goal, an apex that all road-legal modified cars go to, to experience? This place is an absolute wonderland of titanic proportions. If people are already getting club runs for once in a lifetime 30 person cruises to Tassy then I've never seemed to see it. It is like someone replaced the entire place with an idyllic wonderland for cars, and all of the people living there with paid actors who are kind, humble, and friendly. Dear god. After doing a lap of almost all of the place I've found that it's a great way to find out all of the little things that the car isn't doing quite right and a great way to figure it all out. All in all, I drove for 4 hours a day for a week and nothing broke. I didn't even need to open the engine bay. This is by all means a great success, but it has left me with a list of things to potentially address. I also now have a 3D printed wheel fitment tool which annoyingly hasn't got any threads in it to actually assemble it. I might be able to tape it together to check the sizing I actually want to use, but it'll likely involving pulling the shocks out to properly measure travel at least at the front, and probably raise the car while I'm at it, at least in the rear. I scraped on quite a few things and I'm not sure how else to go about it. I was taking anything with a bump at what felt like 89 degree angles. And address those 10 other tasks. And wash the car. God damn it is dirty. And somehow, the weather was perfect the entire time - And because I was on the top of Mt Wellington it turns out it was very much about to freeze up there. I did something I typically never do and took some photos up there in what must have been -10 and the foggy felt like suspended ice, rather than mere fog. If you own a car in Australia, you owe it to yourself to do it.
    • Damn that was hilarious, and a bit embarrassing for skylines in general 😂 vintage car life ey. That R33 really stomped. Pretty entertaining stuff
    • Hi, I have a r32 gtr transmission. Does any of you guys have an idea how much power it will hold with the billet center plate and stock gearset? At what power level and use did yours brake with or without billet plate? Thanks, Oystein Lovik
    • Saw this replica police car based on a Mitsubishi Starion XX parked next to a 'police box' (it's literally a box) in Hirohata, Himeji City in Hyogo prefecture the other day. It's owned by Morii-san who is a local Mitsubishi Starion enthusiast. According to a local radio station blog post, he always wanted to make a police car himself based on ones he saw in his favourite Manga comics.  As it's illegal to modify a car to look like a police car and drive on the road, Morii-san tried many times to get permission from Aboshi police station headquarters nearby. They refused initially by after they got tired of that they granted him permission. However, the car can only be displayed on private property and obviously can't be registered as long as the police livery is present. The car was completed at a cost of 1.5 million yen (US$ 10,000) in addition to the car cost. A location was chosen outside Hirohata Police box where the car can easily been seen from the street. Morii-san has two other Starion road cars, both widebody GSR-VRs.
×
×
  • Create New...