Jump to content
SAU Community

Recommended Posts

Soooo, I have a s2 rb25 in a stagea. Power FC, splitfires, z32 afm, td06, nismo 550cc injectors, gtr fuel, tuned at 18psi.

Has been running fine for 6 months until yesterday it has developed a misfire under load and full boost. Seems ok at very light load and cruising.

Has constant miss when you stand on it and try and rev it out, also get a lot of black smoke out back.

Knock doesn't go above 18 with this happening.

I checked injector value in pfc and it got up to 90% just once, normally around 68-70% WOT. AFM voltage with car off is 0.42v according to the power fc and 1.72v at cruise approx.

I took plugs out (bpr7es gapped at 0.7), and swapped with some other spares I had laying around (not new but known working) and made very little difference.

I sprayed all the vac lines and hose clamps with brake cleaner but no change in idle speed. I did find 1 loose hose clamp after the turbo outlet under the air filter, but after tightening that, no change has been observed.

It was dark when I got into changing the plugs so I couldn't inspect the coil packs thoroughly. Might get around to it on the weekend.

Any suggestions.

Link to comment
https://www.sau.com.au/forums/topic/458035-another-rb25-misfire-topic/
Share on other sites

Cleaned afm, no change. Pulled coil pack leads 1 by 1 and idle got rough with each one. Seems to be when you get close to building boost it starts and then sputters then entire time on boost. Idles like normal, doesn't stall or dive.

That ain't going to help.

Tps voltage is 0.44v at idle. Check power to all coil pack plugs (14.19v across all 6). Unplugged afm and car died straight away.

I'm a bit stuck as to where I should check next? I went to repco and they didn't have any bcpr6es or bcpr7es on the shelf. I would have to order out of adelaide. I'm located alice springs so I can't just duck into a workshop with a dyno and it's my daily so I really wanna get this sorted

New plugs are in but only gapped at 0.8. Hesitates still coming onto boost but then clears up and revs clean through to redline. Makes the same amount of boost as normal once it gets up and goes. would pulling the gap back further make much of a difference that early in the Rev range if it clears up and revs clean after about 7psi?

Idles perfectly, and drives off boost as it did beforehand.

Also checked timing, 20deg btdc cold and fuel filter is new.

Hasn't got any leaks that I can see, no smoke from and where when it's running.

Edited by fmlycar

Just ask an R31 owner.

543.JPG

I don't understand. What is this. Will it fit in my RB30? just looking for a bit more power from my completely standard auto NA 1985 R31 that has 385,000 on the clock. Want to spend as little as possible thanx.

  • Like 1

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Seat of the pants assessment of the new intake: The car is way less "doughy" when hitting the loud pedal, especially off idle when stopped or in traffic, I did use a cheapo lazer thermal thingo to measure the temp around where the pod filter got its air, it was between 55 - 60°C, in saying this the car was shut off and not moving, so the OEM intake pipe was not supplying any fresh air to where the pod was when the car was at least moving A weird bonus was induction noise on the throttle in the cabin increased a bit,  I was worried that I was actually going to lose some of that induction noise I love so much, outside though, when I got the daughter to do a WOT drive by pass for me, the induction noise has increased alot when on the throttle, not quite ITB doort, but well up there I'm extremely happy with the results and have been exploring the country roads in the region  As for house mods: 1.New front fence is up and is awesome, it really upgraded how the joint looks from the street, and the added security is nice 2. Electricians have replace some interior lights, and with more lighting in the garage, a few new motion detecting lights out the front above the garage, front room, and at the front door, which I have already found heaps helpful coming and going, also now has fancy pants CCTV all round the house The only hold point for power though is the solar and batteries due to supply issues, although this will happen over the next few weeks 3. I have done a heap of landscaping out the front and I'm almost ready to do a new small retaining wall with some nice blocks to replace the brick and cemented in rocks around the raised garden beds cemented in river stone "was the fashion at the time" the house was built. I currently have a pallet of retaining wall blocks and 2 bulka bags of 20mm blue metal to replace the wood chip that is in the raised garden beds around the house 4. I now have 3 big raised garden beds for out the back to grow some vegetables, about 70cm high, 200cm long and 100cm wide 5. My 2 compost bins are already pretty full with brown, green and kitchen waste from the landscaping I'vedone so far, but they will probably take a few months to break down, so anything else that gets chopped, trimmed, and kitchen waste will just start filling the base of the raised garden beds to about 30cm before I start throwing 40cm of good compost, and stuff, for the vegetables to grow in, I'll need a few ton of compost and soil, but the local supplier can sent me bulka bags of the stuff Basically the logs, wood chips and a few strategically placed rocks for drainage, will give the beds some good organic materials down low to break down over time, and they will hold moisture during the warmer months to save the water in my big arse water tank if we don't get alot of rain So, all in all, the car and house mods are going well, and I'm really enjoying being retired, I sleep in too 0700 and slowly plod around inside until I feel like actually doing anything, and only work in the yard for as long as want, which has actually been alot over the last few weeks,  although when you look at it, it seems that not a huge amount of work has been done,  until I look at the before I started the work pics Happy days and good times indeed 
    • hahaha yeah. Plan is to get side skirts and probably just rear pods. But going to do them one-by-one. I've got a set that I really like from RHDJapen, but that one isn't shipped to AU. So need to find someone who can get it for me
    • Here's an idea, answer the questions I asked you as they are trying to work out WHY the LSD will be binding up in a straight line.
    • You haven't driven many modern cars then have you? Most of them have sfa steering feel with their stupid electric bullshit steering systems.
×
×
  • Create New...