Jump to content
SAU Community

Recommended Posts

Hi,

Darren, LEWIS ENGINES is fair busy at the moment so im thinking about doing a port job myself (with a lil bit of guidence from him if he has time).

Does anyone know where the RB26 head lacks in flow, what curves work best, and what section of the port needs most work?

keeping in mind its going on a RB30 block.

Link to comment
https://www.sau.com.au/forums/topic/148813-rb3026dett-head-porting/
Share on other sites

not looking for shitloads of power, looking for reliability and midrange power. its for daily driver/G1 drift. i understand that i dont need to do a port job but if i have the oppertunaty to do it i may as well even if its only to put less strain on the engine.

stock or high flow GTR-32 turbos, stock cams, forged Airies pistons (fair sure there for 8.5:1 with 26 head), shot pined rods. so nothing to insane.

any ideas/tips for the port work?

(i have access to all machinery and a flow bench)

Edited by =premo=

I wouldn't touch it at all period, unless you know what you are doing and have had previous experience porting that type of head. Its just to easy to make it go backwards as already stated.

On the topic however, here is a good job

http://www.calaisturbo.com.au/showthread.php?t=64627

Cubes and myself had Chris Milton do our rb25de heads. The usual deshroud and a 3 angle valve job (ask cubes for details) as well they didnt polish the inlet to help the fuel / air mix properly (or something like that).

It is a damn good job done (ive got pics somewhere), as Cubes and myself dont have to run as much boost as some to get good numbers.

yeh fair enuf. 3 angle and all that is a job ill leave to Darren (i dont want to break his seat cutting tool).

Darren knows how to port heads very well but he doesnt have time to do it, so im just trying to learn a lil to see if i can give it a go. he can give me the calculations for comparing the exhaust to inlet flow ratio's but it would take too long for him to teach me where and how to make them flow more.

I understand its the exhaust side that hurts the RB26 head. But i still wouldnt do anything more then match port the manifolds.

If you are serious about doing it then i would grab on old RB20 head do all the chambers etc differently and get plenty of practice. The take the RB20 head to your friend and gt him to explain the parts you have done right and the ones you have done wrong.

I still wouldnt mess with an RB26 head...get it wrong they are lots of money to replace. The money is far better spent on some decent turbos rather then stockies that are a concern or hi flows

If your only keeping the stocker turbos/steelies etc.

Then you really dont need to go too far at all, really just a very very basic touch-up seems to be what everyone aims for unless its going over the 350-400rwkw mark, which you wont be so you dont really need to worry about that

so clean em up a lil, get rid of the lumps from the studs/match ports and get rid of the sharp edges on the vaulve guides on the exhaust side?

any other idea's or specific problem spots?

If you have access to a flowbench it makes it easy to see where you are going. Where you will make the biggest difference is to work mostly on the exhaust port and try to bring the exhaust up to around 75% of what the inlet flows.

What I would do if I was you is:

-Blend the bowls on both intake and exhaust, that is the area under the valve seat where it is machined. Smooth the transition from the machined bowl into the cast area.

-Smooth the short side radius so it doesn't have a sharp edge there, don't remove any more metal than is needed to get a radius there.

-Knock the bump out of the exhaust port to make the port evenly oval and blend this back up the port.

-Remove any dags in both the intake and exhaust ports.

-Sand the ports smooth. I use 80 grit porting rolls and flappers, dont go any smoother than 80 grit and leave it with the sanded finish.

-Dont knife edge the intake divider, leave it with a smooth radius. You can knife edge the exhaust divider as it wil give you a little extra port.

-I use a 3 angle intake cutter, 20/45/65, with a 1mm seat. For the exhaust I use a Serdi or Newen radius cutter, also with a 1mm seat.

-back cut the intake valves at 30 degrees, from to about .5mm from the seating area.

-Unshroud the valves in the chamber with a radius cutter (about 2mm radius) from the top of the top cut on the seat to the edge of the chamber.

-Smooth out any bumps in the chamber and radius the top edges of the chamber carefully.

That should be enough to make a noticeable difference, especially on a 3 litre. Some people say you don't need to port them because they are turbo'd etc.. but if you make the engine more efficient it will always make more power or the same power with less boost.

Most heads are designed to flow really well but the reality of making them means that by the time the initial design is cast and machined they never work as well as they were supposed to. All you need to do is get it as close to what the initial design was. If you want some photos let me know and I'll dig some up.

thank you. your input is exactly what i needed. this way i dont have to ask Darren every 15min "what should i do here"

why leave the intake divider?

does it make a difference leaving a sanded finish in the chamber?

pics of seats and vaulves would be excellent just so i can make sure im following you right. also of the exhaust port to show how you blended the shape back.

thanks again

  • 1 month later...

Here is a bit of info about porting a head for an RB30:

Street car: R32 GTS4, 100% stock unmodified internals, standard g/box, 10.21@134mph. 600whp. Fastest street skyline in NZ.

R33 UK001 GTR, RB30, stock head, cams etc 646whp (4wd roller dyno) 10.77@133mph heavier than stock.

www.ripsltd.com

Per Rob over at RIPS NZ.

646WHP with COMPELTELY stock head.

-Sayajin

Thats max horsepower. What turbo's did they use?

I think alot of people forget that the goal of porting sometimes isn't just for outright power, but for improvements in midrange power. ie street use and circuit racing.

Thats max horsepower. What turbo's did they use?

I think alot of people forget that the goal of porting sometimes isn't just for outright power, but for improvements in midrange power. ie street use and circuit racing.

Very true....

-Sayajin

so clean em up a lil, get rid of the lumps from the studs/match ports and get rid of the sharp edges on the vaulve guides on the exhaust side?

any other idea's or specific problem spots?

Don't remove the stud lumps...just improve their shape by getting rid of the sharp bump on the inner edge and lowering the height. If you remove it you will end up damaging the head.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...