Jump to content
SAU Community

Recommended Posts

Hey guys,

Been a while since my last tutorial so thought it was time for another while I was fixing something.

Long story short, For the past 6 weeks now my starter motor has had a really loud squeal for the first 2 seconds of turning on the car and I was sick of it and worried something bad would eventually happen.

DISCLAIMER: This is how I fixed my squeal, yours may be more serious and need a replacement unit. I take no responsibility if someone attempts this and the results are not the same as mine. Also, none of the cog fins were bent in mine, meaning it had not been rubbing against the flywheel so I knew there was not going to be any damage putting it back in and reusing it.

Tools:

Torch - I guarantee it is necessary

A good socket set

A pair of hands that can get into VERY tight places

Lubricants and cleaning agents

Time required: 15-30mins for someone who has taken it off before, 1hr+ for someone who hasent. 15 mins of cleaning and another 30 mins of putting it back on.

Level of difficulty: Easy-Medium

1. Disconnect the battery as it is wired directly to the starter motor. For R33 that normally involves getting into the boot behind the carpet. Instead, I decided to disconnect the terminal that the starter motor connects directly to in the engine bay. It is under the fuse box lid located on the drivers side. Make sure you cover the lead so it doesn't touch anything, just to be safe

SNC00743.jpgSNC00742.jpg

2. Find the Starter motor. It is located here

med_gallery_36975_3432_161982_2.jpg

3. Remove this plastic cover on the solenoid and undo the bolt that holds the lead to it and disconnect the thin black wire as well. There should now be no wires connected to the starter motor and solenoid.

It is best to do this from the top of the car, not underneath.

SNC00738.jpg

4. Get underneath the car and only just loosen the bolt in the bottom left hand corner of this picture a tiny bit. This is because it is one of the two bolts that holds the starter motor to the bell housing and the other one is much harder to get to so this will take the pressure off the top one.

SNC00727.jpg

5. Now the top one. This one takes the most of your time. It is probably one of the hardest bolts I have ever had to get to on the Skyline. I managed to get it from on top, but whatever way works for you.

It is located just in front of the firewall towards the top of the bell housing that faces the front of the car. It took me 5 minutes just to get this clear pic.

SNC00740.jpg

If you are struggling, the way I did it is get onto the engine, put one knee on the drivers side strut tower, the other on the radiator support bar and looked right down here towards the ground. I then used my left arm and ripped 500 grams of skin off by jamming it all the way down there with my ratchet and a 14mm socket and took it off while watching it from the top.

SNC00741.jpg

6. That was the hardest part. Now undo the bottom bolt and remove the unit from the engine. I did it from underneath.

This is what you get. Very dirty.

SNC00530.jpgSNC00529.jpgSNC00571.jpg

7. Clean it up internally as best you can, I used a combo of degreaser and wd40 to clean it up. The problem with these though Is they get rid of grease and you do want some. Once it was as clean as I could get it I needed to Lube it. We had some Motul chain lube spare which is a thin grease, which is good for this application.

SNC00597.jpg

8. This is how it should look cleanish. You should be able to move it one way fairly easily, it will be a little stiff, the other way should be very very stiff if not movable at all. This is because it is a one way bearing.

SNC00615.jpgSNC00636.jpg

9. Now put back in the reverse method of above. Once again I put the bottom bolt in first from undearneath, then got on top of the motor and did the top one, found it alot easier putting the unit back in then getting it out.

And your done! Hope this helped you guys.

Adam

BIG TIP: If you want to test it out of the car and see if it still squeals after being cleaned, get a car battery and hook it up to it for a few seconds. You could also hook it back into the car and hold it while it spins, just be careful.

Link to comment
https://www.sau.com.au/forums/topic/333872-fixing-starter-motor-squeal/
Share on other sites

just as a side note.... pulling that terminal off in the engine bay could result in shorting to chassis. You should always disconnect the negative terminal from the battery so that you remove the 'ground' circuit and you cant have wires still shorting to the chassis

other then that good write up, hopefully I'll never have to do it but its good to know for when it happens lol

just as a side note.... pulling that terminal off in the engine bay could result in shorting to chassis. You should always disconnect the negative terminal from the battery so that you remove the 'ground' circuit and you cant have wires still shorting to the chassis

other then that good write up, hopefully I'll never have to do it but its good to know for when it happens lol

Yeh, honestly was not 100% sure but my way seemed to work if you are careful with the terminal. For me to get to my battery from the boot would take about 1.5-2 hours alone to remove amps mounted on a custom floating wall and all that, and I normally go through the back seat by removing the backseat and the plate behind it but it was raining outside and I was doing it in my garage where i can only open my door 1/3 of the way to get out so I couldn't pull out my backseat :(

glad you guys liked it.

One further thing that should be noted, the bushes in these are sintered bronze bushes, meaning they are porous. They are soaked with oil before fitting as this is the only lube they get. In the link showing the picture below, it shows quite a lot of clutch dust stuck to the housing. This dust can get into the bush and soak the oil up. Its usually worse if the driver continually slips the clutch, either by riding it or slipping it a lot during take off.

picture

Edited by kjb_r33
  • 7 months later...
  • 2 weeks later...

not much experience with starters screeching n shiz... but my 33gtrs one is spastic sounds like crap when u crank it and even after u let go for a split second it still does it .... since its got low comp and a bottom end knock i think ill just have a look into that now :D STARTER SKILLZ ERE I COME! lol thanks for the diy WYTSKY!

One further thing that should be noted, the bushes in these are sintered bronze bushes, meaning they are porous. They are soaked with oil before fitting as this is the only lube they get. In the link showing the picture below, it shows quite a lot of clutch dust stuck to the housing. ....

picture

That is probably from when I turboed the car and the factory n/a clutch went in 4 hrs :P

not much experience with starters screeching n shiz... but my 33gtrs one is spastic sounds like crap when u crank it and even after u let go for a split second it still does it .... since its got low comp and a bottom end knock i think ill just have a look into that now :D STARTER SKILLZ ERE I COME! lol thanks for the diy WYTSKY!

You welcome :)

  • 6 months later...

this is a long shot but I got my starter motor in bits but i cant get this piece out..

08102011727.jpg

its the last bit, im pretty sure that white ring should pop out but I cant get it to budge..

heres the rest of the bits if anyone is interested

08102011728.jpg

also the only grease i have is castrol High temp wheel bearing grease and a can wd40 3in1 lubricant which is for chains and stuff but its very thin

http://www.3inone.com/products/ptfe-spray-lubricant/

thats what i thought as well but there is no way to get the fork out..

its like the whole assembly just need to slide upwards and out but i cant get it to budge..

Do you know how to get the fork out?

this is interesting, 626 starter motor is identical..to mine..

couldnt hit the end with a shaft becaue it has a cap on top..

What i did do is soak it in wd40 fro the night..still wouldnt budge..turned it upside down and shook it like crazy cause the wheel kept bouncing i guess it slowly tapped itself out till it fell on the table :D

Thing is packed with clutch dust though, i think it will appreciate the clean

  • 1 month later...
  • 7 months later...

The easiest way to get to the top bolt is to have about 2 long extentions on the ratchet and a bendy adaptor behind the socket, then push it in from the front. I managed to get it on there first go, but that might have been pot luck. I had the old one out and the new one in in under an hour.

I got mine out easy and it was on a 32 (RB25) which means less space. First unbolted the fueI line bracket and fuel filter brackets and pushed them down and forwards, used a deep socket and a short extension (about 5cm) and put my right arm down between the strut tower and under the plenum while looking down just behind the plenum with a small torch. Socket on and push downwards. May have to unplug and move the injector harness a bit, but this way did not take long at all.

  • 5 years later...

bit of a topic revival - the whining sound that comes from it - would you get it from starting up the car, then it stops, then it starts back up again?

I'm starting to get a high pitched squeal on intermittent start ups - wracking my head as to what is actually the cause, but then also after driving for a while the sound will come back and then go. it sounds like an angry bearing noise. 

Edited by BstewyR33
6 minutes ago, BstewyR33 said:

bit of a topic revival - the whining sound that comes from it - would you get it from starting up the car, then it stops, then it starts back up again?

I'm starting to get a high pitched squeal on intermittent start ups - wracking my head as to what is actually the cause, but then also after driving for a while the sound will come back and then go. it sounds like an angry bearing noise. 

Have you checked your belts? What you're describing sounds more like a loose belt

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...