Jump to content
SAU Community

Recommended Posts

Ok, if the head has been skimmed it is possible that the cam gears need adjusting, bolting them back where they were might have them slightly advanced or retarded. There is adjustment on the back side of the factory gears.

This might be another avenue to run down if there is still some head scratching.

Why dont you tune it for E85, it loves high compression. Will also prove the sensor is fine.

looks like we're screwed for that in qld , unless you're prepared to custom order by the drum.

No pumps here (that ive found and ive done some research) and doesnt look like there will be for a good while yet!

:)

Edited by PetroDola
Ok, if the head has been skimmed it is possible that the cam gears need adjusting, bolting them back where they were might have them slightly advanced or retarded. There is adjustment on the back side of the factory gears.

This might be another avenue to run down if there is still some head scratching.

Thanks, *hopefully* this was ruled out by checking the static timing at idle ie. dial in 15 degrees on the ECU and the timing read 15 degrees; although the timing is read off the crank pully isn't it... hmm

Just a thought: if it was the CAS sensor, and the timing is already going absolutely nuts by 4,000-5,200 RPM, should I be able to free-rev the engine to 6,000 or drive under light load to those revs without massive pinging?

Basically what I'm saying is I don't think engine load makes any difference to the CAS sensor...

Edited by DaveB
  • 1 month later...

Ok... an update. Replaced CAS (thanks Bob) but no change; spoke to the tuner and arranged to get the head gasket replaced rather than rebuild again; was finished this week.

At last, engine issues appear to be sorted :D There was another R34 with an RB25 which was rebuilt in exactly the same way, with the same pistons by the same workshop using the same machine shop etc etc and it made 280rwkw after installation of a thicker head gasket. I had my engine repaired in the same way and retuned, now making about 230rwkw with the auto and awd; not too bad a result.

post-32445-0-70723100-1292762090_thumb.jpg

I can say that, when trying to make power, it really sucks to have an auto. The same tune in a manual R34 should be at least 260-270 rwkw IMO. But, I like the way the auto drives, and I like not having to pay for clutches. Plus stall launches at ~13psi are just *awesome*. What is your 'real-life power test' Bob - was it 80-100? 80-120? I can't remember... will have to check it but it gains speed pretty swiftly now, even up there.

Tuner has raised the rev limit to 7,150 which makes 2nd gear a lot more usable; especially for overtaking on the highway... plus 380kms out of the first tank not toooo bad I guess since was only ~410kms before with much less BOOST.

So a note for future reference: if you rebuild your NEO RB25DET with CP forged pistons, you will need to measure things up very carefully; I needed a 1.8mm head gasket (I think that's what it was) instead of the usual 1.3mm to get "quench" area right. The problem with detonation appears *not* to have simply been high static compression, as I originally thought (or else I would have perhaps been justified in wanting some more in the way of compensation from the engine builder), but I believe instead it was something about the piston design where it wanted more squish/quench area to prevent something weird with the flamefront which was causing pre-ignition... sounds fuzzy and it is (in my mind anyway). This change of .5mm head gasket thickness meant a return of ignition advance and large increase in power without detonation.

BTW I am unaware of any off-the-shelf forged pistons for NEO. The only ones I have heard of are custom orders from the US which are copies of the stock cast item, but made in forged.

Edited by DaveB

230awkw is not too shabby - your overtaking should be much easier! In my auto I timed it from 80 to 120 which you will easily do in 2nd gear ( I did it accelrating through 80 rather than flooring it at 80 just becasue its eaier to get it right).. I would guess you would be doing it in 3-4 seconds now. How much boost are you running now? Post up your chart in the RB25 dyno results in the forced induction section along with you list of mods. Do you have E10 available in your area? (E85 is a whole other story).

230awkw is not too shabby - your overtaking should be much easier! In my auto I timed it from 80 to 120 which you will easily do in 2nd gear ( I did it accelrating through 80 rather than flooring it at 80 just becasue its eaier to get it right).. I would guess you would be doing it in 3-4 seconds now. How much boost are you running now? Post up your chart in the RB25 dyno results in the forced induction section along with you list of mods. Do you have E10 available in your area? (E85 is a whole other story).

I'm running 18 psi max boost but its dropping to about 16-17 apparently (turner told me this, apparently have hit the turbo's limit). E10 is available at a couple of servos, I will have to give it a go once I have a new fuel filter standing by... or perhaps even before. The iebc wouldn't work for the tune after I tried reducing the bleed orifice size to about 1mm so he plumbed a boost T in instead which is working up top but I'm missing the fast boost build of the electronic controller a LOT. So will swap back at some stage. Car is apparently tuned to 19+ psi so I can just setup the boost myself.

Edited by DaveB

What turbo is it Dave?

It's a GCG high-flowed stock '34 (the OP6 housing)

tune on 95. run it on 98. always safest method.

I wondered about that... seems that my pinging problems weren't really timing related though

i'm tuned on bp ultimate but can get up to 40 xtra k's on v power,dunno why, some say both are out of thew same refinery, weird eh.

ps wonder how i'd go tuned on v power?

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Next on the to-do list was an oil and filter change. Nothing exciting to add here except the oil filter is in a really stupid place (facing the engine mount/subframe/steering rack). GReddy do a relocation kit which puts it towards the gearbox, I would have preferred towards the front but there's obviously a lot more stuff there. Something I'll have to look at for the next service perhaps. First time using Valvoline oil, although I can't see it being any different to most other brands Nice... The oil filter location... At least the subframe wont rust any time soon I picked up a genuine fuel filter, this is part of the fuel pump assembly inside the fuel tank. Access can be found underneath the rear seat, you'll see this triangular cover Remove the 3x plastic 10mm nuts and lift the cover up, pushing the rubber grommet through The yellow fuel line clips push out in opposite directions, remove these completely. The two moulded fuel lines can now pull upwards to disconnect, along with the wire electrical plug. There's 8x 8mm bolts that secure the black retaining ring. The fuel pump assembly is now ready to lift out. Be mindful of the fuel hose on the side, the hose clamp on mine was catching the hose preventing it from lifting up The fuel pump/filter has an upper and lower section held on by 4 pressure clips. These did take a little bit of force, it sounded like the plastic tabs were going to break but they didn't (don't worry!) The lower section helps mount the fuel pump, there's a circular rubber gasket/grommet/seal thing on the bottom where the sock is. Undo the hose clip on the short fuel hose on the side to disconnect it from the 3 way distribution pipe to be able to lift the upper half away. Don't forget to unplug the fuel pump too! There's a few rubber O rings that will need transferring to the new filter housing, I show these in the video at the bottom of this write up. Reassembly is the reverse Here's a photo of the new filter installed, you'll be able to see where the tabs are more clearing against the yellow OEM plastic Once the assembly is re-installed, I turned the engine over a few times to help build up fuel pressure. I did panic when the car stopped turning over but I could hear the fuel pump making a noise. It eventually started and has been fine since. Found my 'lucky' coin underneath the rear seat too The Youtube video can be seen here: https://www.youtube.com/watch?v=uLJ65pmQt44&t=6s
    • It was picked up on the MOT/Inspection that the offside front wheel bearing had excessive play along with the ball joint. It made sense to do both sides so I sourced a pair of spare IS200 hubs to do the swap. Unfortunately I don't have any photos of the strip down but here's a quick run down. On the back of the hub is a large circular dust cover, using a flat head screw driver and a mallet I prised it off. Underneath will reveal a 32mm hub nut (impact gun recommended). With the hub nut removed the ABS ring can be removed (I ended up using a magnetic pick up tool to help). Next up is to remove the stub axle, this was a little trickier due to limited tools. I tried a 3 leg puller but the gap between the hub and stub axle wasn't enough for the legs to get in and under. Next option was a lump hammer and someone pulling the stub axle at the same time. After a few heavy hits it released. The lower bearing race had seized itself onto the stub axle, which was fine because I was replacing them anyway. With the upper bearing race removed and the grease cleaned off they looked like this The left one looked pristine inside but gave us the most trouble. The right one had some surface rust but came apart in a single hit, figure that out?! I got a local garage to press the new wheel bearings in, reassemble was the opposite and didn't take long at all. Removing the hub itself was simple. Starting with removing the brake caliper, 2x 14mm bolts for the caliper slider and 2x 19mm? for the carrier > hub bolts. I used a cable tie to secure the caliper to the upper arm so it was out of the way, there's a 10mm bolt securing the ABS sensor on. With the brake disc removed from the hub next are the three castle nuts for the upper and lower ball joints and track rod end. Two of these had their own R clip and one split pin. A few hits with the hammer and they're released (I left the castle nuts on by a couple of turns), the track rod ends gave me the most grief and I may have nipped the boots (oops). Fitting is the reversal and is very quick and easy to do. The lower ball joints are held onto the hub by 2x 17mm bolts. The castle nut did increase in socket size to 22mm from memory (this may vary from supplier) The two front tyres weren't in great condition, so I had those replaced with some budget tyres for the time being. I'll be replacing the wheels and tyres in the future, this was to get me on the road without the worry of the police hassling me.
    • Yep, the closest base tune available was for the GTT, I went with that and made all the logical changes I could find to convert it to Naturally Aspirated. It will rev fine in Neutral to redline but it will be cutting nearly 50% fuel the whole way.  If I let it tune the fuel map to start with that much less fuel it wont run right and has a hard time applying corrections.  These 50% cuts are with a fuel map already about half of what the GTT tune had.  I was having a whole lot of bogging when applying any throttle but seem to have fixed that for no load situations with very aggressive transient throttle settings. I made the corrections to my injectors with data I found for them online, FBCJC100 flowing 306cc.  I'll have to look to see if I can find the Cam section. I have the Bosch 4.9 from Haltech. My manifold pressure when watching it live is always in -5.9 psi/inHg
    • Hi My Tokico BM50 Brake master cylinder has a leak from the hole between the two outlets (M10x1) for brake pipes, I have attached a photo. Can anyone tell me what that hole is and what has failed to allow brake fluid to escape from it, I have looked on line and asked questions on UK forums but can not find the answer, if anyone can enlighten me I would be most grateful.
    • It will be a software setting. I don't believe many on here ever used AEM. And they're now a discontinued product,that's really hard to find any easy answers on. If it were Link or Haltech, someone would be able to just send you a ECU file though.
×
×
  • Create New...