Jump to content
SAU Community

Duncan's Race Car - The Most Overdue Build Thread On Sau


Recommended Posts

  • 1 month later...

RIght-o, time for another burst of updates now my unplanned week off contract is over.....

A few years back when I had a rush of castor-rod-break-itis, it really brought home how unprotected the main wiring loom in the driver's side wheel well was.  So I took the guard off and have mounted proper cable tie saddles nice and high so I can easily remove/reattach everything there. Once again the rivnut tool was awesome

wheel-well.jpg

Not so the "stainless" fasteners that we put in a few years ago, they were all rusted in place and one required an easy out to remove (the hardest one to get to of course)....cars have a way of making simple jobs hard...

easy-out.jpg

 

Also did some mounting brackets so the oil cooler is now properly held in all 4 corners (the workshop that did it originally only had it supported at the top)

oil-cooler-mountd.jpg

And I've built a bracket to an LED light bar for night events while everything was apart. 2 uprights into the reo (cut down gudgeon pins because I have so many around) and a second support back to the bonnet latch to make sure it all stays straight (and allows a little up/down adjustment). It will have to run without the grill in place with the light on but airflow is still good which is more importantrace-car-leds.jpg

Oh, and I've fitted the new n1/base model headlights with LEDs

  • Like 1

Next up was mounting the ECU etc in the passenger footwell (still in mdf because the carbon fibre fabricator hasn't been around recently),

ecu-mount.jpg

and the power distribution module under the centre of the dash

pdm-mount.jpg

Other than that, the engine bay loom is in place and tidied up, including some new saddle mounts for the starter motor/alternator loom. Also you can see the new kill switch unit in the bottom right (black box with red writing), it is a solid state relay that disconnects the earth from the battery, and sends a kill signal to the PDM or ECU when the internal or external kill button is pushed.  Should be more reliable than the usual big switch + pull cable that I used to havelooms-tidied.jpg

I've also added a new grommet in the firewall to deal with some of the new wiring without having to run it through the wheel well. That was a real pain because the firewall is double skinned there with body sealer in between new-grommet.jpg I've also installed the boost logger required for production cars....yes $700 for a unit that logs boost and can't be used for anything else. awesome. boost-logger.jpg

Next steps now that all the major components are in place is to mount a couple more things (dash, intercom, video cam, rallysafe, terratrip etc) and then run all the wiring for all of those + the new sensors for the haltech.  

But at least it's finally progressing, and I should get more time over xmas to make more progress.

In the meantime we also solved one of hillclimbing's major issues......how to get a decent coffee in the middle of nowhere.

Thanks to nissan's designers for their usual over-engineering to make that possible....there is a 140a DC/DC converter that is powered by the main battery. As well as coffee the system can provide about 8A@240v for a bit over 24 hours on a fully charged battery for things like keeping the house running in a blackout.

  • Like 1
On ‎12‎/‎12‎/‎2016 at 7:05 PM, Duncan said:

In the meantime we also solved one of hillclimbing's major issues......how to get a decent coffee in the middle of nowhere.

Thanks to nissan's designers for their usual over-engineering to make that possible....there is a 140a DC/DC converter that is powered by the main battery. As well as coffee the system can provide about 8A@240v for a bit over 24 hours on a fully charged battery for things like keeping the house running in a blackout.

Oh that is bloody awesome. I now love the Leaf forever.

  • 2 weeks later...

sorry I intended to take a pic of some spares once I got back home....turns out I didn't have any anyway.

so all the haltech stuff is set up to be mounted using server "cage nuts"...I've run 2 in each channel in the rear so there are 4 fasteners for each box.  I've then used 4x m6 rubber mounts for each unit. The smartwire came with mounting tabs (much easier) so I've just used the rubber insulators there.

These are the mounts I used: http://www.ebay.com.au/itm/5PCS-M6-Rubber-Double-Ends-Screw-Anti-Vibration-Mount-Silentblock-For-Gasoline-/201279211695?hash=item2edd2d08af:g:aSoAAOSwIgNXlWer 

I've been in the strange position to have 2 weeks off work, so lots of progress on the car (not that it looks like it!)

I've finished mounting everything internally and adding the wiring for each: Terratrip, Rallysafe on the Nav's side, Camera in the middle rear where either driver or nav can see and reach it. USB to charge the camera (sooooooo annoying to find out at the end of the event that your awesome one time only move didn't get captured for history)

camera-usb.jpg (and you can see why it's time to repaint the interior too....)

snazzy new intercom has been mounted up on the roof where the cabin light once was with rivnuts, and wired up. Only problem is that it is a euro unit and has driver on the nav's side and vice versa. can't really mount it upside down to fix that either because then up volume would be down volume....will see how it goes. It's a single, digital unit with phone bluetooth, camera output and radio which means way less complexity than my old system (and I can get rid of the stilo adapters too as it's native) new-intercom.jpg Pretty much all the auxiliary wiring has been run to the smartwire now, only the new LED, the wb02 sensor and the heated windscreen is missing I think. Still need to wire the car's old fuse box outputs to it though. And still have all the sensors to wire back to the haltech

  • Like 2

Another couple of days on the car, and the progress is not obvious....but it's there

the factory looms are all tidied up and back in the car (temporarily), and all the wires have been run to repace the fuse box/relays etc with the smartwire. 

wiring-progress.jpg

next up is the switch panel and it's wiring, and the haltech's extra senders and their wiring. Also need to get the clutch and brake lines and masters back in, and throw the motor/front subframe back in. Oh and then test every damn thing.

slow progress with the hot weather and fidly jobs today, but both master cylinders are back in (clutch new, brake only used on a sunday), brakes lines cleaned and back in including the modified front line with brake pressure sender

engine-ready.jpg

Also finished the looms and plugs for the new Haltech senders (oil pressure, oil temp, brake pressure, fuel pressure, e85 and wb02).

Hopefully engine and front subframe back in tomorrow

  • Like 1

Jeez, can we at least put gearbox oil in her before you make it harder to do.

A full bolt check before I loose knuckle skin should also be in order.

 

Happy new years all you dickheads.

14 hours ago, Duncan said:

got to here, but Neil wouldn't let me press the down button.

nearly-there.jpg

something about blah blah check everything blah something blah

Sign him up for a day of bolt checking and oil filling... Right before so press the down button :P

OK, engine is back in, everything was very straightforward there. Down about 70% of the motor's height with the hoist, then subframe/engine up on the lifting platform. Actually I can't remember any issue at all with this, it was good

engine-back-in.jpg

Lots of bolts and stuff to do after that of course, the upper control arms have always been a bastard in this car (something about the alignment/chassis) and I managed to strip a bolt in the upper arm while doing it up to Nissan torque spec which is a prick as it's an unusual thread and I don't have another. Also the steering splines are not quite right, and I have to re-wrap the starter motor loom because it's not in the right place.

Also, Neil put together the switch/light panel, just needs the carbon fibre sticker and no-one will ever know it's MDF. Still needs to be wired of course.

switch-panel.jpg

  • Like 3

Despite the good progress on switch panel and engine in, yesterday was one of those frustrating days where lots of little things went wrong. I stripped a bolt in the upper control arm while torquing it up (probably had it threaded all along because my UCAs are a PITA for some reason, presumably something has been bent over the years). Also the steering splines were short and the starter motor wiring was as well.

Today started with more of the same. Went to put the tailshaft in...

tailshaft-backwards.jpg

The problem is really not obvious to look at, but when I had the tailshaft reco-ed they replaced the centre bearing, and put the bracket back on to hold it in place. In fact they took the initiative and welded the upper and lower halves of the bracket together. With the bracket backwards. Took me a while to work out, particularly since it all looked one piece since they painted after welding it on.

Anyway some angle grinder loving to sort that, and the tailshaft is in

tailshaft-in.jpg

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...