Jump to content
SAU Community

Recommended Posts

Hi Guys, I'm trying to remove the standard dump pipes to install new ones.  I'm stuck at removing the hard water lines and the manifold heat shield. I've attached photos and highlighted what I'm talking about. There are some bolts that are just impossible to get to or maybe it's just because I'm limited to tools.  Any tips would be appreciated - thanks. 

20180201_171707.thumb.jpg.8fe5f14755cdcd0abfce3db19911e14b.jpg

20180201_171657.thumb.jpg.606ad9e8e2ffc9e52ac2665dfc416ebc.jpg 

You need bent/offset open ended spanners to access the lower ends of these.  Ideally they would be tube/flare spanners rather than open ended, because they are less likely to do damage.  Flare spanners are like a ring spanner with the end cut out.  The cut out is wide enough to pass over the tube and the remaining part of the ring wraps around the hex on the tube nut to still touch all 6 sides, instead of just 2 sides like an open spanner.

The same tools will of course be good for the top tube nuts.

SPO3909402-zoom.jpg

(or what he ^ said) SPO1061526-zoom.jpg

Edited by GTSBoy

Back. Got the water return pipes off, but then I realised that was just the beginning of my problems. Rear turbo manifold has a bolt at the back that is to tight to get to.  Taking a lot longer to install than I thought.  How's everyone's experience with installing dump pipes?

20180207_201322.thumb.jpg.e046ba2d5557ea0f0b4c337fa2b8425c.jpg

Spoiler

 

 

Once all the oil and water lines are off you need to get crafty with a ring spanner to undo the manifolds, then pull turbo and manifold out together. 

I can't remember exactly but i think you need to loosen off the flange bolts on the rear turbo so you can weasel the manifold off the studs on the head.

If you find it hard going getting them off you should at least get them rebuilt before you put them back in. 

I can pull twins off and put them back on in a day but I’d never pull turbos just to replace dumps 

as said you need to unbolt the turbo from the manifold, push the turbo down then unbolt the manifold from the head, pull the manifold out then the turbo 

So after a long morning of hard labor turns out that the exhaust doesn't even fit the car... :sad:

So annoyed, was looking forward to it so much.

Below is the connection between the front turbo dump pipe and the front pipe.

5a7e9cfb4c5ca_exhaustjoint.thumb.jpg.ebed5f33ad0be1b5a3dfb7f51a299873.jpg

Next picture is the position of the front turbo if the dump pipe and front pipe flanges were to be connected.  It's hard to tell from the picture, but the turbo is sitting a lot lower than the standard position and you can see it's angled.

5a7e9d89ed99e_frontturbopositionwithdumppipe.thumb.jpg.0059a0d8fd486e5bb15537001796a53c.jpg

At this stage, I'll probably leave the car in pieces and try to figure something out. 

Sorry to hear about the big head f**k dude! But as said above. Ditch the snails mate. Put 1 nice 1 on there and completely change how the car drives from Idle to redline ?

Leave it in pieces till you can afford a manifold and the right size snail to suit your application. 

Again as some of the boys have stated and as you've experienced for yourself its A NIGHTMARE so when going to all that effort go for a power/ increased driveability upgrade while you're losing patience, the skin off your knuckles and hours of your life on those nasty ass twins! Swap to 1! Never look back and never deal with your current situation AGAIN! ?

16 hours ago, Count Grantleyish said:

Looks genuine China to me.

Unfortunately, it's genuine Australia.

@Mick_o - Thanks. Oh tell me about it, getting those turbos off was so frustrating. Like @r32-25t said:

On 09/02/2018 at 10:26 AM, r32-25t said:

I’d never pull turbos just to replace dumps 

I wouldn't do that again for just dumps.

After a brief research session on converting to a single, the bank account wouldn't allow for it. Although I'm actually very interested in a single setup now after reading all the benefits you get compared to twins.

My thinking is to leave the car in pieces and source another set of dumps and fronts. But then that money could also contribute to a single setup :6_smile:

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Hi from Canada, Both of my calipers are starting to fail. My car is a 2005 M35 Stagea ARX and I can't seem to find any parts or any cross reference caliper that would fit my car. Is there a company or a similar caliper that would fit and I could replace the OEM one. Or if anyone knows where I can find a new OEM. Any help is very appreciated. Let me know!
    • Maf is a question mark but TPS  I have set at 0.47, the fact that I’m getting proper voltage range out of it with the key on leads me to believe it’s functioning properly. I’m getting proper voltages on basically everything. I still need to look up voltage ranges for z32 maf and test that 
    • Honestly no not at all, but it’s a very basic tune, it’s stock injectors q45 tps and z32 maf. Other than that it’s a completely stock base map. The file is from nistune and from my understanding if it was tune related I would be able to unplug maf and tps and it would still start even if it was a really shitty start. I have tried starting it with coolant temp, maf, and tps unplugged none of those 3 togethor or individually changes anything 
    • 🏆 Skyline Supremacy Meets Mount Panorama Magic 🏆 Join SAU NSW as we take the long way to Bathurst, the home of GTR greatness. Saturday 30th August 2025 7:00AM Meeting Hanna Park North Richmond 7:30AM Departure Cruise Via Bells of Line Road 9:00AM Arrival to Stop 1: Golden Poplars Meadow Flat 9:45AM Arrival to Final Destination: Mount Panorama Motor Racing Circuit Meet Location: Hanna Park North Richmond Stop 1: Golden Poplars Meadow Flat Final Destination: Mount Panorama Motor Racing Circuit   *Disclaimer* There will be a lead and follow car so no one should get lost. If you would like to attend or bring others along please put your name down and a +1 as numbers will be needed prior! This is NOT a race and we will all be adhering to all road rules. If this is what you want please come to one of our many track days. This is an official SAU:NSW event and will be run under a CAMS permit. One of the things that really sets our club apart is our commitment to being true enthusiasts. When on normal roads we strive to maintain good relations with the authorities as well as the public in general. When attending one of Skylines Australia NSW events please try to: • Be aware of surrounding environment and act accordingly. • Drive courteously on the state’s roads as a true enthusiast should. • Understand how important it is to maintain the good name of SAU NSW and thus, treat others accordingly. • Any misbehavior will not be tolerated and you will be asked to leave.
    • What does it look like with highway driving? And yes, I had a similar thought as Duncan. It looks quite similar in my Stagea and I have made myself accept it as normal. Might have to look into it some day   Highway gets as low as 10l/100km on my end so I'm not as worried about it being a mechanical issue. More likely just the tune on the haltech.
×
×
  • Create New...