Jump to content
SAU Community

Recommended Posts

Here are some pics of my final FMIC installation. I got the car back from Springy Motors earlier this week and am absolutely stoked with the outcome (see dyno thread http://www.skylinesaustralia.com/forums/in...t&p=4719149 )

I removed the front bar, as I wanted to replace the black mesh inserts to 'hide' the cooler a bit. You can see what the 'Cooling Pro' Stealth FMIC looks like behind the bar here. For $150 I had George at Springy Motors fabricate some brackets to allow the bottom cooler mounts to attach to the frame (the brackets provided in the kit don't attach to anything)

I hand-sanded the angle-grinder trimming behind the bar, and did a dry fit with the mesh held in with masking tape. I had to trim the cooler piping clamp bolts with a grinder to make some room, and when I was happy with the dry-fit, used some 'Sikaflex' glue purchased at Autobarn to fix the mesh in place. I put a few bricks on it overnight to make a good bond.

I then trimmed away excess glue, re-attached the front bar, and did up all the bolts holding all the undercarriage plastics in place. All in all pretty happy with how the whole thing turned out. It looks pretty tidy, and turned out to be quite 'stealthy' after all. My advice for anyone considering a Cooling Pro Stealth on a S2 would be to just budget around $150 to have it professionally fitted - you'll still be a whole lot in front of buying a Greddy kit!

post-52103-1247992138_thumb.jpg post-52103-1247992383_thumb.jpg post-52103-1247992706_thumb.jpg

  • Replies 254
  • Created
  • Last Reply

Top Posters In This Topic

Top Posters In This Topic

Posted Images

Looks great Tommy. How much did you have to trim off the front bar to get it all to fit??

Hey Sabbai,

I would estimate I trimmed about 60-70mm from the inner vents. Basically, (on a 'Dayz' bar anyway) you need to make the inner two vents flush with the outer vents. I'm not sure why the inner vents extend further into the engine bay than the outers in the first place, but they've gotta go. You could trim a bit more off to allow a bit more room, but I didn't want to make those vertical 'struts' either side of the numberplate any thinner than required.

PS

Very nice install Tangles! That looks seriously tough.

Hey Sabbai,

I would estimate I trimmed about 60-70mm from the inner vents. Basically, (on a 'Dayz' bar anyway) you need to make the inner two vents flush with the outer vents. I'm not sure why the inner vents extend further into the engine bay than the outers in the first place, but they've gotta go. You could trim a bit more off to allow a bit more room, but I didn't want to make those vertical 'struts' either side of the numberplate any thinner than required.

PS

Very nice install Tangles! That looks seriously tough.

Thanks Tommy. My Dayz Edition arrives late August and I'm wanting to get a cooler into it, but I didn't want to hack the front bar up. I like the way you've fitted it, as it looks to be done very well.

Looks good Tangles.

This is how i did it. I cut 1cm out of the lower part of the front bar, and got no problem at all with the clearance. :devil:

662460_ygzpf6.jpg

662463_4qhl67.jpg

664309_w7jyjc.jpg

664327_qtu2jz.jpg

Nice install guys ..... just thought I would say to all stagea owners thinking of putting on a big front mount I/C

Take note !!! make sure your radiator is in good condition!!! get it cleaned or fixed!! as stagea's and r33's only have a standard 1 core radiator!!(many other sports cars have three or four core radiators). And if radiator is half full of junk(As japanease dont like putting coolant in cars) it is alredy putting stress on motor/cooling system then if you reduce air flow with a front mount then overheating/extra/engine stress could result blown head etc or worse big $$$ So for the cost of around a $100 or so to get your radiator rodded/ cleaned out it's cheap and could possibly save you heaps. Just trying to save stag owners $$$ Trust me fixing head gasket on stag is a F***Bitch of a job. Stag on!! ;)

Total cost below 5000sek (approx 750 AUD)

Hey guys,

just thought I'd add my (Very recent) experiences on the front mount issue. I ordered a Just Jap "C34 Stealth" kit on Monday, received it very happily on Wednesday. To start of with, the front mount is now fitted and looks fantastic. The car boosts stronger, faster and higher, or so it feels :blush:. Fit of pipes up to stock set-up was absoloutely perfect, and the core looks a treat. The one gripe I have with the kit was the fittings (Silicon was fine. Hose clamps were great though!). To be honest, the brackets and fixings supplied with kit fit absoloutely nowhere. For example: It was necessary to add another 40mm to the supplied spacer lengths in order for the intercooler to sit off of the fan unit. This in turn meant I had to replace the supplied mounting stud with a longer unit to suit the new spacer lengths. When pairing the supplied nuts with bolts of same diameter, some of the nuts would not thread onto the bolts, any of them. The supplied brackets seemed to attach to nothing whatsoever, in any configuration (Nth to Sth orientation vs. East to West orientation.) which meant I need to purchase new angles and fabricate them to suit the application. To tell you the truth, the problem solving process and fabrication was an entertaining surprise, but not an anticipated one :P

In short, if you purchase the same JJR C34 Stealth Intercooler Kit, expect to:

-Buy new fixings, spacers and brackets: ~$50

-Extra fabrication time: ~1hr

N.B.: This was fitted to a 1998 Series 1 Stagea, "Dayz Edition". No trimming of the Front Bar was required :down:

Big thanks to Chris for the 8mm driver and his time tightening clamps and fitting the bar!

harts.

  • 1 month later...

Nice work Tangles! That cleaned up pretty nicely after the gaping hole I saw in the bottom of your front bar at a cruise once, and the intake pipes held in with cableties! That's a very nice looking Stag.

PS Where did you get that lower-lower-lip-spoiler?? That's awesome

Edited by DaveB
  • 5 weeks later...

Here's mine after throwing on the Blits front bar + sideskirts, and a HDI GT Spec R32/33/34 FMIC.

As will most coolers I had to do the following:

Cut a hole in the battery tray,

Trim the fan blades,

Cut out 2cm of the intrusion bar

Trim a fair bit of the front bar.

Create slightly larger holes where the factory piping went through (under the air filter)

I didn't move the transmission cooler, but if I relocated it, the cooler would most definitely sit better.

post-9646-1254113248_thumb.jpg

post-9646-1254113278_thumb.jpg

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...