Jump to content
SAU Community

Recommended Posts

Here is a little story about my ownership of my R33, and the future of it also. To skip the history and get to the main part of my story/build, Scroll down to "October 12th 2010 - SAU:SA Track Day #2"

I bought my Series 2 1997 R33 Skyline back in October 2008 as a 22nd Birthday Present to myself - 1 week early present. The car was reasonably stock, it had

Rims

Cat Back Exhaust

Whiteline Sway Bars

Bilestein Shocks

Pod Filter

GTR Wing

I had a compression test a few months later and it turned up to be around 149psi over the 6 cylinders, had a Power Run on a Dyno aswell

Dyno 1.jpg

Dyno 1.1.jpg

I soon noticed that the steering was shaking a fair bit and the tyres were a bit low on tread. So I went and had new tyres put on, and was told that the Rims were wonky, and no matter what they could do, the rims would not balance correctly. So I went and had them fixed.

Car on Stands while Rims are repaired

FrontWheel.JPG

JackedRFSedit.jpg

JackedRearedit.jpg

Rims Repaired

DSCF0071.JPG

As you can see the rear bar has a bit of paint damage, aswell as the Drivers sideskirt and a bit of the front bar.

Somewhere along the line I had them repainted, an FMIC Installed, windows tinted, replaced the broken Boot Lock with one I bought off of a SAU User - Barrel swap guide here, and the stock seats replace with R33 GTR Seats.

ResprayDrivers.JPG

ResprayFrontEdit.jpg

ResprayRearEdit.jpg

During 2009, I began acquiring parts to modify the car, the parts I acquired were

Garret 3076 0.82 - Bought as a kit off of a SAU User, came with lines and dump pipe.

Nismo 740CC Injectors - Nytsky's Old ones

Bosch 040 - Bought from SAU Group Buy

Haltech E11v2 with 3 Bar Map and Boost Controller - SAU Group Buy

During October 2009 I had the mods installed and tuned at Horsepower In A Box

At the same time I had a catch can and a hard pipe from Pod to Turbo made up.

When I picked the car up from the Tuner, it was on the Anniversary of when I bought the car.

2 days after I picked the car up, I had booked myself into a country car show at Loxton, was plenty of time to try out this new power.

Beached As!? :P

DSCF0238.jpg

During the next year I fried the OEM clutch which was then replaced with an Extreme Heavy Duty. Went to a SAU:SA Track Day and blew an Exhaust Gasket, Numerous Car Shows...and then the worst happened in October 2010.

October 12th 2010 - SAU:SA Track Day #2

I did one of the most incredibly stupid things possible that day - Before I go any further, Yes I know it was my fault. I had 2 drivers for the whole day, 1 Driver would go out in 1 group for a 20min session, come in and we swap drivers for the 2nd group for another 20min session. About half way through the day the car was making a weird squealing noise, I paid no attention to it, think it was just a seal. I then let another mate that was there take it out for a spin to feel the power of a 3076 and how the car handles with whiteline sway bars. During 1 of his laps, down the back straight of Malalla, the car lost all power and began blowing smoke, he pulled into the pits.

The oil dipstick was being blown out, a little bit of oil in the catch can, and LOTS of white smoke blown out of the exhaust..even at idle. Luckily enough there was a mate their with his car trailer, and another mate that lives nearby. So the car was loaded up onto the trailer, and taken to my mates nearby.

A few weeks pass, and I go back out to my car and do a compression test. All the cylinders were down on compression, 5 cylinders were around the 120-130psi mark...but 1 cylinder in particular was down in compression, by a lot. Cylinder 4 was only making 5psi of compression, so I am guessing the rings are gone, or maybe a nice hole in the piston. I haven't got round to ripping this engine out yet, as I have no room to do it...my solution is to build up a block, and swap them over.

Onto the Build.

Over the past course of 2010, I had been acquiring parts for a project engine I wanted to build. The idea came from an article about a SAU:WA member in HPI #81, namely about the RB27 that is/was in his car. I thought it was a really good idea, so started sourcing parts to build this. I bought a RB25 block and R34GTR Crank from an SAU User, and managed to find a RB25 Head from a friend of a friend.

DSCF0421.JPG

DSCF0420.JPG

DSCF0406.JPG

DSCF0423.JPG

DSCF0424.JPG

*NOTE* Yes, I do know a RB25/30 will make more torque/power...I don't care. I am doing this build to be different and to learn, as I shall be building this myself with the help of my Tuner.

Build Plan

After speaking to my tuner, he has suggested I build the bottom end first, and then sort out the head. Parts list for my build are;

Bottom End

- ARP Head & Main Studs - USA

- CP 86.5mm Pistons with I-Beam Rods

- ACL Bearings

- New Welsh Plugs

- OEM Seals/Gaskets

- ACL Headgasket

- Nitto Oil Pump

- OEM Water Pump

- Baffled Sump

- 1.3mm Oil Restrictor

Head

- Moderate Port

- Performance Springs

- Tomei 256 8.5 Inlet & Exhaust

- ISC Exhaust Cam

- Head to Sump Drain

During January 2011 I went to Japan and managed to buy some parts - Videos from Japan Trip

HKS Type S Oil cooler Kit

Air Diversion Plate

A new car alarm

March 4th

Bought some ARP Head Studs and Main Studs from the USA, less then $400 delivered. Shall hopefully arrive next week sometime.

Removed most of the welsh plugs from the block, I left the one behind the Thermostat, and I can seem to get the rear 1 out - shall try later.

Shall hopefully buy the Pistons and Rods from the US next week or the week after.

Link to comment
https://www.sau.com.au/forums/topic/356109-aberaxs-r33-build/
Share on other sites

  • Replies 104
  • Created
  • Last Reply

Top Posters In This Topic

So far so good bud!! Aim to have it built before Skyline nationals??

Would love to drive it over there...so got 7 months to get it done - would also be an Anniversary present...and another Birthday present to myself :P

Nice build, doing a similar rb25 26 crank rebuild also.

Good to hear, I haven't seen many of these types of builds, especially documented ones to use as a guide.

Update

Apparently my ARP Main Studs were posted today, still waiting confirmation on Head Studs.

  • 2 weeks later...

watching abe LOL

Oh No....now you can see my project crash and burn :P

Apparently my Main Studs are in Australia and out of Customs, should be here later this week. My Head Studs are still in America, awaiting to be shipped.

Spoke to Rhemac today about having machine work done.

They plan to do;

Hot Tank Block and Crank

Crack Test

Grub Screw Crank

- Fit ARP Main Studs

Line hone Main Tunnel

- Fit Bearings

- Run Mic over Crank

Bore and Torque Plate Block

- Slide Crank in

Dummy up a piston/rod

Deck block - Check Deck Height

Balance Rotating assembly

Just need to sort out bearings, Rods and Pistons. I may get them to start work on the block, that way they can tell me how the block will turn out and what size pistons I will need.

Edit - Just picked up my ARP Main Stud kit from the Post Office :)

Wednesday 16-03-11

Organized to have my Block and Crank to be picked up tomorrow from a Mates house by Rhemac so they can start doing their machine work. Got a message from my tuner to go and see him about Pistons, Rods...and Tomei cams.

He has a set of REVS I Beam rods and is getting a set of CP pistons for me, for the same price I could pick up a Eagle Rod and CP combo for from the States. He also has a set of unused Tomei 256 8.5mm poncams for an Rb25 I can have for a good price.

I believe my build is progressing a better pace then I had hoped for :)

I need to ring Rhemac tomorrow and change a few things on the job card, so I can hopefully save a few $$$.

My ARP Head Studs should be here in the next few days, hoping tomorrow.

  • 3 weeks later...

Got a phone call yesterday to say my Pistons had arrived, so I went and picked them up today, so here is some pics.

Box of 6 R.E.V I-Beam Conrod's with ARP Bolts

DSCF0221.JPG

DSCF0222.JPG

DSCF0224.JPG

My box of CP

DSCF0227.JPG

DSCF0228.JPG

DSCF0230.JPG

As far as I know about the block at the moment it has been Line Honed, as the Machinist has been held up with other jobs, and they have been waiting for me to give them the rods and pistons as they can do everything else. They should have the rods and pistons in the next few days, and work can continue on its way.

Got word from Rhemac today about the progress on my block and parts.

Machining is almost finished. The R.E.V Rods only had standard ARP bolts installed, but had ARP2000 bolts loose in the box. So they installed the ARP2000 bolts and checked the bigend's, due to the extra clamp loading there was some variation and distortion, so they had to be honed again. This may have been avoided if I had gone with Eagle rods, as they come manufactured with ARP2000 bolts.

Piston oil squirter notches elongated, as the stock ones came rather close to the squirters.

Block was faced at the minimum of .004" to clean up the deck. This now means my pistons will protrude out of the block by .019"-.020" with a 1.2mm (0.51") head gasket, so a thicker head gasket (1.5mm) is now on the cards.

They are also going to install new oil gallery plugs also.

Should hopefully be able to get the block back sometime in the next 1-2 weeks :w00t:

  • 3 weeks later...

I called into Rhemac yesterday (Monday 2nd May) and spoke to the guys there about the progress of my machining.

It is all pretty much done, just needs a slight clean, and the grub screws installed into the crank. Also got to see the block and parts, it looks good :)

They also showed me around their machine shop a bit, got a nice set up there.

Once I have paid for the work, which turned out a bit cheaper then I expected, they will deliver to my mates work, where I can pick it up, and begin to give it a final wash and begin assembly :D

Hopefully more updates towards the end of next week.

11th May 2011

Rhemac delivered my block, and other parts back yesterday afternoon.

So today I had a day off and decided to set my gear up at Horsepower In A Box and begin working on the block.

Today consisted of cleaning the bores, applying oil to the bores and test fitting the rings. The 2nd rings all had a gap between 0.022 and 0.024", so they were fine. The 1st rings were about 0.012", so these will surely need a file fit which may be done this weekend.

So here is a few pics of the shiny goodness :D

The block after machining, you can see the 2nd rings in the bores, the girdle in the background with the crank next to it.

DSCF0502.JPG

Hmmmm, Shiny

DSCF0503.JPG

DSCF0504.JPG

  • 2 months later...

So, its been just over 2 months since my last update...why!? you may ask, Well nothing has been happening :P

I let my tuner/engine builder use my engine stand to build 2 RB26's for customer while I saved more money, but things finally got moving yesterday 12-07-2011.

Yesterday we gapped the piston rings, which took 30-1hr to do...but took longer as of interruptions, and the occasional side track of conversation.

Today, 13th, we washed the block, squeaky clean, the bores are brilliant. Test fitted the front and rear bearings with the crank, with a coat of oil, and that was turning perfectly with no travel.

Tomorrow, 14th, we should be cleaning the crank, installing the grub screws and beginning to bolt things together...YAY!!! Progress, shall post photos tomorrow afternoon if I have time :)

good to see you trying something differnt and whacking in the rb26 internals.

I went down this path mid last year but with a R34 RB25 neo motor and it turned out i needed custom pistons to clear the head (due to smaller CC). i didnt have time for a 16wk wait from the US to get these made so i ended up ditching the rb26 gear and went all rb25.

Will be following this build thread and cant wait for completion..

keep up with the good work! :)

When you tested the crank in the block with the front and back bearings were you checking crank runout on the centre main?

correct :thumbsup:

which leads me now to my next item.

Yesterday when we checked for runout, it was about 0.01-0.015", being concerned about this we rang a few places and they said it would be fine. Double checked it again to today, and realized it was out by 0.015-0.02" instead :down:

So I have ordered new bearings, should be here tomorrow - Friday, and next week we'll assemble it, and take it to a crank machinist to fit the run out...so another $500 to spend on new bearings and machine work >_< and stuck with a set of bearings I cant use, anyone know anything cool I can make out of bearings.

The head and sump were sent off to Lewis Engines today for them to extend and baffle the sump, recondition the head with new seals, springs, and a mild port job and install my sexy Tomei cams.

So updates and pics next week now...hopefully :unsure:

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Did this end up working? Did you take some pictures?
    • And finally, the front lower mount. It was doubly weird. Firstly, the lower mount is held in with a bracket that has 3 bolts (it also acts as the steering lock stop), and then a nut on the shock lower mount itself. So, remove the 3x 14mm head bolts , then the 17mm nut that holds the shock in. From there, you can't actually remove the shock from the lower mount bolt (took me a while to work that out....) Sadly I don't have a pic of the other side, but the swaybar mounts to the same bolt that holds the shock in. You need to push that swaybar mount/bolt back so the shock can be pulled out past the lower control arm.  In this pic you can see the bolt partly pushed back, but it had to go further than that to release the shock. Once the shock is out, putting the new one in is "reverse of disassembly". Put the top of the shock through at least one hole and put a nut on loosely to hold it in place. Put the lower end in place and push the swaybar mount / shock bolt back in place, then loosely attach the other 2 top nuts. Bolt the bracket back in place with the 14mm head bolts and finally put the nut onto the lower bolt. Done....you have new suspension on your v37!
    • And now to the front.  No pics of the 3 nuts holding the front struts on, they are easy to spot. Undo 2 and leave the closest one on loosely. Underneath we have to deal with the wiring again, but this time its worse because the plug is behind the guard liner. You'll have to decide how much of the guard liner to remove, I undid the lower liner's top, inside and lower clips, but didn't pull it full off the guard. Same issue undoing the plug as at the rear, you need to firmly push the release clip from below while equally firmly gripping the plug body and pulling it out of  the socket. I used my fancy electrical disconnect pliers to get in there There is also one clip for the wiring, unlike at the rear I could not get behind it so just had to lever it up and out.....not in great condition to re-use in future.
    • Onto the rear lower shock mount. It's worth starting with a decent degrease to remove 10+ years of road grime, and perhaps also spray a penetrating oil on the shock lower nut. Don't forget to include the shock wiring and plug in the clean.... Deal with the wiring first; you need to release 2 clips where the wiring goes into the bracket (use long nose pliers behind the bracket to compress the clip so you can reuse it), and the rubber mount slides out, then release the plug.  I found it very hard to unplug, from underneath you can compress the tab with a screwdriver or similar, and gently but firmly pull the plug out of the socket (regular pliers may help but don't put too much pressure on the plastic. The lower mount is straightforward, 17mm nut and you can pull the shock out. As I wasn't putting a standard shock back in, I gave the car side wiring socket a generous gob of dialectric grease to keep crap out in the future. Putting the new shock in is straightforward, feed it into at least 1 of the bolt holes at the top and reach around to put a nut on it to hold it up. Then put on the other 2 top nuts loosely and put the shock onto the lower mounting bolt (you may need to lift the hub a little if the new shock is shorter). Tighten the lower nut and 3 upper nuts and you are done. In my case the BC Racing shocks came assembled for the fronts, but the rears needed to re-use the factory strut tops. For that you need spring compressors to take the pressure off the top nut (they are compressed enough when the spring can move between the top and bottom spring seats. Then a 17mm ring spanner to undo the nut while using an 8mm open spanner to stop the shaft turning (or, if you are really lucky you might get it off with a rattle gun).
    • You will now be able to lift the parcel shelf trim enough to get to the shock cover bolts; if you need to full remove the parcel shelf trim for some reason you also remove the escutcheons around the rear seat release and you will have to unplug the high stop light wiring from the boot. Next up is removal of the bracket; 6 nuts and a bolt Good news, you've finally got to the strut top! Remove the dust cover and the 3 shock mount nuts (perhaps leave 1 on lightly for now....) Same on the other side, but easier now you've done it all before
×
×
  • Create New...