Jump to content
SAU Community

Recommended Posts

Hi All,

Recently my A/C would only blow stinking hot air which was awfully uncomfortable to drive in but it's been too cold to have it off. It started off that it was sporadic but eventually got worse. After some soul searching I found out that the part is a the Air Mix/Blend actuator which controls how much fresh air vs heater air comes through the vents.

Tools/Requirements:

- Soldering Iron and Solder

- Assorted Phillips head and flat head screw drivers

- Vice to hold everything

- Power supply to test the motor itself

- Permanent marker to mark existing points

- Sand paper

Difficulty:

- Low

Time Required:

- 1 Hour

Optional:

- Brand new OEM mix actuator

- Used OEM working mix actuator

1) Start by testing the actuator using the diagnostics system - If you have error 26, the problem is most certainly the actuator

http://www.sau.com.au/forums/topic/426605-aircon-diagnostics-r33/

2) Locate the actuator under the drivers side dash to the left

IMG_2738 - Copy 2_zpslkzolefq.webp

 

3) Remove cap holding the actuator rod in place, mark the rod for reference and pop the rod out of it's "seat"

 

IMG_2741_zps3nqwu145.webp

IMG_2742_zpsi06eyiru.webp

 

4) Disconnect the wiring connector from the mix actuator

 

5) Remove the three securing screws shown below and take the actuator out of the car

IMG_2738 - Copy_zps5kfedpse.webp

 

*over to the bench*

 

IMG_2750_zpsvhqfg41t.webp

 

6) Mark some reference points on the arm for the actuator - This will make it easier to assemble again later

 

IMG_2756_zpstip1vpue.webp

 

7) Unscrew the actuator off its mounting bracket

 

2_zpse6yy0rkz.webp

 

8) Remove the two screws that seal the housing

 

1_zpsplxcjsqz.webp

 

9) Using a flat head screwdriver gently pry the arm off the actuator

 

IMG_2764_zpswoboetgo.webp

 

10) Separate the two clips that hold the housing together from the side and gently open the actuator case

 

IMG_2767_zpsbc3b2fz6.webp

 

11) Remove all of the little gears from the housing and set them aside somewhere they won't roll away

 

IMG_2770_zpsjpvc2uzh.webp

 

12) Remove the circuit board and motor from the housing to reveal the last large gear with contacts on it

 

IMG_2771_zpsq4uzrl1a.webp

IMG_2774_zpsz9zhmfxd.webp

 

13) Gently bend the contacts upwards to ensure they haven't been worn out and bent over time - Give the contacts a light sand at while you're at it

 

14) Clean the contact surface on the circuit board - I wasn't sure what sort of grease this was so I left a thin coat on the board anyway

IMG_2777_zpsyjomekbq.webp

 

15) Connect a power source to the motor terminals to ensure the motor still functions - If not see the options above or look at a replacement motor (from Jaycar or other electronics stores or eBay)

 

16) Take your soldering iron and melt the solder on the joints of the board - Take the time to add a bit more solder where necessary

ddd_zpstrp6tkql.webp

 

17) If all went well work your way back from step 12 and test the actuator again

 

Edited by PranK
Copied images from photobucket
  • 8 months later...

does someone have a pic of what its suppose to look like when hooked up on the other side, ive just taken mine apart and put it together and it works when not hooked up to the door but when i hooked it up it wouldnt work, i think its just cause it fell off and now is in the wrong position.

 

with out it hooked up going full hot makes the arm move to the front of the car.  going full cold makes it move closer to the cabin/gearbox

But i cant seem to get it to line up with the door when i set it too full hot or full cold when i move the door myself

 

Edited by MatthewT85
  • 3 years later...
  • 4 years later...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I'm looking for some real world experiences/feed back from anyone who has personally ran a EFR7670 with a 1.05 exhaust housing or a .83 I'm leaning towards the .83 because its a street car used mostly for spirited driving in the canyons roads. I"m not looking for big numbers on paper. I want a responsive powerband that will be very linear to 8000 rpm. I dont mind if power remains somewhat flat but dont want power to drop off on top. The turbo I've purchased is a 1.05, although the mounting flange T3 vs T4 and internal vs external waste gates are different on both housings, I not concern about swapping parts or making fabrication mods to get what I want. Based on some of the research I've done with chat gpt, the 1.05 housing seems to be the way to go with slightly more lag and future proofing for more mods but recommends .83 for best response/street car setup. AI doesn't have the same emotions as real people driving a GTR so I think you guys will be able to give me better feed back 😀   
    • Surely somebody has one in VIC. Have you asked at any shops?  Is this the yearly inspection or did you get a canary?
    • This is where I share pain with you, @Duncan. The move to change so many cooling system pieces to plastic is a killer! Plastic end tanks and a few plastic hose flanges on my car's fail after so little time.  Curious about the need for a bigger rad, is that just for long sessions in the summer or because the car generally needs more cooling?
    • So, that is it! It is a pretty expensive process with the ATF costing 50-100 per 5 litres, and a mechanic will probably charge plenty because they don't want to do it. Still, considering how dirty my fluid was at 120,000klm I think it would be worth doing more like every 80,000 to keep the trans happy, they are very expensive to replace. The job is not that hard if you have the specialist tools so you can save a bit of money and do it yourself!
    • OK, onto filling. So I don't really have any pics, but will describe the process as best I can. The USDM workshop manual also covers it from TM-285 onwards. First, make sure the drain plug (17mm) is snug. Not too tight yet because it is coming off again. Note it does have a copper washer that you could replace or anneal (heat up with a blow torch) to seal nicely. Remove the fill plug, which has an inhex (I think it was 6mm but didn't check). Then, screw in the fill fitting, making sure it has a suitable o-ring (mine came without but I think it is meant to be supplied). It is important that you only screw it in hand tight. I didn't get a good pic of it, but the fill plug leads to a tube about 70mm long inside the transmission. This sets the factory level for fluid in the trans (above the join line for the pan!) and will take about 3l to fill. You then need to connect your fluid pump to the fitting via a hose, and pump in whatever amount of fluid you removed (maybe 3 litres, in my case 7 litres). If you put in more than 3l, it will spill out when you remove the fitting, so do quickly and with a drain pan underneath. Once you have pumped in the required amount of clean ATF, you start the engine and run it for 3 minutes to let the fluid circulate. Don't run it longer and if possible check the fluid temp is under 40oC (Ecutek shows Auto Trans Fluid temp now, or you could use an infrared temp gun on the bottom of the pan). The manual stresses the bit about fluid temperature because it expands when hot an might result in an underfil. So from here, the factory manual says to do the "spill and fill" again, and I did. That is, put an oil pan under the drain plug and undo it with a 17mm spanner, then watch your expensive fluid fall back out again, you should get about 3 litres.  Then, put the drain plug back in, pump 3 litres back in through the fill plug with the fitting and pump, disconnect the fill fitting and replace the fill plug, start the car and run for another 3 minutes (making sure the temp is still under 40oC). The manual then asks for a 3rd "spill and fill" just like above. I also did that and so had put 13l in by now.  This time they want you to keep the engine running and run the transmission through R and D (I hope the wheels are still off the ground!) for a while, and allow the trans temp to get to 40oC, then engine off. Finally, back under the car and undo the fill plug to let the overfill drain out; it will stop running when fluid is at the top of the levelling tube. According to the factory, that is job done! Post that, I reconnected the fill fitting and pumped in an extra 0.5l. AMS says 1.5l overfill is safe, but I started with less to see how it goes, I will add another 1.0 litres later if I'm still not happy with the hot shifts.
×
×
  • Create New...