Jump to content
SAU Community

Recommended Posts

Skyline R33 series 1

Hey guys

So i have a series 1 R33 GTST. It had a blown motor in it so brought a series two long motor and used my series 1 turbo and intake. using series 1 wiring lume. i got it all fitted up on the weekend and guess what. no start. she cranks over fast but doesnt fire. so ive checked fuel. fuel is flowing freely and theres a bit of pressure behind it just after the fuel filter going into the rail. checked spark and i have spark at the spark plugs. checked injection pulse with a noide light and i have injection pulse. im kinda stuck at this point and not to sure what to attack next. im going to test fuel pressure tomorrow night just to make sure the pressure is right. i have tested it with 2 cas and no change. its just not making sense. i have fuel, i have spark, i have injection pulse. why wont she fire. any advice would be amazing. thanks guys

Edited by SkylineR33Lad
Link to comment
https://www.sau.com.au/forums/topic/471116-skyline-r33-series-1-no-start/
Share on other sites

Hi,

I just got my skyline so I'm not particularly familiar with it yet but are all the sensors plugged in and proper? Maf, O2 etc?

A friend had his O2 sensor wires on his Rav4 chewed by his dog and had similar symptoms. 

Thanks for the fast reply guys. yer smells like fuel if ive been cranking it for a bit. plugs were wet when i pulled them out on the weekend. got new plugs coming tomorrow. 

ive gone over all my sensors and im 99 percent ive got them all hooked up. 

Edited by SkylineR33Lad

ive even tryed to use some start ya bastard and had no hope. do you have to adjust your cas or does that bolt straight on. cause im thinking its timming but i replaced timming belt when engine was out and it was smack dead perfect 

 

Update.

I found out that you adjust your cas for your timing since I just whacked it on I thought I had better give that a shot. I tried it in all angles as I would have to move it then go crank the key. Didn't make a difference. The weird thing is when I first crank the car. After it's been sitting it sounds like it fires straight away then just dies of and keeps on cranking over

When you first crank it. It sounds like it fires and then just sounds like it's turning over after that. I just compression tested all cylinders and they are all around 140:150. But when I was removing the plugs it came to my attention the spark plugs in cylinder 5 and 6 were dry. So I don't think I'm getting fuel into those cylinders. I have replaced all spark plugs. The car should still fire with 4 cylinders. I've all so checked over the link you posted . Yes I've checked everything on the list apart from timing. Can you check timing with out the car running. I have a timing light just need to make something up that can go into the coil. So I can put a ht lead for the pick up of the timing light

 

 

You really need the car running to check the timing.

I think you have already checked it but the CAS isnt a tooth out or something along those lines?

Is it just the standard ECU?
Be interesting to plug consult into it if so and see if there is an issue. My thinking is possibly AFM or water temp sensor perhaps (ECU thinks its -50 degrees or so)

Fuel pressure regulator hooked up correctly?

Im thinking that there may be a dud sensor. Double check all the connections (pull them out and check the pins) but you may have a sensor that is connected correctly but internally faulty

Wait hold up. Won't the car run with out the water temp sensor. I haven't got any of the cooling system hooked up. Not even the radiator. I'm pretty sure the water temp sensor is on the intake manifold and she's plugged in.

 

I'm pretty sure the cas can go on only one way. It's a standard ecu but the owner before me had a aftermarket ecu piggy backed off that one. Ive got another ecu coming tomorrow to plug it in and she if that makes a different. Also got another mass air flow sensor to try tomorrow. I'll check the fuel reg tomorrow but I don't think I really touched it so it still the same.

 

 

 

 

The car injects fuel differently depending on the water temp. So if your water temp is say 10 degrees, the car will run in a cold start mode and inject more fuel because it is colder

Like I said, this is all just guessing

I would strongly suggest hooking up the cooling system and correctly filling it to avoid any chance of the head or block warping or cracking

The issue you have described, we had a very similar experience with on an RB30. We found that the fuel pump wasn't working correctly and would not provide enough pressure in the system. Maybe double check that the fuel pressure is where is should be.

Ok guys so I've called in sick today to work. So I can try and figure this f**king car out. I pressure tested it from the filter as that was the only fitting that fitted my fuel pressure tester. I got 6 bar straight away. So I plugged in my mates ecu. Of his running 33. Still nothing! So I removed that ecu and put mine back in. I then changed the air flow sensor. Still nothing. I'm pretty sure that I'm not getting fuel to cylinder 5 and 6. I'm going to pull the plugs out on more time to conform that. I'm trying to post a video of it cranking over I can't seem to do it via iPhone. When I pump the throttle jut a little bit whilst cranking it sounds like it's firing. Any advice today would pretty amazing as I have taken the day of work

Okay so I pulled the fuel rail off so I can see if the injectors are blocked and clean them out. But when I got it out the injectors just don't look right to me. One of them have popped an o-ring half out. And one injector looks totally different to the rest.IMG_3442.thumb.jpg.cf4f7f52c85d93bded9d7284ccdd15c2.jpg

 

Still no start!!! Losing my mind here guys. Tried f**king everything. Don't know where to go from here. Please help. I tested all injectors when they were out by giving them a 12 volt feed. That all click when powered up. I'm lost.

 

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Well, I can recommend the partial AV system translation CD I ordered from Car Audio Workshop in NZ. Whilst it didn't address the date issue, it has conveniently translated on-screen menu items into English, and now allows the GPS-received time to be offset in hours rather than minutes, so I can display Eastern Australian time accurately ( and bump it by another hour when daylight savings starts ).
    • Yuh, if it's 45°C outside, my car is driving in it.
    • I'd be curious to hear more. Otherwise, have you driven a modern x-trail? I wonder how it compares. Here in Australia they are/were popular for rentals and fleet vehicles. I have been in some and my impression was they are bad. But, this may have been very different in the 2000s at a good trim level. Twenty years is plenty of time to make the model worse. I do very much agree with the 2 silver cars in the garage approach. But, not driving because it's too hot would not leave a lot of time in the year for many Australians. I don't think you need to worry too much unless the car has actual issues with overheating. 
    • Back again. I returned to Japan in Jul/Aug to spend time with the car on my birthday and remind myself what all the sacrifice and compromise is for. It happened to line up with the monthly morning meet in Okutama, which I have been wanting to go to for a long time. It's a unique event at a unique spot with really rare, interesting, and quirky cars. It's where all the oldheads and OGs gather. The nighttime scene at DKF certainly has its place and should be experienced if you're into cars, but there's too much bad attention and negativity around it now. IMO the better time is Sunday morning at DKF or Okutama; it's more chill and relaxed. I'm glad I was finally able to go, but not sure it's worth the drive from all the way from Nagoya immediately the day before, unless I was already staying in Tokyo for the days right before the meet, because you have to wake up quite early to make it in time. Funnily enough though I didn't drive the car all that much this trip because it was just too damn hot. While there were zero issues and running temps were nominal and the A/C was strong, RBs already run crazy hot as it is. Sure, it took it all like a champ but something about driving these cars in the ridiculous heat/humidity bothers me and makes me feel like I'm asking too much of it. I'm just me being weird and treating the car like a living thing with feelings; I'm mechanically sympathetic to a fault. Instead I was mainly driving something else around - a KX4(silver) 2001 X-Trail GT, that I acquired in May. There's a few different flavors to choose from with Xs, but visually it's the Nissan version of the Honda CR-V. Mechanically it's a whole different story as this, being the top-trim GT, has an SR20VET mated to a four-speed auto and full-time AWD! It was a very affordable buy in exceptional condition inside and out, with very low mileage...only 48k kms. Most likely it was owned by an older person who kept it garaged and well-maintained, so I'm really happy with how it all worked out. It literally needs zero attention at the moment, albeit except for some minor visual touch-ups. I wanted something quirky, interesting, and practical and for sure it handily delivers on all three of those aspects. I was immediately able to utilize the cargo and passenger capacity to its full extent. It's a lot of fun to drive and is quite punchy through 1st and 2nd. It's very unassuming -in the twisty bits it's a lot more composed than one would think at a glance- and it'll be even better once I get better tires on it(yes, it's an SUV but still a little boat-y for my liking). So...now I have two golden-era Nissans in silver. One sports car and one that does everything else; the perfect two-car solution I think👍 The rest of the trip...I was able to turn my stressed brain off and enjoy it, although I didn't quite get to do as much as I thought. I did some interesting things, met some interesting people, and happened into some interesting situations however, that's all for another post though only if people really want to know. Project-wise, I went back to Mine's again to discuss more plans and am hoping to wrap that up real soon; keep watching this space if that interests you. Additionally, while working in the tormenting sweatbox that is the warehouse, I was able to organize most of the myriad of parts that my friend is storing for me along with the cars, and the 34 has a nice little spot carved out for it: And since it can get so stupid hot in there, that made it all the more easy -after I was standing there looking at the car and said 'f**k it'- to finally remove all the damn gauges that have mostly been an eyesore all this time. Huzzah. The heat basically makes the adhesive backing on the gauge mounts more pliable to work with, so it was far less stressful getting this done. I didn't fully clean it up or chase the wiring though; that will happen once I have the car in closer possession. Another major reason to remove all that stuff is to give people less reasons to get in my car and steal s**t while it's being exported/imported when/if the time comes, which leads us to my next point... ...and that is even though it's time in Japan is technically almost up since it's a November car and the X would be coming in March, I'm still not entirely sure where my life and career is headed; I don't really know what the future looks like and where I'm going to end up. I feel there's a great deal of uncertainty with me and as a result of that, it feels like I'm at a crossroads moreso now than any point in my life thus far and there are some choices I need to make. Yes, I've had some years to consider things and prepare myself, however too much has happened in that time to maintain confidence and everything feels so up in the air; tenuous one might say. Simply put, there's just too much nonsense going on right now from multiple vectors. Admittedly, I'm struggling to stay in the game and keep my eyes on the prize. So much so in fact, that very recently I came the closest I ever have before to calling it quits outright; selling everything and moving on and not looking back. The astute among you will pick up on key subtext within this paragraph. In the meantime I've still managed to slowly acquire some final bits for the car, but it feels nice knowing there's not much left to get and I'm almost across that finish line; I have almost everything I'll ever want for my interpretation and expression on what it is I think an R34 should be. 'til later.
    • Thanks for that, hadn’t used my brain enough to think about that. 
×
×
  • Create New...