Jump to content
SAU Community

Recommended Posts

Hi Guys, I'm trying to remove the standard dump pipes to install new ones.  I'm stuck at removing the hard water lines and the manifold heat shield. I've attached photos and highlighted what I'm talking about. There are some bolts that are just impossible to get to or maybe it's just because I'm limited to tools.  Any tips would be appreciated - thanks. 

20180201_171707.thumb.jpg.8fe5f14755cdcd0abfce3db19911e14b.jpg

20180201_171657.thumb.jpg.606ad9e8e2ffc9e52ac2665dfc416ebc.jpg 

You need bent/offset open ended spanners to access the lower ends of these.  Ideally they would be tube/flare spanners rather than open ended, because they are less likely to do damage.  Flare spanners are like a ring spanner with the end cut out.  The cut out is wide enough to pass over the tube and the remaining part of the ring wraps around the hex on the tube nut to still touch all 6 sides, instead of just 2 sides like an open spanner.

The same tools will of course be good for the top tube nuts.

SPO3909402-zoom.jpg

(or what he ^ said) SPO1061526-zoom.jpg

Edited by GTSBoy

Back. Got the water return pipes off, but then I realised that was just the beginning of my problems. Rear turbo manifold has a bolt at the back that is to tight to get to.  Taking a lot longer to install than I thought.  How's everyone's experience with installing dump pipes?

20180207_201322.thumb.jpg.e046ba2d5557ea0f0b4c337fa2b8425c.jpg

Spoiler

 

 

Once all the oil and water lines are off you need to get crafty with a ring spanner to undo the manifolds, then pull turbo and manifold out together. 

I can't remember exactly but i think you need to loosen off the flange bolts on the rear turbo so you can weasel the manifold off the studs on the head.

If you find it hard going getting them off you should at least get them rebuilt before you put them back in. 

I can pull twins off and put them back on in a day but I’d never pull turbos just to replace dumps 

as said you need to unbolt the turbo from the manifold, push the turbo down then unbolt the manifold from the head, pull the manifold out then the turbo 

So after a long morning of hard labor turns out that the exhaust doesn't even fit the car... :sad:

So annoyed, was looking forward to it so much.

Below is the connection between the front turbo dump pipe and the front pipe.

5a7e9cfb4c5ca_exhaustjoint.thumb.jpg.ebed5f33ad0be1b5a3dfb7f51a299873.jpg

Next picture is the position of the front turbo if the dump pipe and front pipe flanges were to be connected.  It's hard to tell from the picture, but the turbo is sitting a lot lower than the standard position and you can see it's angled.

5a7e9d89ed99e_frontturbopositionwithdumppipe.thumb.jpg.0059a0d8fd486e5bb15537001796a53c.jpg

At this stage, I'll probably leave the car in pieces and try to figure something out. 

Sorry to hear about the big head f**k dude! But as said above. Ditch the snails mate. Put 1 nice 1 on there and completely change how the car drives from Idle to redline ?

Leave it in pieces till you can afford a manifold and the right size snail to suit your application. 

Again as some of the boys have stated and as you've experienced for yourself its A NIGHTMARE so when going to all that effort go for a power/ increased driveability upgrade while you're losing patience, the skin off your knuckles and hours of your life on those nasty ass twins! Swap to 1! Never look back and never deal with your current situation AGAIN! ?

16 hours ago, Count Grantleyish said:

Looks genuine China to me.

Unfortunately, it's genuine Australia.

@Mick_o - Thanks. Oh tell me about it, getting those turbos off was so frustrating. Like @r32-25t said:

On 09/02/2018 at 10:26 AM, r32-25t said:

I’d never pull turbos just to replace dumps 

I wouldn't do that again for just dumps.

After a brief research session on converting to a single, the bank account wouldn't allow for it. Although I'm actually very interested in a single setup now after reading all the benefits you get compared to twins.

My thinking is to leave the car in pieces and source another set of dumps and fronts. But then that money could also contribute to a single setup :6_smile:

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Given you're running a 2.8 and my 2.5 is not really like for like, I suspect there could be a bit more timing you could give it. What is the kW yield per degree you're putting through it? Here's my E85 map to give you an idea, where it was I could still get another 3~4kW per degree thrown at it.  
    • It turns out that Setrab make a fan specifically for the oil cooler which is great and I've installed it with minimal swearing. I removed my 2x 12in push fans from the front of my aircon condenser and wired them into this. My main thermo fans kick on when I use the aircon anyway and would effectively already be working as puller fans through the condensor which is infront of the rad. The push fans (understandably) didn't really do much in the config they were previously in so now they're out. Now we're on to the "Oil fan doesn't really do much either!". Yes I'll duct it next if it does nothing in heavy use which it shouldn't. But hey, the object exists and fits great and is cool. Let me have this. The car is still in the "do my fittings leak oil now? do my wheels actually rub?" phase. I did a spirited drive on them and didn't hear or feel anything. Then I got back home and noticed there were grind marks on the inside of the rims, though I couldn't see where they were touching I got out the grinder and attacked the suspects. Note: I do not know how to use a grinder. Then I realised I had dragged my new rims across my concrete driveway before I did this drive. I didn't think I had damage at that time when I briefly looked...... but remembered this occurred after I did all the angle grinding. The grinding on the wheels in some very specific spots. It's not around the whole rim for example, which lines up with dragging it across concrete more than hitting a suspension component for even 1 full rotation. So everything is currently painted and taped up and I need to test it some more to see if it really IS rubbing, but from inside the car it doesn't feel like it is. In other news I attempted to do a before and after comparison of the heads/cam upgrade thing. Dynos lie, everything is in different measurements. Here is the data from the sandown back straight. Car go faster than before. Vroom vroom.
    • Here's my base ignition. +3 correction to redline when shooting water/meth which is always on. Looking at my old ignition table, I should be able to add 1-2 degree's next time I'm on the dyno.  Let me know your thoughts. 
    • Given what I know now - same haha, but this was 12 years ago with second hand 740cc Nismo injectors in my S15 daily, I was too busy hunting elsewhere for the issue to even look at the injectors, running through some cleaner was a happy coincidence haha
    • Not a terrible idea. But if I ever had concerns that my injectors were sufficiently dirty to be causing me a problem, they would be out of the engine and onto the actual injector cleaner/testing bench.
×
×
  • Create New...