Jump to content
SAU Community

Recommended Posts

Hello. Having some 'fun' with this new setup on my 1995 S1.5 R33 GTST:

I have a brand new Exedy (extra extra heavy duty) 500kw single plate ceramic clutch kit, new aftermarket throw out bearing + holder, new Exedy spigot with all parts having only 750-1000km on them.

Today while driving I gave it a fairly hard (5000rpm or so) shift from first to second gear and now I can't disengage the clutch. Limped it home in second so the clutch is engaged, but can't get it to move gears whatsoever. Goes through all gears when engine is off.

It made no noise when the clutch stopped working- nothing went bang or made any odd sounds and drove it home fine in second gear.

I checked the pedal adjustment and it's as high as it'll go (most movement of pushrod on slave) and had someone push the pedal down while watching. The slave pushrod moved about 1.5 inches which is apparently the correct amount of movement.

Decided to try and bleed the clutch to rule that out, and now all of a sudden there is no pressure on the pedal- it just falls to the floor and stays there. Tried bleeding master and didn't do anything. A fair bit of air comes out of the slave when bleeding, but continues and gets no better- with no change in pedal.

What on earth is going on? The slave worked fine before opening the bleed valve, now the pushrod won't move, and still obviously can't disengage the clutch as I have a pedal that flops to the floor. Tried compressing and bleeding master 30 times or so with no change. Anyone got any idea what is causing this? Why did the slave suddenly stop, or was this the issue all along?

Cheers everyone! Sorry for the long one.

Link to comment
https://www.sau.com.au/forums/topic/482858-clutch-issues-need-some-advice/
Share on other sites

Possibly broken clutch fork pivot, or something just wrong with the clutch.

Anyway I think your box is coming out, as you are somehow not pressing on the clutch pressure plate to disengage.

I think you may have massive air pockets in the damper (the loop next to the chassis rail). Do you have a hand vacuum pump? that might help get fluid down.

 

Or like the others mentioned, snapped pivot or snapped fork (can happen with super strong pressure plates).

On 9/29/2021 at 4:51 AM, PLYNX said:

 Have you checked the clutch pedal box is intact ?

They are notorious for breaking the spot welds.

Sometimes it can be hard to see as you've got to flip upside down in the foot well to see it !

Thanks for the advice- hsve read about this issue but mine is good, works as it should.

On 9/29/2021 at 6:08 AM, BK said:

Possibly broken clutch fork pivot, or something just wrong with the clutch.

Anyway I think your box is coming out, as you are somehow not pressing on the clutch pressure plate to disengage.

I sadly think this is the case too- based on how sudden it is. I've decided to buy a new OEM slave cylinder just in case but that all appeared to work. The second I opened the breather however it just never bled properly, so maybe a seal in it has gone suddenly. Unlikely but trying before box is out.

Any clue if I can check clutch pivot with a boreascope camera?

On 29/09/2021 at 11:15 AM, CLEM0 said:

Any clue if I can check clutch pivot with a boreascope camera?

you should be able to, remove the slave, remove the rubber and you should be able to stuff those small cameras in there to have a look.

On 29/09/2021 at 10:45 AM, CLEM0 said:

I sadly think this is the case too- based on how sudden it is. I've decided to buy a new OEM slave cylinder just in case but that all appeared to work. The second I opened the breather however it just never bled properly, so maybe a seal in it has gone suddenly. Unlikely but trying before box is out.

Look, you may have air in the system and your master (not slave) may be passing, but the fact you can see your slave rod moving that much points to something not pressing down on the clutch. This comes back to something like a bent clutch fork or broken fork pivot.

Another thing to check regarding air in the system while you're doing all this,  which has happened to me in the last 2 weeks, is if your booster has had its master cylinder dump clutch fluid into it. My master cylinder seals failed, passed fluid into the booster and got sucked into the engine via the booster vacuum line. It won't be why your not disengaging, but can explain air in the system as slave cylinders very rarely fail.

On 9/29/2021 at 9:43 AM, BK said:

Look, you may have air in the system and your master (not slave) may be passing, but the fact you can see your slave rod moving that much points to something not pressing down on the clutch. This comes back to something like a bent clutch fork or broken fork pivot.

Another thing to check regarding air in the system while you're doing all this,  which has happened to me in the last 2 weeks, is if your booster has had its master cylinder dump clutch fluid into it. My master cylinder seals failed, passed fluid into the booster and got sucked into the engine via the booster vacuum line. It won't be why your not disengaging, but can explain air in the system as slave cylinders very rarely fail.

I believed it may be the slave- it does move but apparently it must move almost the whole way, which it didn't seem to. It was close- but it could be 1-2mm off and that might be all it takes.

If it was the clutch pivot, or even fork for that matter, wouldn't it lose all feeling immediately, as it requires those parts to even move the pedal? Not after opening the slave bleeder? It felt totally normal and made no sounds until I opened the slave cylinder valve.

I suppose this doesn't rule out throw out bearing- I will get a camera in there today and update. Cheers.

On 9/29/2021 at 2:30 PM, BK said:

For your sake I hope it is the slave, but it is very unlikely.

How'd you go with your mangled crank keyway issue ?

I have strong doubt it's the slave too- but for $100 worth a shot. Otherwise tow car then box out. Beginning to hate this car more than I love it haha. 6 weeks on road, 10+ Months off it since ownership. Expensive too...

As for the mangled keyway, bought a used crank, did new ACL race series bearings, oil pump collar, custom single keyway mod, and a ross balancer. Nissan balancers are not made properly and shred the keyways, regardless of bolt torque. It's a design/tolerance fault and I confirmed it by using a micrometer, as well as several OEM balancers- new and used. They never fit properly snug, and rely on bolt tension instead of interference fit! I can't even begin to imagine how many RB series engines are currently driving around with shredded crank snouts as a result- probably a tonne.

Not just oem. I have shredded a keyway with a Ross balancer and Nitto billet crankshaft before - Bolt came loose eventually from crushing the crank washers, and that was at tension to 460nm.

The balancer is not supposed to rely on the key for any sort of load really as that is the bolts job.

20210930_155942.thumb.jpg.3ee4e902177df7d79978cc768d137205.jpg20210930_155935.thumb.jpg.0b1d787ae6e5de85a927b3c5fa327efd.jpg

 

On 30/09/2021 at 5:19 PM, Dose Pipe Sutututu said:

Since you're changing the slave and rebleeding the entire system - might as well piss off that clutch loop line/damper.

That should be a given really.

  • Like 1

You may have split the clutch fork arm at the pivot ball area  happened to mine when i first upgraded to a higher rated pressure plate. Replaced it with an aftermarket fork arm and pivot ball pin.

On 30/09/2021 at 10:43 PM, Dasmbo said:

You may have split the clutch fork arm at the pivot ball area  happened to mine when i first upgraded to a higher rated pressure plate. Replaced it with an aftermarket fork arm and pivot ball pin.

Definitely possible too and will have the same effect as snapping the pivot. Did you actually go aftermarket for the fork ? The more common 350z cd009 cast fork with a chromoly pivot is generally the fix for this. 

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...