Jump to content
SAU Community

Recommended Posts

  • Replies 254
  • Created
  • Last Reply

Top Posters In This Topic

Top Posters In This Topic

Posted Images

Has anyone had any luck fitting a front mount to a S2 Stagea with a Dayz front bar, without cutting the reo bar??

Any help would be appreciated,

Model, Size, etc, would be great.

Thankyou in advance

My reo needed a fair bit of cutting and front bar needed a fair amount too with my GReddy M-Spec.

  • 1 month later...

Just ordered the Just Jap Stealth kit. After reading this thread it seems that it should work pretty nicely.

Our Stagea has the Dolphin front bar so I am thinking that will give us a bit more room to work with as well as less obstructions for airflow.

Fingers crossed it gets here before the Xmas break.

Just ordered the Just Jap Stealth kit. After reading this thread it seems that it should work pretty nicely.

Our Stagea has the Dolphin front bar so I am thinking that will give us a bit more room to work with as well as less obstructions for airflow.

Fingers crossed it gets here before the Xmas break.

Sean, its a pretty easy install, you need to trim a little out of the reo, i had to trim abit out of the dayz front bar but as you say, a dolphin bar should give you plenty of room. the only issues i found were:

- the bottom mounting brackets were no good, i had to make up my own, used the ones they gave me but had to add to them so they would work.

- i mounted the top centre bolt to the bonnet latch support, there is already a couple of holes in the support, i just used one of those holes along with a long bolt and spacer. if you use the spacer supplied in the kit you may have an issue with the bottom of the intercooler hitting the a/c thermo fan, i used a longer spacer and had no issues with the intercooler fouling on the thermo fan or the oil cooler (S2).

- the bottom black plastic engine tray cover bit, the return pipe stops you from putting a couple of the bolts back it to hold this up, and if you mount the intercooler too low you may have to cut a section of it out for the return pipe.

- not really an issue but the horns need to be bent back a tad to clear the intercooler.

- the outside air temp sensor needs to be moved, i just cable tied it up to the thermo fan shroud.

apart from that the pipe work itself was good, easy to line up with the stock pipes. there are some holes in the end of the chasis rail for the return pipe mount to bolt to.

here's a pic of mine without the reo

post-34711-1260775937_thumb.jpg

and here is a pic of how i mounted it up on the bottom. i used the 2 supplied brackets on the one side, just had to join them together and drill a couple of holes, the made up something the same for the other side out of some steel i had here at home. i've since tidied them up a little.

post-34711-1260776120_thumb.jpg

good luck with the install :)

Edited by QWK32
  • 2 weeks later...

Ok well the JJR kit arrived last night , was going to start on it today ( this morning ) but had a few things to take care of at work so I might start at around mid-day. I had a really quick look at things last night and looks like I am going to have to hack the front bar a bit. What are the best tools to cut that kinda plastic with? I have a Dremel with a cut off wheel but thats going to take AAAGES! Other than that I was thinking a jigsaw with a blade suitable for plastic might be faster way of doing things.

I will make sure I post some pics.

I used a freash sharp blade in a stanley knife and it did the trick, just got to be slow and steady with your cut. I also used a small razor blade to get in the tight spots.

Be carefull with a jigsaw, you may lift the paint, I'd suggest masking tape on the are you are cutting to help. Also don't use too small pitch on a jigsaw blade. If it's too small the plasic just melts and sets in the cut after you pass.

ok well got home, ripped off the factory cooler off ( More on that in a min !) , took the front bar off etc etc.

Now- the Just Jap intercooler kit is definately not a direct fit. The oil cooler fouls it and the thermo fan comes pretty close too ( this has been addressed before. Also in our particular instance it fouls on the front bar on the right hand side vent as you are looking at the car. My thoughts were to put the numberplate over the vent so that it is out of the way of the airflow into the cooler and it will also cover any hacking I need to do for the pipes to clear the vent

I need to find a new home for the horns and also the oil cooler. Hey whats the dealio with relocating oil coolers? anything to be looking at , ie any traps for young playerS?

The weird thing is that the factory cooler was oily on the OUTLET of the cooler and clean on the inlet of the cooler??

WTF ? does that make sense to anyone else? where does the oil come from in the space of passing thru the cooler!?

The return pipe on the new cooler hangs a bit lower than the lip on the front bar - so we will have to mind that when we go parking etc.

There is some jiggering around to be done where the factory pipes meet the new cooler pipes - I need a few extra inches and should be good.

post-36321-1261564033_thumb.jpg

post-36321-1261564061_thumb.jpg

post-36321-1261564095_thumb.jpg

Yes, if you do a search you should find a thread with a comparison of various aftermarket options such as Trust, Nismo and ARC. Another possibility is to use the space for a water to air intercooler but i don't think anyone here has done it on a Stagea as yet. The simplest upgrade (see the DIY sticky) is the S2 or GTT smic into the S1.

Ok - Snag #1 !!

I dont know if its some kinda crazy ingenuity on Just Japs behalf , but to cut a long stoy short the factory intercooler pipework for the Stagea seems to be somewhere between 2.5 inch and 2.25 inch ! WTF?

Like no sh1t hey.. I went to replace the factory elbows ( near where the Air box used to sit ) to get a bit more length to mate up the Just Jap pipe work , and got some 2.5 inch 90 Deg Elbows , brought them home and BaawBAAWWW .. the fit was just much too loose, I tried clamping it down with a clamp and was just not 100% happy with it, just seemed to bunch up a bit.

So went back to the guy ( THANK YOU to CHAMP from SilviaWA ) and got some 2.25 inch elbow bends and yeh.. its going to be like fitting a grand piano down a flight of stairs ( TIGHT ) but I would prefer to try and get a good tight fit rather than stress about it leaking while its getting Nistuned.

Now dont get me wrong. I am not bagging Just Jap , not by any means. I am just trying to get the information out there for others that are going down the same path. I think it would have been good if Just Jap priced the cooler kit a bit higher and included all the replacement pipework.

Anyways having driven for god knows how long this afternoon I am not going to work on it anymore , but will post more information about this sometime between xmas and NYE!

Water to air = SIIIIIIIKKK!!!!!! expensive but pure Porn!!

Yes, if you do a search you should find a thread with a comparison of various aftermarket options such as Trust, Nismo and ARC. Another possibility is to use the space for a water to air intercooler but i don't think anyone here has done it on a Stagea as yet. The simplest upgrade (see the DIY sticky) is the S2 or GTT smic into the S1.

There's a Trust SMIC for sale in the skyline part section. The guy reckons he made 300kw with it (which i think is pushing it a bit) but it would be a good upgrade for anyone wanting to make up to 240 or may 270kw at a stretch. I used to have one and it was great. They are a bit fiddly to fit as the brackets don't line up but the hoses do and still a lot easier than fitting a fmic.

Started her up last night , didnt hear any leaks etc so all must be well.

Though I dont know if I am paranoid or what but I could detect a slightly rough idle, but having said that the car has been on stands for a while so I guess its hardly surprising.

you can see the new oil cooler peeking up there :/

post-36321-1262225725_thumb.jpg

post-49463-1262584166_thumb.jpgMy similar return pipe fmic. I have cut out all the plastic where the number plate was. Would probably look better without the bit of grill that I stuck in there but its more stealthy this way ;)
  • 10 months later...

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • I did end up getting it sorted, as GTSBoy said, there was a corroded connection and wire that needed to be replaced. I ended up taking out the light assembly, giving everything a good clean and re-soldered the old joints, and it came out good.
    • Wow, thanks for your help guys 🙏. I really appreciate it. Thanks @Rezz, if i fail finding any new or used, full or partial set of original Stage carpets i will come back to you for sure 😉 Explenation is right there, i just missed it 🤦‍♂️. Thanks for pointing out. @soviet_merlin in the meantime, I received a reply from nengun, and i quote: "Thanks for your message and interest in Nengun. KG4900 is for the full set of floor mats, while KG4911 is only the Driver's Floor Mat. FR, RH means Front Right Hand Side. All the Full Set options are now discontinued. However, the Driver's Floor Mat options are still available according to the latest information available to us. We do not know what the differences would be, but if you only want the one mat, we can certainly see what we can find out for you". Interesting. It seems they still have some "new old stock" that Duncan mentioned 🤔. I wonder if they can provide any photos......And i also just realized that amayama have G4900 sets. I'm tempted too. 
    • Any update on this one? did you manage to get it fixed?    i'm having the same issue with my r34 and i believe its to do with the smart entry (keyless) control module but cant be sure without forking out to get a replacement  
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if something was binding the shaft from rotating properly. I got absolutely no voltage reading out of the sensor no matter how fast I turned the shaft. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
    • So this being my first contribution to the SAU forums, I'd like to present and show how I had to solve probably one of the most annoying fixes on any car I've owned: replacing a speedometer (or "speedo") sensor on my newly acquired Series 1 Stagea 260RS Autech Version. I'm simply documenting how I went about to fix this issue, and as I understand it is relatively rare to happen to this generation of cars, it is a gigantic PITA so I hope this helps serve as reference to anyone else who may encounter this issue. NOTE: Although I say this is meant for the 260RS, because the gearbox/drivetrain is shared with the R33 GTR with the 5-speed manual, the application should be exactly the same. Background So after driving my new-to-me Stagea for about 1500km, one night while driving home the speedometer and odometer suddenly stopped working. No clunking noise, no indication something was broken, the speedometer would just stop reading anything and the odometer stopped going up. This is a huge worry for me, because my car is relatively low mileage (only 45k km when purchased) so although I plan to own the car for a long time, a mismatched odometer reading would be hugely detrimental to resale should the day come to sell the car. Thankfully this only occurred a mile or two from home so it wasn't extremely significant. Also, the OCD part of me would be extremely irked if the numbers that showed on my dash doesn't match the actual ageing of the car. Diagnosing I had been in communication with the well renown GTR shop in the USA, U.P.garage up near University Point in Washington state. After some back and forth they said it could be one of two things: 1) The speedometer sensor that goes into the transfer case is broken 2) The actual cluster has a component that went kaput. They said this is common in older Nissan gauge clusters and that would indicate a rebuild is necessary. As I tried to figure out if it was problem #1, I resolved problem #2 by sending my cluster over to Relentless Motorsports in Dallas, TX, whom is local to me and does cluster and ECU rebuilds. He is a one man operation who meticulously replaces every chip, resistor, capacitor, and electronic component on the PCB's on a wide variety of classic and modern cars. His specialty is Lexus and Toyota, but he came highly recommended by Erik of U.P.garage since he does the rebuilds for them on GTR clusters.  For those that don't know, on R32 and R33 GTR gearboxes, the speedometer sensor is mounted in the transfer case and is purely an analog mini "generator" (opposite of an alternator essentially). Based on the speed the sensor spins it generates an AC sine wave voltage up to 5V, and sends that via two wires up to the cluster which then interprets it via the speedometer dial. The signal does NOT go to the ECU first, the wiring goes to the cluster first then the ECU after (or so I'm told).  Problems/Roadblocks I first removed the part from the car on the underside of the transfer case (drain your transfer case fluid/ATF first, guess who found out that the hard way?), and noted the transfer case fluid was EXTREMELY black, most likely never changed on my car. When attempting to turn the gears it felt extremely gritty, as if shttps://imgur.com/6TQCG3xomething was binding the shaft from rotating properly. After having to reflow the solder on my AFM sensors based on another SAU guide here, I attempted to disassemble the silicone seal on the back of the sensor to see what happened inside the sensor; turns out, it basically disintegrated itself. Wonderful. Not only had the electrical components destroyed themselves, the magnetic portion on what I thought was on the shaft also chipped and was broken. Solution So solution: find a spare part right? Wrong. Nissan has long discontinued the proper sensor part number 32702-21U19, and it is no longer obtainable either through Nissan NSA or Nissan Japan. I was SOL without proper speed or mileage readings unless I figured out a way to replace this sensor. After tons of Googling and searching on SAU, I found that there IS however a sensor that looks almost exactly like the R33/260RS one: a sensor meant for the R33/R34 GTT and GTS-T with the 5 speed manual. The part number was 25010-21U00, and the body, plug, and shaft all looked exactly the same. The gear was different at the end, but knowing the sensor's gear is held on with a circlip, I figured I could just order the part and swap the gears. Cue me ordering a new part from JustJap down in Kirrawee, NSW, then waiting almost 3 weeks for shipping and customs clearing. The part finally arrives and what did I find? The freaking shaft lengths don't match. $&%* I discussed with Erik how to proceed, and figuring that I basically destroyed the sensor trying to get the shaft out of the damaged sensor from my car. we deemed it too dangerous to try and attempt to swap shafts to the correct length. I had to find a local CNC machinist to help me cut and notch down the shaft. After tons of frantic calling on a Friday afternoon, I managed to get hold of someone and he said he'd be able to do it over half a week. I sent him photos and had him take measurements to match not only the correct length and notch fitment, but also a groove to machine out to hold the retentive circlip. And the end result? *chef's kiss* Perfect. Since I didn't have pliers with me when I picked up the items, I tested the old gear and circlip on. Perfect fit. After that it was simply swapping out the plug bracket to the new sensor, mount it on the transfer case, refill with ATF/Nissan Matic Fluid D, then test out function. Thankfully with the rebuilt cluster and the new sensor, both the speedometer and odometer and now working properly!   And there you have it. About 5-6 weeks of headaches wrapped up in a 15 minute photo essay. As I was told it is rare for sensors of this generation to die so dramatically, but you never know what could go wrong with a 25+ year old car. I HOPE that no one else has to go through this problem like I did, so with my take on a solution I hope it helps others who may encounter this issue in the future. For the TL;DR: 1) Sensor breaks. 2) Find a replacement GTT/GTS-T sensor. 3) Find a CNC machinist to have you cut it down to proper specs. 4) Reinstall then pray to the JDM gods.   Hope this guide/story helps anyone else encountering this problem!
×
×
  • Create New...