Jump to content
SAU Community

Recommended Posts

Hey Paul, as discussed - I used to run 044 in tank, changed to Walbro 460 for e85. Nearly kept up with demand but was on the edge and needed surge tank for track. I considered a number of "big single" fuel pumps - but most American gear I looked at had "duty constraints". ie not to be run at full duty for more than X minutes..

also, mixed results on 'noise' depending on who you talk to. Have sat in a few cars with Aeromotive, Maganflow etc that all you could hear is fuel pump.

this is ok if its a track car only - but to me, even a track car with a quiet pump means you can hear 'other stuff' that you want to hear.. so if you can get performance AND have a quiet pump - then why wouldn't you. Considered speed controlling these and even bought a Fuelab to do just this but did not go ahead based on other factors.

I think there is something to be said for OEM manufacturers. Generally cheaper (replaceable easily), reliable, often quieter, less amps draw (sometimes).

Running e85, I wanted no 'corrosion' so surge tank had to be completely anodised throughout. There is anodising and there is anodising. You want Type 3 Hard anodising done if you get it done locally - this stands up best but it is not 'by default' what you get - you must ask for it.

All lines are Speedflow Series 200 Teflon lined. No corrosion and no smell.

I ended up running a radium surge tank which is well made, properly anodised throughout and holds 2x Walbro 460 e85 pumps. Could have fabbed our own but why reinvent the wheel when this was a good solution. I only switch the second pump on under high load, so it sees very little duty (so it should out last the main one). With e85, there is much less chance of engine damage if you lean it out... and remember a big single pump can still 'slow down' over its life, so the argument there is.... arguable. At least when #2 pump fails you know about it. A big single slowing could catch you out over time.

regarding lift pumps, people have mentioned you can use another Walbro 460 for that - BUT, check out their current draw. They draw big amps even with no load or pressure.. about 10A from memory. If you are at full noise with all three pumps going at 20A + 20A +10A you can be drawing 50A for fuel pumps! (admittedly only at certain times)... with all the other gear we're running and CDI/fans etc... you want to keep it down where you can

I use an e85 rate Pierburg Lift Pump which only draws about 2A and easily keeps the surge topped up.

End result is I have a fuel system that you cannot hear even if you put your ear to it. It is capable of well more than my cars puts down in HP.

Parts are easy to get locally for replacement. All pumps are submersed in fuel - which I also believe keeps them happier in terms of temp and environment. ......and the surge tank is pretty to look at. Bonus. :)

  • Like 4

Sure - its one of the most bling things on my car actually. Normally its all about function and lightweight, but went a bit overboard with a CNC aluminium "shelf" to fit a lithium battery, the relays (hidden behind battery when installed), surge tank and holders for the canisters from the AST Suspension.

The surge tank can take up to 3x Walbro 460 e85.. I run just the two. Pierburg 2A Lift pump in tank.

post-20408-0-90867700-1439988304_thumb.jpg

post-20408-0-66639400-1439988349_thumb.jpg

post-20408-0-94901300-1439988359_thumb.jpg

post-20408-0-08324700-1439988369_thumb.jpg

  • Like 8

I considered a number of "big single" fuel pumps - but most American gear I looked at had "duty constraints". ie not to be run at full duty for more than X minutes..

also, mixed results on 'noise' depending on who you talk to. Have sat in a few cars with Aeromotive, Maganflow etc that all you could hear is fuel pump.

Hater! :)

I have a Mangafuel Protuner 625 that doesn't need PWM and doesn't have runtime restrictions (I have done hundreds of KM's then done 1000m drag runs without issue) but it's a noisy f**ker. I'm constantly considering the same option as our male model friend here, twin Walbro 460 pumps. I had one in my last green car when they first came out, fantastic pumps and almost silent.

Edited by SimonR32

That setup is mint, Matty.

As I said on the phone today, i've bought one of those Holley dominator 1800 pumps. By all accounts it should satisfy everything that gets thrown at it.

Bit of an update.

I finally got the car home. Huge issues with injector baskets filling up with this super fine silt. Its small enough to get through the 23 micron filters I have post pumps. The baskets have been cleaned about 6 times, fuel filters twice. The intank pump was flogged so a Walbro 460 went in as a lift pump. Definitely a whole fuel system clean out is in order. I have a few large 6 micron fuel filters coming also.

The modified transfer case has settled the car down alot too. With the GT Pro in the rear set to medium, it was very taily. It feels much more planted, can get on the loud pedal earlier. Win win!

The tune has been relaxed also. Boost controller is turned off, 3 degrees of timing taken out and 6-7% more fuel across the entire map just to make it super safe with this fuel problem. It still went onto make 415rwkw. Did a comp test and its 190 psi across all 6 pots.

The box is great. Definately "woke" it up. The clutch is better than expected also.

28268977-DC49-4393-B984-34533CC3DFAB_zps

What the intank sock looked like.

7A4194A9-20D1-4329-9304-B668EE32112A_zps

Bit of box porn.

  • Like 3

Dang. You make me think dumping this old wore-out box on the curb and getting a fresher, younger, but more expensive box that may let me thrash it more before complaining.

Wait...we aren't talking about wives?

  • Like 2

http://vid1068.photobucket.com/albums/u457/Ptriffitt/F690A0AE-CCD6-4CEF-A3DD-3D47EE493AFF_zps0mlky3ck.mp4

For shits and giggles I took a video of the warm idle just before the compression test. On E85 you would hardly know it has cams in it.

http://vid1068.photobucket.com/albums/u457/Ptriffitt/D2CDE898-D824-4475-8145-56E87DFD29A6_zpsu2e9b2mn.mp4

A bit of box action. 415 KW, 19 PSI, super relaxed tune.

  • Like 4

http://vid1068.photobucket.com/albums/u457/Ptriffitt/F690A0AE-CCD6-4CEF-A3DD-3D47EE493AFF_zps0mlky3ck.mp4

For shits and giggles I took a video of the warm idle just before the compression test. On E85 you would hardly know it has cams in it.

http://vid1068.photobucket.com/albums/u457/Ptriffitt/D2CDE898-D824-4475-8145-56E87DFD29A6_zpsu2e9b2mn.mp4

A bit of box action. 415 KW, 19 PSI, super relaxed tune.

Well what can I say, your passenger said it all. :special:

Love that box , box Mmmmmmmmmmmm

  • Like 2

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Well, that's kinda the point. The calipers might interfere with the inside of the barrels 16" rims are only about 14" inside the barrels, which is ~350mm, and 334mm rotors only leave about 8mm outboard for the caliper before you get to 350, And.... that;s not gunna be enough. If the rims have a larger ID than that, you might sneak it in. I'd be putting a measuring stick inside the wheel and eyeballing the extra required for the caliper outboard of the rotor before committing to bolting it all on.
    • OK, so again it has been a bit of a break but it was around researching what had been done since I didn't have access to Neil's records and not everything is obvious without pulling stuff apart. Happily the guy who assembled the engine had kept reasonable records, so we now know the final spec is: Bottom end: Standard block and crank Ross 86.5mm forgies, 9:1 compression Spool forged rods Standard main bolts Oil pump Spool billet gears in standard housing Aeroflow extended and baffled sump Head Freshly rebuilt standard head with new 80lb valve springs Mild porting/port match Head oil feed restrictor VCT disabled Tighe 805C reground cams (255 duration, 8.93 lift)  Adjustable cam gears on inlet/exhaust Standard head bolts, gasket not confirmed but assumed MLS External 555cc Nismo injectors Z32 AFM Bosch 023 Intank fuel pump Garret 2871 (factory housings and manifold) Hypertune FFP plenum with standard throttle   Time to book in a trip to Unigroup
    • I forgot about my shiny new plates!
    • Well, apparently they do fit, however this wont be a problem if not because the car will be stationary while i do the suspension work. I was just going to use the 16's to roll the old girl around if I needed to. I just need to get the E90 back on the road first. Yes! I'm a believer! 🙌 So, I contacted them because the site kinda sucks and I was really confused about what I'd need. They put together a package for me and because I was spraying all the seat surfaces and not doing spot fixes I decided not to send them a headrest to colour match, I just used their colour on file (and it was spot on).  I got some heavy duty cleaner, 1L of colour, a small bottle of dye hardener and a small bottle of the dye top coat. I also got a spray gun as I needed a larger nozzle than the gun I had and it was only $40 extra. From memory the total was ~$450 ish. Its not cheap but the result is awesome. They did add repair bits and pieces to the quote originally and the cost came down significantly when I said I didn't need any repair products. I did it over a weekend. The only issues I had were my own; I forgot to mix the hardener into the dye two coats but I had enough dye for 2 more coats with the hardener. I also just used up all the dye because why not and i rushed the last coat which gave me some runs. Thankfully the runs are under the headrests. The gun pattern wasn't great, very round and would have been better if it was a line. It made it a little tricky to get consistent coverage and I think having done the extra coats probably helped conceal any coverage issues. I contacted them again a few months later so I could get our X5 done (who the f**k thought white leather was a good idea for a family car?!) and they said they had some training to do in Sydney and I could get a reduced rate on the leather fix in the X5 if I let them demo their product on our car. So I agreed. When I took Bec in the E39 to pick it up, I showed them the job I'd done in my car and they were all (students included) really impressed. Note that they said the runs I created could be fixed easily at the time with a brush or an air compressor gun. So, now with the two cars done I can absolutely recommend Colourlock.  I'll take pics of both interiors and create a new thread.
    • Power is fed to the ECU when the ignition switch is switched to IGN, at terminal 58. That same wire also connects to the ECCS relay to provide both the coil power and the contact side. When the ECU sees power at 58 it switches 16 to earth, which pulls the ECCS relay on, which feeds main power into the ECU and also to a bunch of other things. None of this is directly involved in the fuel pump - it just has to happen first. The ECU will pull terminal 18 to earth when it wants the fuel pump to run. This allows the fuel pump relay to pull in, which switches power on into the rest of the fuel pump control equipment. The fuel pump control regulator is controlled from terminal 104 on the ECU and is switched high or low depending on whether the ECU thinks the pump needs to run high or low. (I don't know which way around that is, and it really doesn't matter right now). The fuel pump control reg is really just a resistor that controls how the power through the pump goes to earth. Either straight to earth, or via the resistor. This part doesn't matter much to us today. The power to the fuel pump relay comes from one of the switched wires from the IGN switch and fusebox that is not shown off to the left of this page. That power runs the fuel pump relay coil and a number of other engine peripherals. Those peripherals don't really matter. All that matters is that there should be power available at the relay when the key is in the right position. At least - I think it's switched. If it's not switched, then power will be there all the time. Either way, if you don't have power there when you need it (ie, key on) then it won't work. The input-output switching side of the relay gains its power from a line similar (but not the same as) the one that feeds the ECU. SO I presume that is switched. Again, if there is not power there when you need it, then you have to look upstream. And... the upshot of all that? There is no "ground" at the fuel pump relay. Where you say: and say that pin 1 Black/Pink is ground, that is not true. The ECU trigger is AF73, is black/pink, and is the "ground". When the ECU says it is. The Blue/White wire is the "constant" 12V to power the relay's coil. And when I say "constant", I mean it may well only be on when the key is on. As I said above. So, when the ECU says not to be running the pump (which is any time after about 3s of switching on, with no crank signal or engine speed yet), then you should see 12V at both 1 and 2. Because the 12V will be all the way up to the ECU terminal 18, waiting to be switched to ground. When the ECU switches the fuel pump on, then AF73 should go to ~0V, having been switched to ground and the voltage drop now occurring over the relay coil. 3 & 5 are easy. 5 is the other "constant" 12V, that may or may not be constant but will very much want to be there when the key is on. Same as above. 3 goes to the pump. There should never be 12V visible at 3 unless the relay is pulled in. As to where the immobiliser might have been spliced into all this.... It will either have to be on wire AF70 or AF71, whichever is most accessible near the alarm. Given that all those wires run from the engine bay fusebox or the ECU, via the driver's area to the rear of the car, it could really be either. AF70 will be the same colour from the appropriate fuse all the way to the pump. If it has been cut and is dangling, you should be able to see that  in that area somewhere. Same with AF71.   You really should be able to force the pump to run. Just jump 12V onto AF72 and it should go. That will prove that the pump itself is willing to go along with you when you sort out the upstream. You really should be able to force the fuel pump relay on. Just short AF73 to earth when the key is on. If the pump runs, then the relay is fine, and all the power up to both inputs on the relay is fine. If it doesn't run (and given that you checked the relay itself actually works) then one or both of AF70 and AF71 are not bringing power to the game.
×
×
  • Create New...