Jump to content
SAU Community

Recommended Posts

I'm not sure why you removed the sound deadener??? 

Don't bother with DIY remedies... this is how you can do it properly.

For the lightly stained areas, just stick to a fine grade wet sand paper....and then paint over once the stain is gone.

For the worst areas...especially the pitted ones...you just need to sand the rust in the localised spot working down from a heavier grit to medium grit wet sandpaper, which will get most of the rust off. It's just localised rust from the spare wheel touching the boot. Don't go to town on sanding the whole boot...not needed! Try to avoid sanding the seam sealer etc (obviously)

After the rust spots are down to bare metal - use a fine brush dipped in "RUST DEOXIDISER"...and carefully apply this to the little rust areas. It's important the chemical you use is DEOXIDISER.

After applying that, let it sit for a while and obviously wipe off with prepsol before it dries, and repeat 3-4 times. If you go to a panel shop they will probably be able to sell you some - as the trade products are a shitload stronger than retail products.

After deoxidising the rust, scuff the surrounding paint with red scotch brite....& then you are ready to apply etch primer and then paint the matte gray colour on. Mask up the surrounding area using tape & paper..... as you don't need to paint the whole boot, just blend it in and keep the repair as small as possible. Spray can paint or spray gun depending on your level of expertise will be fine.

Probably will cost you about $100-$150 in materials.

 

  • Thanks 1
On 1/22/2022 at 7:23 PM, sonic99 said:

By the way, how do I remove these plastic clips in the boot? The arrow points up so I tried it with the arrows pointing down (and up) but I just can’t get it to move

B1F86815-B4C9-47C6-B694-19A0A792E749.jpeg

Try various orientations until it releases? I don't recall having any issues with those clips.

  • Thanks 1
On 23/1/2022 at 4:52 PM, GTSBoy said:

You may need to put something between the two pieces of trim to prise them apart while you turn the clip. There's no science here. They are very simple, just a little annoying sometimes.

Prise them apart with arrows pointing up or down? 😬

On 22/1/2022 at 11:12 PM, BakemonoRicer said:

I'm not sure why you removed the sound deadener??? 

Don't bother with DIY remedies... this is how you can do it properly.

For the lightly stained areas, just stick to a fine grade wet sand paper....and then paint over once the stain is gone.

For the worst areas...especially the pitted ones...you just need to sand the rust in the localised spot working down from a heavier grit to medium grit wet sandpaper, which will get most of the rust off. It's just localised rust from the spare wheel touching the boot. Don't go to town on sanding the whole boot...not needed! Try to avoid sanding the seam sealer etc (obviously)

After the rust spots are down to bare metal - use a fine brush dipped in "RUST DEOXIDISER"...and carefully apply this to the little rust areas. It's important the chemical you use is DEOXIDISER.

After applying that, let it sit for a while and obviously wipe off with prepsol before it dries, and repeat 3-4 times. If you go to a panel shop they will probably be able to sell you some - as the trade products are a shitload stronger than retail products.

After deoxidising the rust, scuff the surrounding paint with red scotch brite....& then you are ready to apply etch primer and then paint the matte gray colour on. Mask up the surrounding area using tape & paper..... as you don't need to paint the whole boot, just blend it in and keep the repair as small as possible. Spray can paint or spray gun depending on your level of expertise will be fine.

Probably will cost you about $100-$150 in materials.

 

I was going to pay someone to finish it all off. But after being quoted $700+ I’ll just follow your recommended steps and try and deal with it myself. Thanks again!!!

On 12/12/2021 at 10:34 PM, Robzilla32 said:

Remove the sound deadener with dry ice; wire wheel the rust marks; paint with kbs; reinstate the seam sealer; cover with new sound deadener

Will this wire wheel kit do ok? https://www.bunnings.com.au/josco-3-piece-drill-brush-kit_p6111235?store=5228
 

I’ve removed the carpet lining from the boot. Is there anything else I need to keep in mind so as not to cause any damage?

I’ve reached a point where I’m beginning to think I should have just left it as it was… so the question is… do I abort mission or keep going? Should I aim to remove all the discoloured spots around sealant also? How long is a piece of string?

This is where I’m at now 

4F213B37-47F8-4067-871B-ED0DC4F876E1.jpeg

247888AA-1BFB-41EE-A6EA-74A3A087B9AE.jpeg

6CFB9FAA-C930-40CA-82FD-DE1005548B26.jpeg

I did a bit more cleaning and this is where I’m at now…

I’ve concluded that the sealant parts that are discoloured aren’t necessarily rusty 😵💫

However, the parts circled red are rusty but I’m finding it difficult to get to them. Especially the only on top and the one next to the rubber seal down the bottom. Any tips on how and where to from here?

6A2D26B2-2606-46DB-9A20-3EF7C40C513D.jpeg

Remove any flake or loose rust with said wire brush.  Get a rust sealer like Septone and convert/seal the rust.  Use a quality primer and paint over the Septone areas.  Lastly paint the whole boot area, several coats, sanding lightly between dry coats.

This should take care of all the rust, boot paint quality, and your time for the next few months.

  • Thanks 1

I just did this on my hydraulic tank and subframe for a dumper.  The battery is right next to the tank and [from previous owners] acid spilled out and ate the tank away until I lost hydraulic fluid...so I took the tank out, cut the rust affected part out and replated...then I used a wire corded type brush on an angle grinder and got the rust off the subframe and the rest of the tank.  Then did the above steps in my previous posts.  With waiting for the prep/primer/paint to dry between coats etc it took me around 10-12 days...hot sunny days.  TBH I should have done it before, but 'if it ain't broke don't fix it' + laziness took over :).

 

  • Thanks 1

Gotta admit, I'm [like many others on here] sitting here scratching my head wondering what your doing and why.  The 'rust' you are having sleepless nights over is nothing.  Personally I think you have made a mountain of work for yourself.  Close the boot, open the bonnet and do work there.....thats where the go fast stuff lives!!!!

If you must, ,,,for that 'rust' under the car, coat it with Septone converter, then use an undertray primer/bitumen type paint and forget it.

https://www.repco.com.au/en/car-care-panel/paint/underbody/c/1862917956

https://www.supercheapauto.com.au/p/septone-septonechassis-black---1-litre/1411.html

  • Like 1
  • Thanks 1

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Bummer...yeah i "need" something to "ease" up the work and for my driving it would be enough.    Iam counting the tune "without" turbo. I do not mean "cheap" like something from Temu around 200 USD, "Cheap" is something around 1000 USD? 
    • Starter motors used to use the weight of metal (magnets) to provide torque. Now they use (more) current instead. This. It's completely normal.
    • So thing that had me stumped, but I think is OK....is that when it was up in the air, in neutral I had it running to bleed to coolant while I put the wheels back on. I noticed the rears were turning (slowly) which I'd never seen before 20250928_163512.mp4     Because there had been an issue with clutch slip due to pedal adjustment on the dyno, I assumed there was still and issue so spent some quality time upside down under the dash adjusting the pedal....but no matter what I did the wheels still turned in neutral. Even disconnected the master cylinder to pedal rod and same. In despair, I even removed the clutch slave so there was no chance of any preload causing it.....still happened. So either: 1. Something is not right in the bellhousing, or 2. Its a thing sometimes with cold, thick gearbox oil Internet says it might be 2, I hope so!
    • OK, few more things sorted and it is ready for a shakedown on 10-Oct, with one weird thing. Changed the run in oil and filter for the good stuff. 8l came out, about 8.5 went in with filter so that looks all good. Changed the starter (again), this time for a brand new one, works good. Interesting that the Taaaarks one is shorter than factory but spins harder, I guess electronics have moved on a little in the last 30 years. Will be nice to have a bit of extra space under there. Put the timing cover back on, and noted where the cam gears were set as a record.  Will need to double check the timing but it is pretty close. Also put the coil pack cover and intake snorkel back on. Exhaust Inlet Changed the water out for coolant, bled up nicely. Removed the rear brake pads (well worn factory sumitomo ones!), gave the hardware a good clean and reassembled. I've put bendix XP on the back again because the price is excellent at $150 a set and they worked well on the V37. Front pads have plenty so no issue there
×
×
  • Create New...