Jump to content
SAU Community

Recommended Posts

Hi all.

I had to chamge fuel pump due to car sitting for 10.years and went the 460. From memory it had the slightly smaller walbro in it previously. Running bosch 2200 injectors and a turbosmart compact fpr. Problem is no2 I can't get base pressure below 70psi. If I disconnect return line from fpr pressure drops indication restriction. I've inspected.the fuel line and removed the pipe on return line in tank and no chamge. Surely I'm not the only o e using stockings on a 460? Could the fpr be too small to handle the flow of new pump ? I'd like to sort it rather than going back.to smaller pump.

  • Like 1
Link to comment
https://www.sau.com.au/forums/topic/485437-walbro-460-in-r32-gtr/
Share on other sites

You got your answer when everything was OK after disconnecting your return line from the FPR. Why in the world are you running a 460, 2200CC injectors, etc. on stock 8mm lines? 

Keep the pump, ditch the lines. I used both 8mm lines as my feed and one of my Hicas 10mm lines as return. 

Edited by TurboTapin

I'm trying to maintain stock appearance . Hicas is still installed (although has lockout kit) did you retain factory fuel pump hat? If so I assume you used a bulkhead fitting or similar ?  I was also trying to avoid a full re design as it was previously dynoed at 426kw atw with same setup but different pump. Changing return line would also mean having to change ethanol sensor and fpr and possibly fuel rail. Not chasing more power in any way just reliability of the setup 

I've been running a 525 for years with the standard hat and FPR in the stagea (mine has a 32 gtr fuel rail and stagea and 32 hat and tank setup are the same) without an issue with base fuel pressure.

You said when you disconnected the return it is OK, did you do so at the fuel rail or the fuel hat? Either way I'd be looking for blockages or in the case of the tank kinks in the lines downstream

Note I did however have an issue with the current required for the 460 melting the fuel hat.

10 hours ago, TurboTapin said:

 Why in the world are you running a 460, 2200CC injectors, etc. on stock 8mm lines? 

Keep the pump, ditch the lines. I used both 8mm lines as my feed and one of my Hicas 10mm lines as return. 

I run 2 x 525 pumps on factory 8mm fuel lines :P    ... zero issues, staged of course 

 

Your setup should work fine, all you need to do is find the restriction. A good aftermarket fuel regulator is always a good idea too. If it's not your regulator i'd be suspicious of your fuel tank breather and your tank pressurising. Next would be something with the fuel hat. Then blow out the fuel lines. 

 

  • Like 1

I disconnected before the fuel pump and restriction still there. Disconnected at turbosmart fpr and also after ethanol sensor and pressure dropped. No kinks in line but I found one spot above diff that I can hear the fuel flowing while running so I'm wondering if there is built up corrosion  from 10 years of sitting.  I had injectors cleaned and tested and one was dead but rest were fine. Was never an issue when I owned the car previously but I'll talk to jez about his thoughts on if they should be changed to newer tech. Thx guys at least I know the setup should work again. Pump is wired directly to relay and not using factory plug any  more 

14 minutes ago, portaz said:

Pump is wired directly to relay

And I hope the relay receives the trigger signal from the ECU and not the ignition power.

It should prime and stop if the motor isn't running.

33 minutes ago, Dose Pipe Sutututu said:

And I hope the relay receives the trigger signal from the ECU and not the ignition power.

It should prime and stop if the motor isn't running.

Yep sure does . Comes on primes and cuts off as a factory pump would 

  • Like 1
On 4/19/2024 at 7:33 PM, Butters said:

I run 2 x 525 pumps on factory 8mm fuel lines :P    ... zero issues, staged of course 

 

Your setup should work fine, all you need to do is find the restriction. A good aftermarket fuel regulator is always a good idea too. If it's not your regulator i'd be suspicious of your fuel tank breather and your tank pressurising. Next would be something with the fuel hat. Then blow out the fuel lines. 

 

1x 8mm line cannot flow 525lph, let alone two pumps worth of it. Your first pump isn't being fully utilized and your second pump isn't doing anything at all.

 

 

Edited by TurboTapin
6 hours ago, TurboTapin said:

1x 8mm line cannot flow 525lph, let alone two pumps worth of it. Your first pump isn't being fully utilized and your second pump isn't doing anything at all.

 

I've read that before, really good article.

However my ~900hp+ at flywheel, means it can be done.

Also have tested it with one pump on only, does what you'd expect, near 700's flywheel.

No disagreement that i will have horrible pressure drop compared to what it would be on a bigger lines.  

I can also overwhelm the regulator / return line at low HP consumption with both on, but I don't do that, so no issue :) 

 

So horribly inefficient but it works really well for the 10 seconds or so the second pump is on. 

  • Like 1
14 hours ago, Butters said:

I've read that before, really good article.

However my ~900hp+ at flywheel, means it can be done.

Also have tested it with one pump on only, does what you'd expect, near 700's flywheel.

No disagreement that i will have horrible pressure drop compared to what it would be on a bigger lines.  

I can also overwhelm the regulator / return line at low HP consumption with both on, but I don't do that, so no issue :) 

 

So horribly inefficient but it works really well for the 10 seconds or so the second pump is on. 

I'm actually really impressed that you don't pop a pressure relief valve or find some other weak link in the system. This puts me at ease though, I want to run 5 bar differential at the injectors and flow enough for maybe 500 crank horsepower tops on E85. I'm really hoping that a single Fuelab 496 series pump will work for this.

1 hour ago, portaz said:

So I ran a new return line and upgraded in tank wiring to 6mm just in case and pressure is now adjustable thankfully. I may upgrade fuel.system down the  track but as its only 426kw atw that will.do for  now 

:cool:

what size was the return line?

  • 1 month later...
On 20/04/2024 at 8:33 AM, Butters said:

I run 2 x 525 pumps on factory 8mm fuel lines :P    ... zero issues, staged of course 

 

Your setup should work fine, all you need to do is find the restriction. A good aftermarket fuel regulator is always a good idea too. If it's not your regulator i'd be suspicious of your fuel tank breather and your tank pressurising. Next would be something with the fuel hat. Then blow out the fuel lines. 

 

How are you staging yours? I am running these 2.. and my fuel was heating up.. I had to stick a fan assisted cooler on the return.

4 hours ago, Predator1 said:

How are you staging yours? I am running these 2.. and my fuel was heating up.. I had to stick a fan assisted cooler on the return.

It's 2024, just PWM them instead of staging.

If OEMs are PWM, then you should too, especially with all the fancy ECUs on the market.

FWIW even my shit box with a mediocre ECU has PWM fuel pumps set up to ramp up and down with RPM x MAP.

On 4/22/2024 at 8:35 AM, joshuaho96 said:

I'm actually really impressed that you don't pop a pressure relief valve or find some other weak link in the system. This puts me at ease though, I want to run 5 bar differential at the injectors and flow enough for maybe 500 crank horsepower tops on E85. I'm really hoping that a single Fuelab 496 series pump will work for this.

If both pumps are only on at full tilt, and even better if he reduces the output of one pump with he other off for idle etc, then when both pumps are on for full tilt power, the injectors are diverting the fuel away from the fuel return line to a much nicer location, which will help keep fuel pressure lower as there's not a blockage/build up of liquid.

9 hours ago, Predator1 said:

How are you staging yours? I am running these 2.. and my fuel was heating up.. I had to stick a fan assisted cooler on the return.

using a map with TPS and duty cycle with a slight delay on the off. 

The second pump only really needs to come on when flat out. 

 

5 hours ago, Dose Pipe Sutututu said:

It's 2024, just PWM them instead of staging.

 

PWM is interesting, are you using a solid state relay ?

9 hours ago, Butters said:

PWM is interesting, are you using a solid state relay ?

Correct, I used to run 1x SSR for both pumps, but the inner OCD in me wanted 1x SSR per pump, so here we are :D 

image.thumb.png.53d63e2a478341f01c245a3f6e17981d.png

Flyback diodes built into the harness

image.thumb.png.912c5e79f6d7e57fb4df253d4a9f8a92.png

image.thumb.png.2d287a3e2bfea574f3184f0270908ba5.png

 

Here's my DC table

image.thumb.png.86e58259f9246a6a99712008df28173a.png

  • Like 4

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Hey Dave, welcome aboard! Good to see another soon-to-be Stagea owner here. The wagons are awesome — plenty of space, still got that Skyline DNA, and loads of potential if you’re into mods. Definitely post up pics when you get it, everyone here loves seeing new builds. What model/year are you looking at?
    • See if you can thermal epoxy a heatsink or two onto it?
    • The other problem was one of those "oh shit we are going to die moments". Basically the high spec Q50s have a full electric steering rack, and the povo ones had a regular hydraulic rack with an electric pump.  So couple of laps into session 5 as I came into turn 2 (big run off now, happily), the dash turned into a christmas tree and the steering became super heavy and I went well off. I assumed it was a tyre failure so limped to the pits, but everything was OK. But....the master warning light was still on so I checked the DTCs and saw – C13E6 “Heat Protection”. Yes, that bloody steering rack computer sitting where the oil cooler should be has its own sensors and error logic, and decided I was using the steering wheel too much. I really appreciated the helpful information in the manual (my bold) POSSIBLE CAUSE • Continuing the overloading steering (Sports driving in the circuit etc,) “DATA MONITOR” >> “C/M TEMPERATURE”. The rise of steering force motor internal temperature caused the protection function to operate. This is not a system malfunction. INSPECTION END So, basically the electric motor in the steering rack got to 150c, and it decided to shut down without warning for my safety. Didn't feel safe. Short term I'll see if I can duct some air to that motor (the engine bay is sealed pretty tight). Long term, depending on how often this happens, I'll look into swapping the povo spec electric/hydraulic rack in. While the rack should be fine the power supply to the pump will be a pain and might be best to deal with it when I add a PDM.
    • And finally, 2 problems I really need to sort.  Firstly as Matt said the auto trans is not happy as it gets hot - I couldn't log the temps but the gauge showed 90o. On the first day I took it out back in Feb, because the coolant was getting hot I never got to any auto trans issues; but on this day by late session 3 and then really clearly in 4 and 5 as it got hotter it just would not shift up. You can hear the issue really clearly at 12:55 and 16:20 on the vid. So the good news is, literally this week Ecutek finally released tuning for the jatco 7 speed. I'll have a chat to Racebox and see what they can do electrically to keep it cooler and to get the gears, if anything. That will likely take some R&D and can only really happen on track as it never gets even warm with road use. I've also picked up some eye wateringly expensive Redline D6 ATF to try, it had the highest viscosity I could find at 100o so we will see if that helps (just waiting for some oil pan gaskets so I can change it properly). If neither of those work I need to remove the coolant/trans interwarmer and the radiator cooler and go to an external cooler....somewhere.....(goodbye washer reservoir?), and if that fails give up on this mad idea and wait for Nissan to release the manual 400R
    • So, what else.... Power. I don't know what it is making because I haven't done a post tune dyno run yet; I will when I get a chance. It was 240rwkw dead stock. Conclusion from the day....it does not need a single kw more until I sort some other stuff. It comes on so hard that I could hear the twin N1 turbos on the R32 crying, and I just can't use what it has around a tight track with the current setup. Brakes. They are perfect. Hit them hard all day and they never felt like having an issue; you can see in the video we were making ground on much lighter cars on better tyres under brakes. They are standard (red sport) calipers, standard size discs in DBA5000 2 piece, Winmax pads and Motul RBF600 fluid, all from Matty at Racebrakes Sydney. Keeping in mind the car is more powerful than my R32 and weighs 1780, he clearly knows his shit. Suspension. This is one of the first areas I need to change. It has electronically controlled dampers from factory, but everything is just way too soft for track work even on the hardest setting (it is nice when hustling on country roads though). In particular it rolls into oversteer mid corner and pitches too much under hard braking so it becomes unstable eg in the turn 1 kink I need to brake early, turn through the kink then brake again so I don't pirouette like an AE86. I need to get some decent shocks with matched springs and sway bars ASAP, even if it is just a v1 setup until I work out a proper race/rally setup later. Tyres. I am running Yoko A052 in 235/45/18 all round, because that was what I could get in approximately the right height on wheels I had in the shed (Rays/Nismo 18x8 off the old Leaf actually!). As track tyres they are pretty poor; I note GTSBoy recently posted a porker comparo video including them where they were about the same as AD09.....that is nothing like a top line track tyre. I'll start getting that sorted but realistically I should get proper sized wheels first (likely 9.5 +38 front and 11 +55 at the rear, so a custom order, and I can't rotate them like the R32), then work out what the best tyre option is. BTW on that, Targa Tas had gone to road tyres instead of semi slicks now so that is a whole other world of choices to sort. Diff. This is the other thing that urgently needs to be addressed. It left massive 1s out of the fish hook all day, even when I was trying not too (you can also hear it reving on the video, and see the RPM rising too fast compared to speed in the data). It has an open diff that Infiniti optimistically called a B-LSD for "Brake Limited Slip Diff". It does good straight line standing start 11s but it is woeful on the track. Nismo seem to make a 2 way for it.
×
×
  • Create New...