Jump to content
SAU Community

Recommended Posts

I'd like to know your compression ratio. I had JE make my pistons for 8.5 to 1. I used 52cc for the combustion camber volume, measured the block height myself, and took the rest of the specs from Tomei. I just noticed that they list their rb24 pistons with a 5.2cc piston crown volume. http://www.tomei-p.co.jp/_2003web-catalogu...ston-specs.html

I believe the Tomei pistons have a 7.9/1 cr. Which seems likely to me since my 8.5/1 pistons have a 8.5cc dome and the Tomei's have a 5.2cc dome. I got my deck clearance by subtracting my rod length plus half the stroke plus the compression height from the block height. This gave me 0.0661" of deck clearance. After over boring to 82mm in my case this effectively increases the combustion chamber lowering the compression ratio. Then the dome brings it back up to the stock 8.5/1.

  • 3 weeks later...

Finally heard back from Ross pistons, below is the data they sent through to me.

Note its all in imperial

________________________________________________________________________

3.465 A dimension (for Ross engineering dept only)

56690 Ross Job Card (number on piston)

7/8/2008 Date Pro/Engineer program was run

TEST CP Program run by

0.326 Deck thickness major front

0.312 Deck thickness major rear

0.173 Minimum thickness under intake valve pocket

0.180 Minimum thickness under exhaust valve pocket

0.200 Minimum thickness at top of flat top / dome / dish

0.367 Minimum thickness of dish to top ring groove

0.251 Intake valve pocket to top ring groove

0.270 Exhaust valve pocket to top ring groove

Lox to oil ring groove

0.153 Skirt

N/A Side relief

Spark Plug notch

Spark Plug slot

0.114 Pin hole to side of pin boss

0.680 Pin engagement in pin bosses (each side)

Edited by murrayis
  • 2 weeks later...

Update:

My new intake plenum and SARD fuel rail arrived on Tuesday. I got them to make some mounts so I could use the SARD fuel rail on a rb20 plenum. I only have 2 pic's of the plenum atm.

post-23119-1216278067_thumb.jpg

post-23119-1216278132_thumb.jpg

I am Expecting my 6boost Manifold to arrive tonight once Kyle drops it off :P

Also forgot I received my new wastegate in the mail today fresh from the USA

IMAG022.JPG

Edited by murrayis

Well thanks to Kyle from 6Boost for dropping my new Exhaust Manifold off at 11:30 last night, I am now able to finish up the engine build as far as bolt on's go. Heres a couple of pics of the manifold, is A highmount T4 Split Pulse.

1.JPG

2.JPG

3.JPG

4.JPG

5.JPG

Cheers

Cameron

  • 3 weeks later...
Well thanks to Kyle from 6Boost for dropping my new Exhaust Manifold off at 11:30 last night, I am now able to finish up the engine build as far as bolt on's go. Heres a couple of pics of the manifold, is A highmount T4 Split Pulse.

1.JPG

2.JPG

3.JPG

4.JPG

5.JPG

Cheers

Cameron

any updates on the build?

Well yes there is, yesterday afternoon I was bored and had just got the last bits for the gearbox form nissan so put all that together and put the engine and box back in the car.

I must say I am never doing that again by myself! My poor engine crane paid the toll and has a nice arch in the beam now. I will post some pics a little later after i tidy it up abit.

Cameron

Heres a couple of pics, the engines pretty much just sitting in there at the moment

post-23119-1218155512_thumb.jpg post-23119-1218155531_thumb.jpg

post-23119-1218155589_thumb.jpg post-23119-1218155626_thumb.jpg

post-23119-1218155644_thumb.jpg post-23119-1218155659_thumb.jpg

Still have to finish off porting the intake manifold ot match the head its half done, then just a matter off mounting the gearbox up 100% running all the oil and water lines, and get a tailshaft.

Can anyone recommend a place around the western subs in brisbane who make tailshafts?

Edited by murrayis
  • 1 month later...

Ok so I am planning on getting the engine started this weekend. I just finished the wiring tonight and decided to turnthe key and jsut crank it over to move some oil around a couple of things i noticed.

1) Theres a hissing sound coming from the dip stick that slowly tappers down after you stop cranking like pressure build up and slowly leaking out

2) oil pressure guage on the dash doesnt move but the light does fliker a little bit

Is this normal for a fresh built engine? Or shold I be looking into it before I try to start it all?

Indeed it is, Not bad for a 1 week turn around from kyle. The only thing I had to do to the manifold was TIG on a 45 degree bend for the wastegate :)

you might want to be careful there, i remember someone else posting about doing something similar and it caused boost control issues

  • 3 weeks later...

Well the hot day it is here in Brisbane we decided to crank the engine over and get her running. After a bit aof head scratching of why the injectors weren't firing we jiggled the ecu wiring harness and all of a sudden they worked.

A couple of small things I have to sort out before it goes off the be tuned.

1) Retension the timing belt as its a little to tight and sitting a bit far back on the gears for our liking

2) Finish interncooler piping

3) make it run on 6 cyl instead of 5 :wacko:

Well I spent a good part of today checkeing all the electrical connections and cables in my car to do with the coils and injectors it all turned out fine, but came across the number 3 injector wasn;t firing where in previous tests it was.

Isolated the injector and disconnected all the coils so no chance of blowing myself up, i took the injector out to see if it was blocked which it wasnt put 12v directly onto it... nothing gave it a quick tap with a screwdriver and tried 12v again and ot mu surprise it clicked gave it 10 mins and tried it again and it clicked. So I installed it back into the fuel rail adjusted the tension on the timing belt while I was in there, also found the steel plate behind the crank sproket was rubbing on the oil pump so pressed that a bit flatter so it cleared the pump and put all the timing belt and balancer back in.

Fired her up after a nice BANG! that my poor puppy is still trying to recover from, still have to adjust the idle a tad as its still at 2000rpm. I recorded a lil vid of the sound of it sitting at 2k idling

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • I have no hard data to report, but I have to say, having driven it to work and back all week, mostly on wet roads (and therefore mostly not able to contemplate anything too outrageous anywhere)..... it is real good. I turned the boost controller on, with duty cycle set to 10% (which may not be enough to actually increase the boost), and the start boost set to 15 psi. That should keep the gate unpressurised until at least 15 psi. And rolling at 80 in 5th, which is <2k rpm, going to WOT sees the MAP go +ve even before it crosses 2k and it has >5 psi by the time it hits 90 km/h. That's still <<2.5k rpm, so I think it's actually doing really well. Because of all the not-quite-ideal things that have been in place since the turbo first went on, it felt laggy. It's actually not. The response appears to be as good as you could hope for with a highflow.
    • Or just put in a 1JZ, and sell me the NEO head 😎
    • Oh, it's been done. You just run a wire out there and back. But they have been known to do coolant temp sensors, MAP sensors, etc. They're not silly (at Regency Park) and know what's what with all the different cars.
    • Please ignore I found the right way of installing it thanks
    • There are advantages, and disadvantages to remapping the factory.   The factory runs billions of different maps, to account for sooooo many variables, especially when you bring in things like constantly variable cams etc. By remapping all those maps appropriately, you can get the car to drive so damn nicely, and very much so like it does from the factory. This means it can utilise a LOT of weird things in the maps, to alter how it drives in situations like cruise on a freeway, and how that will get your fuel economy right down.   I haven't seen an aftermarket ECU that truly has THAT MANY adjustable parameters. EG, the VAG ECUs are somewhere around 2,000 different tables for it to work out what to do at any one point in time. So for a vehicle being daily driven etc, I see this as a great advantage, but it does mean spending a bit more time, and with a tuner who really knows that ECU.   On the flip side, an aftermarket ECU, in something like a weekender, or a proper race car, torque based tuning IMO doesn't make that much sense. In those scenarios you're not out there hunting down stuff like "the best way to minimise fuel usage at minor power so that we can go from 8L/100km to 7.3L/100km. You're more worried about it being ready to make as much freaking power as possible when you step back on the loud pedal as you come out of turn 2, not waiting the extra 100ms for all the cams to adjust etc. So in this scenario, realistically you tune the motor to make power, based on the load. People will then play with things like throttle response, and drive by wire mapping to get it more "driveable".   Funnily enough, I was watching something Finnegans Garage, and he has a huge blown Hemi in a 9 second 1955 Chev that is road registered. To make it more driveable on the road recently, they started testing blocking up the intake with kids footballs, to effectively reduce air flow when they're on the road, and make the throttle less touchy and more driveable. Plus some other weird shit the yankee aftermarket ECUs do. Made me think of Kinks R34...
×
×
  • Create New...