Jump to content
SAU Community

Recommended Posts

  • Replies 246
  • Created
  • Last Reply

Top Posters In This Topic

Top Posters In This Topic

Posted Images

I always use 5, I have used 4 in the past but never really liked it. What are your thoughts on the 4?

I will have some more pics up in a couple of days of the welding I done on the weekend....more of the cast to raw aluminium and it turned out quite well and consistent which is most important.

I always use 5, I have used 4 in the past but never really liked it. What are your thoughts on the 4?

I will have some more pics up in a couple of days of the welding I done on the weekend....more of the cast to raw aluminium and it turned out quite well and consistent which is most important.

i really only use 5356 which i have had no problems with it, but i havent tried pipe/cast or sheet/cast with it.

ive used 4043 before but thats only good for cast repair,

i might grab 1kg of 4047 and compare it to the 5 series

Silly question, would you know if the RB20, RB20 or Rb26 fuel rails are interchangeable? I have an RB26 rail for my RB20 and after having a quick look at it i suspect its not going to work....despite my mates assurance he ran a scummy RB20 rail on his RB26.

One other thing, is there a reason why the runners are perpindicular to the plenum when you are going full custom?

For some reason I believe they do but not 100% sure since I usually make my own. I would just see if anyone else can confirm, I think the rb25's are not.

This has been proven over and over to produce the best results in terms of flow and consistency between runners with a correctly designed plenum.

looks great! just curious, how you manage to get the torch into tight spots like this? do you pull the tungsten out a fair bit, and wind up the gas flow to shield it more? or any secrets? :D

i'm also thinking for tighter spots too, like between runners in an ex manifold, etc..

I use a 20 size torch....being watercooled it is a lot smaller than the air cooler ones.

I have very rarely needed to extended the tungsten out of the cup or turn the gas flow up when welding aluminium....I usually just crank the amps up. I do though for stainless/mild steel and tight spots.

They are sandblasted prior to welding. If they are not blasted and you try to weld them, the impurities should only come from the cast and not from the oil on the inside of the runners. If that's what's happening you are using to much amps.

I used to weld them before blasting them but as you can see the result is just fine doing it before and this justifies not having to blast them afterwards as well.

You could ask what type of sand I use to blast them, but then I would be giving away all my little secrets :P

Ariel

hahaha fair enough :D

well its either soda or glass bead - as no garnet/crushed glass/oxide based blasting media will give that shine :)

you've given me enough hints so i should work the rest out myself :D cheers Ariel.

Chris

Guest
This topic is now closed to further replies.



  • Similar Content

  • Latest Posts

    • Next, remove the upper and lower radiator hoses, both are held with a spring clamp. While you are under there, tackle the Auto Trans cooler lines.  Again both are held on with spring clamps, and as mentioned above you should cap them on the radiator side with an 8mm cap, and on the car side loop them with a length of 8mm pipe - this will stop you losing a dangerous amount of AT fluid during the rest of the job If you've been meaning to add a sender for AT trans temp, this is a great time to do it; put a sender fitting into the passenger side line as that is the inlet to the cooler/radiator.
    • Next you need to remove the intake duct (as with pretty much every job on these cars), it is a series of clips you gently remove with a flat bladed screwdriver. They do get brittle with time and can break, and I have not found a decent quality aftermarket one that fits (they are all too soft or flimsy and don't last either) but the nissan ones are a couple of bucks each (ouch).  Once the clips are off (either 8 or 10, I didn't check) you lift the intake duct out and will see the reservoirs Undo the line into the radiator side cap (some bent needle nosed piers are awesome for spring clamps) and then remove the 4x 10m nuts that hold both in place.  I didn't get these pics, but remove the line under the radiator reservoir (spring clamp again) then remove that reservoir. Then you can get at the intake reservoir, same thing, spring clamp underneath then remove it. BTW This is a great time to put in a larger (+70%) combined reservoir that AMS makes..... https://www.amsperformance.com/product/q50-q60-red-alpha-coolant-expansion-tank/ They also make an Infiniti branded and part# version if that is your thing
    • To drain the Intake Heat Exchanger, there is a crappy drain plug in front of the driver's side front tyre: You should use the largest headed phillips screwdriver you had, and in my case I needed vice grips on the hose above as the plug was tight (tighter than it needed to be, since it has an o-ring seal).  After you have a tray down and open the drain, open the intake heat exchanger reservoir cap (drivers side one) and you should get a couple of litres of coolant To get to the radiator, you need to remove the plastic engine undertray. It is held on with a series of 10mm headed bolts and some clips. For the radiator, there is another type of crappy drain (kind of like a plastic banjo bolt) and you should attach a length of hose to direct the stream of coolant per this pic (otherwise the coolant hits the rad support and goes everywhere). The drain is on the rear of the radiator on the driver's side and a bit hard to find. Put a big tray or bucket down (5l won't be enough) and slowly unscrew the fitting by hand. You only want to remove it far enough for coolant to flow, it you unscrew it right out the whole fitting and direction pipe will come off and you will get a coolant bath (yum!). Undo the radiator reservoir cap and it should empty about 8l
    • So, this shouldn't be such a mission, but there were a few tricks so I thought I'd post up a DIY for it. This was on a Q50 Red Sport but I doubt any other V37 model is very different (maybe just less steps for the intake heat exchanger hoses) I pulled the radiator out to flush it because the car was running hot at the track, but obviously the same steps apply for changing a radiator for any reason including an upgrade. If you are removing the radiator, you of course need to drain and refill, so have 5+ litres of blue coolant ready. You also need to drain the intake heat exchanger to remove the radiator so you will need a couple of litres for that as well. You will also need something to deal with the auto transmission lines, I used 2x 8mm rubber caps on the radiator side, and a short length of 8mm pipe on the car side.....unless you can block these lines quickly you will loose AT fluid and it may be enough to hurt the transmission if you don't refill it. 2 other tools that really help dealing with coolant lines and spring clamps are Bent Needle Nose pliers Hose pliers Between them they will reduce the frustration (and injury) potential by about 1000% Other than that....lets go... "First, jack up your car". Yes really, and put it safely on stands. If you are not confident doing that you need to give this job to a mechanic
    • If the forester is anything like our old 2007 GTB Liberty, I could near on run ling Long's and "rate them", as no matter what, it just hung to the road, even when abusing it in a hard launch in the wet, or throwing it at corners.
×
×
  • Create New...