Jump to content
SAU Community

Recommended Posts

Hi guys,

There doesn't seem to be a great deal of information how best to mount an external gate off the exhaust housing.

I recently finished building a steam pipe manifold for my SR and deliberately didn't include an external gate as it makes the most sense to me to evenly bleed the exhaust gases from the highest pressure point, which would be the exhaust housing, plus i wanted to be a little different.

It doesn't seem to be all that common to mount the external gate off the housing, i am curious to how far i around on the housing i should weld it onto and also which way to face the pipe. A lot of the housing's i have seen face the pipe in the same direction to gas flow of the housing, but shouldnt the gate be mounted at a 90 so that it isnt the easiest path for the gases to travel?

Thanks

Link to comment
https://www.sau.com.au/forums/topic/451509-external-gate-in-exhaust-housing/
Share on other sites

the most optimal angle to not impede 'flow' i've attached a snipet from turbosmarts installation guide.

How have you managed to mount the gate like that on a standard low mount?

I have got a mate who is going to weld onto the cast housing but he only wants to weld on a 90" off the housing to ensure its strong and to allow the tig to get into there, which is going to make it hard to not impede the flow some what.

The other issue is my manifold is top mount, ideally to limit impeding flow i could come somewhere off where the housing starts to curl around after the straight to the flange, but i might be limited by space.

Mine is mounted off the exhaust housing. It probably could be better angled but I didnt really have the room. All good, seems to work fine:

20131024_173749_zps01749055.jpg

So you have ran this and have no problems? Because it seems to go in an opposite direction to the flow?

The logic is simple. When the wastegate is shut all of the exhaust will go through the turbo. When the wastgate opens if the path is not direct much (or too much) of the exhaust will continue to flow through the turbo leading to overboosting.

Here's how mine goes:

post-49463-0-52442300-1418017474_thumb.jpg

The optimal mounting is to improve gas flow, which increases top end power. Simply venting the pressure at a 90 may hold boost well enough, but the gains won't be as great in my experience.

This setup I do works very well, but I spend a lot of time die grinding the inside to get a smooth path into the gate. External gate housings are obviously preferred.

post-63525-0-05491300-1418045082_thumb.jpg

Thanks for all of the pictures and ideas guys,

It seems since it is a pressure system the angle doesn't greatly affect the ability to hold or vent boost, but isn't giving the best performance, but realistically my biggest issue is going to be space.

Obviously the shorter the runner to the waste gate the better, but should that be a priority over angle?

If you were running a GT30 internal, then switched to an external with optimal flow, power difference atw will be less then 10hp

The internals are at 90 deg, which isn't great but will really only overboost on big engines with a small (relative) turbo/housing, the Xr6t is an example.

  • Like 1

Well the TD06 10cm was good for around 50kw more. Smaller housings will react better to external gates as opposed to the 1.06 Garrett internal, and such a simple way to get the results of a good top mount.

I thought making 430kw from the stock rb25 manifold was proof enough... Don't mistake boost control with the gate's ability to flow.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now


  • Similar Content

  • Latest Posts

    • Yeah we keep on in the dailies, it is pretty poor how many animals get hit and the driver leaves without checking....have saved a couple of little ones over the years. Bit of a gruesome job though, pouches generally need to be cut open because they are so tight and often the joey doesn't realise mum is gone so they are still locked onto the teat. I checked the modules in front of the DS wheel where an oil cooler should go.... There is the radar unit - that can go for race use) One of the 2 HX water pumps, the silver cylinder. That needs to be kept but might be able to be relocated But the bad news, the big computer mounted vertically in front of the wheel (blocking any potential air exit) is the electric steering computer. That is required until/unless i do a hydraulic steering conversion, and in CAD based modern car design it is not like I can just pop a big unit like that somewhere else (plus the loom would be too short anywhere else too). So, the passenger side is OK to clear out (just use a smaller washer reservoir, potentially elsewhere), but the DS no beuno
    • Well, all the best with the new camry It was interesting to hear about the UK process, it is generally a lot more streamlined here with a shipping agent looking after all the import side (noting the exact final price can still be a surprise.....) and I've used a few different brokers on the japan (or US) side, and never had any trouble with any of them....luck of the draw I guess. You mentioned you didn't get the auction sheet (understandable since you bought it from a dealer, not auction), but I always try and get hold of that because they are pretty thorough. I've imported 2x R grade vehicles over the years and both were fine, repairs in Japan are pretty thorough compared to here in Oz.
    • BTW I measured the jack I have, it is 70mm at the saddle but you only have about 700 until it returns to 150mm high at the cylinder so it is good but no magic bullet.
    • My experience with Rising Sun Exports Before agreeing to the sale I tried to do as much research as I could (obviously), his Facebook reviews are 98% and he goes Live at least once or twice a week. I contacted 2 people in the UK who had used him for their imports, both had positive feedback. His explanation and talk through of the import process was thorough, answering any query no matter how stupid it was. It felt as soon as the money was sent, communication dropped off. I asked for shipping updates every 2 weeks or so, not wanting to pester him, he never had any updates. I wasn't informed the car had been dropped off at the port, I only found out by his Facebook story. I asked for the photos taken at the port, knowing he would need some for insurance purposes. I received a few 5 second clips and that's it. When asked again, he said his staff had them. Weeks later I asked again, he tells me he doesn't have any, but does have 50 photos from the original advert. I never received them. I eventually got the documents sent via WhatsApp after I mentioned the port was requesting them. I purchased a CarVX report, to find out the vehicle is a Grade R with recorded accident damage, first recorded in 2017 when it was first auctioned. He never told me the grade, then again I didn't ask. His response was "Grade R means nothing, it wasn't chassis damage". Still, I would have liked to have been informed about it. Jon prides himself on being open and honest when it comes to inspecting cars, it's his main job doing so at the auctions for customers. When the vehicle arrived in the UK I noticed a few little cosmetic issues. It's a 21 year old car so it wasn't going to be mint condition. The side skirts are cracked on each corner and the sealant is failing. The front grill on the bonnet/hood isn't secured very well, mounting studs are missing. Both minor things, but again, it would have been nice to be told. During a Facebook Live walk around video of the vehicle, he mentioned it has a front Whiteline anti roll bar/sway bar. While on the inspection ramp, I noticed the stock item has been installed. When first questioned, his response was "the ARB? Switched? Since when, it never had them". Since sending video and photo evidence I've not received a response. I'm probably being over critical of the overall condition of an old car, but all I wanted was honesty (which he claims to have). I'm aware I wasn't his only customer, he's busy doing XYZ but other reviews praise him for great communication with regular updates and photos, I felt I didn't receive the same treatment. 
    • I was able to get some underside photos while the car was on the ramp The suspension is all Altezza/IS200/IS300 so getting part's will hopefully be less of a headache
×
×
  • Create New...