Jump to content
SAU Community

Recommended Posts

You are correct, a loosely thrown around interval is 5000km, but that is largely dependant on the operator. Someone who is very skilled at changing gears in an H pattern dog box will cause little to no wear on the dog teeth faces. Same thing with a sequential with correctly setup strain gauge strategies correctly unloading the gears on shift, very little dog wear will occur. On the flip side someone just bashing a dog box around not shifting correctly will wear the flat sides of the dogs very quickly, to the point where they will jump out of gear on the slightest gear unload. This where km on box is not a good gauge for inspection, rather inspection intervals at X amount of hours, or x number events completed.

You are also correct in the dog gear replacement. The main shaft gears usually have dog teeth on the side an a separate sliding dog that matches to it. What you have to replace can only be determined on a box teardown, so it is not impossible to predict what you're likely to need. Sometimes with only slight wear on the dog teeth you can get prolong the gear or sliding dog needing replacement by regrinding the dog teeth from being rounded off to square again. This will buy you more time with needing to replace anything, but eventually round again and need to be replaced.

The biggest problem is that any of the above requires the box to be removed from the car, disassembled and inspected, possibly repaired, reassembled and reinstalled again - whether you replace anything or not. This is where the main cost in keeping a dog box alive is, not necessarily the cost of any parts that may or may not need to be replaced. When someone chooses to go dog engagement this has to be just accepted as the norm, and is the main reason why a synchro box makes more sense for a dedicated street only car.

  • Like 3

Thanks for the reply !  

These guys do a dog box with the rings seperate from the gears - https://www.6xdgearbox.com/

They suggest a dog is $300 ish AUD. 

 

Anything like that available for the GTR ?

 

info for anyone interested

 

 

  • 5 months later...

I have a new Series 3 box, haven't broken anything yet with around 700hp, I go easy into 3rd gear.

Have been tossing up about the sequentials.  Lately the word has been PPG = probably not, a few people who've had them haven't been too satisfied with how they hold up

A few big HP GTRs have switched to Samsonas and handling the power well.   Albins seems quite new to market, unsure how good they are and how they handle the power.  

Big money to drop on a gearbox.  I'm tossing up between Samsonas and Albins but will definitely want to know what's got the better track record on holding the power

Edited by RB335

Here's a quote I got for a PAR gear 1-4 straight cut syncro with stock 5th.

Note from the gearbox shop: 

"the PAR sets work well with the upgraded 26-spline input shaft. It does require you upgrade your clutch to match with the GM style input splines."
 
This means new clutch, labour involved to take the box out (if you cant do it yourself), shipping to send the box to the shop (if you don't have a decent gearbox builder in your state) and to send it back. It all adds up quickly.
There's a few guys in WA using PAR gear sets and are very happy with it.

gearbox quote.JPG

  • Like 1

updates, got my PPG dogbox back drives sooo much better :) after about 500km i can drive it without issues around town all different speeds, best way to explain is it loves direct shifts, it really isnt that bad to drive and i have to say once i got used to it i almost prefer it to a syncro box.

53 minutes ago, Greekos said:

2nd gear, 3/4 inner hub,1/2 outer hub dogs had the gear-set isf refinished, the pressure changing gears is almost like stock, so it was definitely a assembly issue that caused my grief

 

Do you mind uploading a video here mate? 

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Even more fun, leave all the ADAS stuff plugged in, but in different locations, hopefully avoid any codes!   And honestly, all these new cars with their weird electronics. Pull all the electronics out Duncan, and just shove an aftermarket ECU and if needed a trans controller in, along with a PDM. Make it run basic but race car styled!
    • To follow up a question from earlier too since I had the front bar off again (fking!) This is what is between the bumper and the drivers side wheel And this is the navigator side, only one thing but its a biggy! So basically....no putting coolers in the wheel arches without a lot of moving other stuff. Assuming I move to properly race prepping this car I'll take that job on and see how the computers respond to removing a whole bunch of ADAS modules
    • So I prepped the car for another track day on Wednesday (will be interesting to see coolant temps post flushing out and the larger reservoir, with a forecast of 3-14 being 20o cooler than last time I took it out). Couple of things to mention; since I am just driving the car and not taking a support vehicle, I took the rear seats out and just loaded the back up Team Trackday style. Look at all that space! To cover off removing the rear seat....it is weird (note the hybrid is probably different because it wouldn't have folding rear seats) Basically, you remove the lower seat base, very similar to a r series but it is a clip that pulls forward to release the base rather than it being bolted down. Easy Then, you need to remove the side section of the rear seat on each side. There is a 14mm head nut at the bottom of the side piece, the it slides upwards off a hook at the top to release; you also need to unhook the seatbelt from the loop at the top. Then the centre piece is weird. You need to release/fold the seats forward with the tab in the boot on each side From there, there are 2,x12mm headed bolts holding the rear of each seat to the folding bracket, under the trim between the rear seat and the boot (4x christmas tree clips there, they suck). The seat is out but you can see where the bolts attach to the bracket
    • As discussed in the previous post, the bushes in the 110 needed replacing. I took this opportunity to replace the castor bushes, the front lower control arm, lower the car and get the alignment dialled in with new tyres. I took it down to Alignment Motorsports on the GC to get this work done and also get more out of the Shockworks as I felt like I wasn't getting the full use out of them.  To cut a very long story short, it ended up being the case the passenger side castor arm wouldn't accept the brand new bush as the sleeve had worn badly enough to the point you could push the new bush in by hand and completely through. Trying a pair of TRD bushes didn't fix the issue either (I had originally gone with Hardrace bushes). We needed to urgently source another castor arm, and thankfully this was sourced and the guys at the shop worked on my car until 7pm on a Saturday to get everything done. The car rides a lot nicer now with the suspension dialled in properly. Lowered the car a little as well to suit the lower profile front tyres, and just bring the car down generally. Eternally thankful for the guys down at the shop to get the car sorted, we both pulled big favours from our contacts to get it done on the Saturday.  Also plugged in the new Stedi foglights into the S15, and even from a quick test in the garage I'm keen to see how they look out on the road. I had some concerns about the length of the LED body and whether it'd fit in the foglight housing but it's fine.  I've got a small window coming up next month where I'll likely get a little paint work done on the 110 to remove the rear wing, add a boot wing and roof wing, get the side skirt fixed up and colour match the little panel on the tail lights so that I can install some badges that I've kept in storage. I'm also tempted to put in a new pair of headlights on the 110.  Until then, here's some more pictures from Easter this year. 
    • I would put a fuel pressure gauge between the filter and the fuel rail, see if it's maintaining good fuel pressure at idle going up to the point when it stalls. Do you see any strange behavior in commanded fuel leading up to the point when it stalls? You might have to start going through the service manual and doing a long list of sensor tests if it's not the fuel system for whatever reason.
×
×
  • Create New...