Jump to content
SAU Community

Recommended Posts

Phew! My ATI is the 1000HP version so fingers crossed it's all good.

I'll be at the point of putting on thebalancer fairly soon so I'll soon know!

Thanks for the heads up.

Only done bits and pieces the last few days. Been bust doing family stuff for Christmas and went back to work between Chrissy and New Years.

Fit all my nice shiny new coolant pipes into the block. No corroded fittings for me thanks! Nothing worse than stuffing with coolant hoses under the inlet manifold.... I've got all new genuine coolant hoses to fit when I reassemble it all. The last hoses lasted 19 years so I'm sure the next lot will do much the same with how little I'll drive it.

DSC_0211.jpg

Head studs are all in so I'm nearly ready for some head....

DSC_0216.jpg

As a mini side project i had a bit of a tidy up of my sink area in the corner of the shed. Put up some $3 sheets of particle board and mounted a stainless splash back above the sink. Put up a shelf, a dart board and mounted one of my stupidly large quantity (about 8 or 9 at a guess) sets of spanners just to free up some space in my toolbox.

I'll give it a quick lick of paint later today if I can be bothered bearing the 40 degree temps out in the shed.

DSC_0215.jpg

I also need to confirm that my valve clearances are correct in the head before I bolt it on so that'll be another job for later. At some point during one of my two house moves some of the buckets fell out of the head and mixed up a few of the shims so I might need to swap a few around to get them all within spec. Annoying little things like that can be quite time consuming. Takes farking ages each time to take the cams in and out.

Valve clearances are a bit all over the shop so need to order some new shims.... Tried swapping a few shims around but still have a few clearances out of whack. Sick of pulling cams in and out a few times I'll tell you....

With slightly lumpier cams and heavy valve springs it's a bastard. I also discovered that with oversized valves and greater lift the valves can touch if the same lobes are at full lift on the same cylinder..... Thankfully no damage, could have been a costly discovery.

Finished off my little man cave sink corner-

DSC_0222.jpg

Rear plate and rear main in, sump adapter in place ready to be bolted on next foray into the shed. It needs to be done at the same time as the sump as there are bolts along the front and rear that go through the plate rather than locking the plate to the block like the rest of the flush cap head screws. The photos might explain what I mean (countersunk holes along the side and standard drilled holes front and back of the engine)....

DSC_0256.jpg

DSC_0255.jpg

I had a look at the sump and I've decided I'll attack it with the die grinder before putting it on as there is a bit of a lip (3-4mm) that would stop all of the oil draining out during an oil change. The claggy oil sitting on the bottom of the sump is the stuff you most want to get out so I'd rather avoid that if possible.

Looks a bit rough but hard to get into the sump with the die grinder!

DSC_0010_2.jpg

DSC_0008_2.jpg

Had to remove the standard studs out of the sump to allow for fitting the sump adapter. Trial fit the sump to check clearances and checked pickup depth to bottom of the sump. All looks pretty good. Sitting at about 10-11mm from the bottom so all good.

DSC_0012_2.jpg

DSC_0013_2.jpg

Trial fit the sump about 4 times which is a bloody arduous job! They're such a big heavy cumbersome thing! If it was evenly weighted (not with the diff hanging way out to one side) it would be a lot easier to manhandle but alas, it isn't, it's a prick!!

Still waiting on a few shims to tidy up some of the valve clearances a bit before I bolt the head on. I could put it on now but a lot easier getting cams in and out with the head on the bench. It makes it a lot easier checking the valve locations now that I know the intake and exhaust valves hit at full opening....

It's a frustrating part of the build at the moment, I'm getting lots done but it's all time consuming stuff modifying things to suit the different setup. When you strip an engine and just reassemble the same thing it's easy but when a lot of new things are thrown into the mix it makes it a lot more time consuming.

All part of the "fun" I guess!

  • 2 weeks later...

Im going to build one of these simps soon. As i did one for a rb25. And came out great

Seeing how i did it myself i wont have them little problems bung wise. Lol great build mate. Love this post. Keep up the good work.

  • 2 weeks later...

Didn't get a lot done the last few weeks. Always excuses popping up...

Anyway, here are some further progress pics-

Sump going on-

DSC_0022.jpg

DSC_0019.jpg

DSC_0025.jpg

Ready for the head to go on-

DSC_0035.jpg

Head on-

DSC_0042.jpg

DSC_0040.jpg

Yes they're two generations of Tomei timing gears. I actually kind of like the difference. Not that it'll matter once the trigger kit cam pickup goes on-

DSC_0039.jpg

Got my hoist bolted down and tidied up the shed a little bit anyway.... Just waiting for the electrician to come and wire it up and I'll be in heaven!

DSC_0031.jpg

DSC_0027.jpg

DSC_0030.jpg

I've got a week off work coming up so hopefully I can get a bit more done on the engine then.

  • Like 3
  • 1 month later...

I've been tied up concreting garden borders, fixing my Kubota tractor and generally piss farting around not concentrating on the car. My Datto 1200 ute finally made it's way to it's new home after being in storage at my parents place for 3 years. It was almost like a barn find it had that much dust and bird crap on it! It's another distraction I don't need. I've already started ordering parts for it....

DSC_0288.jpg

I've only done a few little bits and pieces on the engine. I'm prepared to be set alight by the haters here but I bought a Freddy intake manifold. A) to help with the aledged leaning off in cyl 6 and B) because it looks good! Performance wasn't a factor but if it helps then great! The quality was pretty shit. I had to get the mating faces of the two halves to the manifold machined as it was a bit warped. I also port matched it to the gaskets so it should flow perfectly now. In terms of the thickness of the alloy that I have seen questioned in the past it was fine. I drilled at tapped 2 holes in it for MAP and IAT sensors and it was plenty thick enough for that.

Hopefully get the intake manifold painted in the next few days and I can get stuck into it again.

Hoist in and car up-

DSC_0190.jpg

DSC_0178.jpg

Freddy-

DSC_0279.jpg

DSC_0282.jpg

Masked up ready for painting-

DSC_0290.jpg

I've "ceramic" (high temp paint anyway) coated my exhaust manifolds so we'll see how resilient that is. I need to heat cycle them to try and lock the paint in place-

DSC_0012.jpg

DSC_0014.jpg

A snap shot of my next 6 years of spare time....

DSC_0211.jpg

I'm getting reverse cycle air con installed in the next few weeks so hopefully that makes life a little more bearable all year round! Less excuses then anyway!

Painted the intake manifold last night. Going for wrinkle red. I can't find any photos of it done before so not sure how it's going to look with all of the engine covers, turbo pipe, etc in black and the intake red. Be nice if it looked (and went!) like a Ferrari!

Is it just me or does this photo make the manifold look like it's floating...... Nah, just me!

DSC_0291.jpg

First coat and cook-

DSC_0292.jpg

Finished. Didn't wrinkle quite as well as my past efforts have but I still like the textured look even without the wrinkles-

DSC_0296.jpg

DSC_0295.jpg

Next up I need to try and work out where the fark all the other little fiddly bits and pieces a) have got to after moving house twice since dismantling the engine and b) go on the engine! My recollection on both a) and b) are pretty bloody foggy after 3 1/2 years of being dismantled. I'll be relying on a lot of Google images and good old trial and error!

I set the goal of having it running by the end of March but sadly that is drawing near and not looking likely. If I can at least get everything done to the engine apart from bolting it back in then I'll be pretty happy.

  • Like 2

Didn't get much done this weekend which is shit considering it was a long weekend....

Painted the balance tube (??) section of the intake manifold. No prizes for guessing what type of paint..... I'm pretty sure the only items not wrinkle black will be the plenum of the intake and probably the fuel rail which will both be wrinkle red. I hate Essendon footy club so not sure about the colour scheme...

This section is pretty much ready to go onto the head now, just need to decide what happens with the throttle body section. It will be bloody hard to paint neatly so it might go in the too hard basket......

DSC_7096.jpg

DSC_7095.jpg

At some point I'm going to get over painting shit so stay tuned for some not painted stuff getting whacked on fairly shortly...

  • Like 1

Oh yeah, also I put all new genuine hoses under the intake manifold. If it worked for the last 20 years it's good enough for me to use genuine again! Cost an effing bomb though..... :dry:

DSC_0300.jpg

DSC_0301.jpg

  • Like 1

Nissan.

Probably could have saved money elsewhere (Amayama, etc) but one of my mates (unfortunately no longer) was spare parts manager at my local Nissan dealership so he always looked after me.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Even more fun, leave all the ADAS stuff plugged in, but in different locations, hopefully avoid any codes!   And honestly, all these new cars with their weird electronics. Pull all the electronics out Duncan, and just shove an aftermarket ECU and if needed a trans controller in, along with a PDM. Make it run basic but race car styled!
    • To follow up a question from earlier too since I had the front bar off again (fking!) This is what is between the bumper and the drivers side wheel And this is the navigator side, only one thing but its a biggy! So basically....no putting coolers in the wheel arches without a lot of moving other stuff. Assuming I move to properly race prepping this car I'll take that job on and see how the computers respond to removing a whole bunch of ADAS modules
    • So I prepped the car for another track day on Wednesday (will be interesting to see coolant temps post flushing out and the larger reservoir, with a forecast of 3-14 being 20o cooler than last time I took it out). Couple of things to mention; since I am just driving the car and not taking a support vehicle, I took the rear seats out and just loaded the back up Team Trackday style. Look at all that space! To cover off removing the rear seat....it is weird (note the hybrid is probably different because it wouldn't have folding rear seats) Basically, you remove the lower seat base, very similar to a r series but it is a clip that pulls forward to release the base rather than it being bolted down. Easy Then, you need to remove the side section of the rear seat on each side. There is a 14mm head nut at the bottom of the side piece, the it slides upwards off a hook at the top to release; you also need to unhook the seatbelt from the loop at the top. Then the centre piece is weird. You need to release/fold the seats forward with the tab in the boot on each side From there, there are 2,x12mm headed bolts holding the rear of each seat to the folding bracket, under the trim between the rear seat and the boot (4x christmas tree clips there, they suck). The seat is out but you can see where the bolts attach to the bracket
    • As discussed in the previous post, the bushes in the 110 needed replacing. I took this opportunity to replace the castor bushes, the front lower control arm, lower the car and get the alignment dialled in with new tyres. I took it down to Alignment Motorsports on the GC to get this work done and also get more out of the Shockworks as I felt like I wasn't getting the full use out of them.  To cut a very long story short, it ended up being the case the passenger side castor arm wouldn't accept the brand new bush as the sleeve had worn badly enough to the point you could push the new bush in by hand and completely through. Trying a pair of TRD bushes didn't fix the issue either (I had originally gone with Hardrace bushes). We needed to urgently source another castor arm, and thankfully this was sourced and the guys at the shop worked on my car until 7pm on a Saturday to get everything done. The car rides a lot nicer now with the suspension dialled in properly. Lowered the car a little as well to suit the lower profile front tyres, and just bring the car down generally. Eternally thankful for the guys down at the shop to get the car sorted, we both pulled big favours from our contacts to get it done on the Saturday.  Also plugged in the new Stedi foglights into the S15, and even from a quick test in the garage I'm keen to see how they look out on the road. I had some concerns about the length of the LED body and whether it'd fit in the foglight housing but it's fine.  I've got a small window coming up next month where I'll likely get a little paint work done on the 110 to remove the rear wing, add a boot wing and roof wing, get the side skirt fixed up and colour match the little panel on the tail lights so that I can install some badges that I've kept in storage. I'm also tempted to put in a new pair of headlights on the 110.  Until then, here's some more pictures from Easter this year. 
    • I would put a fuel pressure gauge between the filter and the fuel rail, see if it's maintaining good fuel pressure at idle going up to the point when it stalls. Do you see any strange behavior in commanded fuel leading up to the point when it stalls? You might have to start going through the service manual and doing a long list of sensor tests if it's not the fuel system for whatever reason.
×
×
  • Create New...