Jump to content
SAU Community

Recommended Posts

Plus I'm working on a VNT .82 rear housing for the G3s hopefully getting SS1PU's response with 330rwkws top end.

Eagerly awaiting results for this. Been tossing up between SS2 and G3 since we spoke but I'll watch how this devolps, VNT sounds like it will be pretty unreal to drive with.

Keep up the good work Stao :thumbsup:

with the SS2 and G3, do i have to send my turbo to you? i cant decide what one ile go for lol

Stao develops and produces them from scratch. send your turbo to him if you want it highflowed etc

G'day all,

Well I was going to wait until it was all done and dusted, but it would be the epic post of 2012. So I thought Id break up my Hypergear experience into a couple of posts;

Car is a Series 2 R33 with the following relevant mods

- 3" exhaust with metal cat

- Blitz return flow front mount

- Xtreme Cushion Button clutch

- Splitfire coil packs

- Alloy intake pipe with standard airbox

After running the standard turbo at 10psi for ages, I decided to try a Hypergear and bought the following goodies for the upgrade;

- Hypergear PU highflow (non SS1)

- S15 450(480)cc injectors

- Z32 AFM

- Gizzmo boost controller

So the car was pulled apart and turbo ordered. It took around 3 weeks for the turbo to arrive which gave me plenty of time to deal with some other little jobs;

I decided to replace all of the exhaust studs, as 2 had snapped in the head.

- Action Thread Repair came and pulled the broken studs out for $150

- New studs and a manifold gasket from Hornsby Nissan (great blokes) came to around $150

- The manifold REFUSED to go back on, so i needed to die grind the bolt holes out. This irritated ths shit out of me, as the manifold CAME OFF THERE a week earlier. Anyway, beware of this!

I also took the time to fit new injectors and seals

- Full set of Injector seals from Hornsby Nissan was $67

- One broken pintle cap replaced

Once the turbo arrived it was fitted up with relative ease. I note the following in terms of fitment;

- The water lines need to be 'encouraged' to fit. Mine seemed to fit okay with only a bit of massaging.

- The standard oil drain fitted and worked fine

- The dump pipe comes close to, but does not touch the air con drain. I heat wrapped the downpipe anyway.

- The whole exhaust was pushed backwards about 0.5- 1 inch

- It came with a standard compressor housing so my existing metal intake pipe fitted, but made it sit a little higher than normal.

With the piping all back on, the only fitment issue was with the whole piping arrangement now sitting higher. This meant that the standard crossover pipe does not fit down flush with its mounting bracket and the airbox snorkel no longer fits without hitting the bonnet. However, I'm sure I can massage/ manouevre it all to fit!

With it all fitted and running, the only noticable difference was that the exahust was alot deeper and louder. Oh, and that heatwrap f*&%ing stinks.

With that all done and sorted I had TOSHI come out to fit the temporary ECU before dyno tuning in a couple of weeks. TOSHI is a great bloke and I look forward to working with him in the coming weeks!

First run on the road and the car feels pretty good. There is nothing under about 4000 RPM, but from there boost builds quite quickly and it feels pretty quick. I am hanging out to get it tuned!!

Ultimately, it has been a little more costly than anticipated (to date) but that is to be expected. Hopefully all goes well on the dyno and no further headaches arise!

Anyway, just thought Id put my $0.02 up here in case anyone is interested.

Ill post up pics once it's all done.

Cheers

Chris

Highflow = standard housings bored out to fit larger wheels.

Highflow PU = standard housings bored out to their limits with even larger wheels. It's laggy but it does make a lot of power.

SS1 (super street, version 1) = a small, responsive turbo like the small HKS turbos ~230-240rwkw.

SS1PU = same turbo, sacrificing some response for more power ~250-270rwkw

Stao should make a chart detailing the product family and what the numbers/letters denote, because it can be confusing, but if you've been following the thread from the start, it does make sense. PU = powered up, like the "R" version of a turbo.

around 280rwkw easy?

lol

how will his "Hypergear PU highflow (non SS1)" make 280rwkw easy when everyone elses larger turbos are averaging 260?

LoL

I guess you didn't follow up this thread. the PU high flow is a ATR43G3 turbo built with a stock compressor housing and a .82 rear.

Means it has larger guts and bigger turbine housing then all of the SS turbos. I've made 287rwkws relatively easy out of it, the average I'm seeing is 280rwkws.

I've tested it. it made less power through out all rev range based on same boost. It just acted as a massive air leakage. Anti surge comp housing is not recommended unless the turbo is surging.

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now



  • Similar Content

  • Latest Posts

    • Here's the chart for fuel pressure vs. current draw, assuming your base fuel pressure is 3 bar and you run like 0.5bar boost on WOT, you should only momentarily hit 9amps here and there. (Ignore my prev post, I cannot read a chart these days it seems)
    • Those comp test results are not hideous. Whether they are accurate or not (ie, when that comp tester says 140 psi, is the real pressure120, 140 or 160?) is unknown to us. The state of the battery used to crank it over is unknown, etc etc. Many people around here would say that the absolute values and the spread are perfectly fine to just add boost and keep going. I personally would be happier with a narrower spread than that, but even the diff between 125 and 145 is not terrible. That one cylinder at 125 though, has probably copped some damage relative to the others. You should inspect the valves seeing as you've got it open. Do you know how to measure installed ring gaps? That, and an inspection of the rings themselves, is how you will determine whether they need to be replaced. If you're not good to do these things, take the block and the pistons and rings to a shop that is, and ask them for the go/no-go on them. Do the bores need a hone at all? If so, you might well be justified in getting some different pistons in order to get away from the ring supply problem. Whether you're happy to spend a lot more money right now, on more gear, rather than less money, but an amount that looks stupid given that you will only get a handful of rings in exchange for that money, is for you to decide.
    • also possibly backed up to my filler and shat down it! 🤣
    • Ok so i would love some advice here please, i purchased an R33 a few months back and its had a few mods done to the engine, its an RB25det running a Master ECU, 1200cc injectors, bigger turbo, oil cooler, oil filter relocation kit, Spool H-beam rods, acl/ross pistons. When i removed the motor from the vehicle (as its getting a respray) i thought i would compression test it and these are the following results. Cylinder 1-145psi, Cylinder 2-143psi, Cylinder 3-125psi, Cylinder 4-145psi, Cylinder 5-140psi, Cylinder 6-135psi this test was done with the motor on the ground and powering up the starter motor. I dropped the sump and found broken oil squirters on cylinder 3,5 and 6. I was told my rings are probably worn so i stripped the motor completely to get a new set of rings for it. The trouble is no one has these rings anywhere and they have to be custom made by Ross over in the states and will cost about $600+$200 delivery. My question is how can i tell if my rings are at fault and if they are still ok and is this price ok for a set of rings?
    • What sold me on Trailer Park Boys is this scene: Great stuff, just stay clear from the new Netflix production.
×
×
  • Create New...